# AD 2000-15-14: Remote Control Circuit Breakers - Type: Airworthiness directive - Status: Historical - Products: McDonnell Douglas MD-11 Series (all) - Effective: August 23, 2000 - Published: August 8, 2000, 65 FR 48362–48364 - Issued: July 28, 2000 - Issued as: Final rule; request for comments - Superseded by: [AD 2004-12-16](https://openairdocs.org/ad/2004-12-16) - Product type: Aircraft, Large airplane - Amendment: 39-11846 - Docket: 2000-NM-219-AD - Registered aircraft: 4 may be affected, by airframe or engine model (OpenAirDocs) - Official PDF: https://openairdocs.org/files/sha256/d1/03/d103eabd3c32dc1da71163813c9a868baf4839746b46917f6777912d2ce0832e (from https://www.govinfo.gov/content/pkg/FR-2000-08-08/pdf/00-19814.pdf) - Federal Register: https://www.federalregister.gov/documents/2000/08/08/00-19814/airworthiness-directives-mcdonnell-douglas-model-md-11-series-airplanes - FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/39E30AE78EE3D7FE86256A08006BFC10.0001 - DRS record last changed: August 7, 2025 - Page: https://openairdocs.org/ad/2000-15-14 ## Summary This amendment adopts a new airworthiness directive (AD) that is applicable to certain McDonnell Douglas Model MD-11 series airplanes. This action requires repetitive inspections to verify operation of the remote control circuit breakers (RCCB) of the alternating current (AC) cabin bus switch, and replacement of any discrepant RCCB with a new RCCB. This action is necessary to prevent propagation of smoke and fumes in the cockpit and passenger cabin due to an inoperable RCCB of the AC cabin bus switch during smoke and fume isolation procedures. This action is intended to address the identified unsafe condition. ## The airworthiness directive Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows: 1. The authority citation for part 39 continues to read as follows: ## Rule preamble ### Dates Effective August 23, 2000. The incorporation by reference of certain publications listed in the regulations is approved by the Director of the Federal Register as of August 23, 2000. Comments for inclusion in the Rules Docket must be received on or before October 10, 2000. ### Addresses Submit comments in triplicate to the Federal Aviation Administration (FAA), Transport Airplane Directorate, ANM-114, Attention: Rules Docket No. 2000-NM-219-AD, 1601 Lind Avenue, SW., Renton, Washington 98055-4056. Comments may be inspected at this location between 9 a.m. and 3 p.m., Monday through Friday, except Federal holidays. Comments may be submitted via fax to (425) 227-1232. Comments may also be sent via the Internet using the following address: 9-anm-iarcomment@faa.gov. Comments sent via fax or the Internet must contain “Docket No. 2000-NM-219-AD” in the subject line and need not be submitted in triplicate. Comments sent via the Internet as attached electronic files must be formatted in Microsoft Word 97 for Windows or ASCII text. The service information referenced in this AD may be obtained from Boeing Commercial Aircraft Group, Long Beach Division, 3855 Lakewood Boulevard, Long Beach, California 90846, Attention: Technical Publications Business Administration, Dept. C1-L51 (2-60). This information may be examined at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Transport Airplane Directorate, Los Angeles Aircraft Certification Office, 3960 Paramount Boulevard, Lakewood, California; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC. ### For further information contact Brett Portwood, Aerospace Engineer, Systems and Equipment Branch, ANM-130L, FAA, Transport Airplane Directorate, Los Angeles Aircraft Certification Office, 3960 Paramount Boulevard, Lakewood, California 90712-4137; telephone (562) 627-5350; fax (562) 627-5210. ### SUPPLEMENTARY INFORMATION As part of its practice of re-examining all aspects of the service experience of a particular aircraft whenever an accident occurs, the FAA has become aware of incidents in which certain remote control circuit breakers (RCCB) of the alternating current (AC) cabin bus switch failed when the switch was pushed to the “OFF” position. These incidents occurred on McDonnell Douglas Model MD-11 series airplanes. Investigation revealed that an inoperable RCCB may not trip open (disconnects cabin bus loads) when commanded during smoke and fume isolation procedures. Even though an RCCB may be inoperable, the cabin bus “OFF” overhead switch light could still illuminate, which could mislead the flightcrew that all cabin buses have been deenergized. An inoperable RCCB of the AC cabin bus switch during smoke and fume isolation procedures, if not corrected, could result in the propagation of smoke and fumes in the cockpit and passenger cabin. These incidents are not considered to be related to an accident that occurred off the coast of Nova Scotia involving a McDonnell Douglas Model MD-11 series airplane. The cause of that accident is still under investigation. ### Other Related Rulemaking The FAA, in conjunction with Boeing and operators of Model MD-11 series airplanes, is continuing to review all aspects of the service history of those airplanes to identify potential unsafe conditions and to take appropriate corrective actions. This airworthiness directive (AD) is one of a series of actions identified during that process. The process is continuing and the FAA may consider additional rulemaking actions as further results of the review become available. ### Explanation of Relevant Service Information The FAA has reviewed and approved Boeing Alert Service Bulletin MD11-24A181, dated June 27, 2000, which describes procedures for repetitive inspections to verify operation of the RCCB's of the AC cabin bus switch, and replacement of any discrepant RCCB with a new RCCB. ### Explanation of the Requirements of the Rule Since an unsafe condition has been identified that is likely to exist or develop on other McDonnell Douglas Model MD-11 series airplanes of the same type design, this AD is being issued to prevent propagation of smoke and fumes in the cockpit and passenger cabin due to an inoperable RCCB during smoke and fume isolation procedures. This AD requires accomplishment of the actions specified in the service bulletin described previously. ### Interim Action This is considered to be interim action until final action is identified, at which time the FAA may consider further rulemaking. ### Determination of Rule's Effective Date Since a situation exists that requires the immediate adoption of this regulation, it is found that notice and opportunity for prior public comment hereon are impracticable, and that good cause exists for making this amendment effective in less than 30 days. ### Comments Invited Although this action is in the form of a final rule that involves requirements affecting flight safety and, thus, was not preceded by notice and an opportunity for public comment, comments are invited on this rule. Interested persons are invited to comment on this rule by submitting such written data, views, or arguments as they may desire. Communications shall identify the Rules Docket number and be submitted in triplicate to the address specified under the caption ADDRESSES. All communications received on or before the closing date for comments will be considered, and this rule may be amended in light of the comments received. Factual information that supports the commenter's ideas and suggestions is extremely helpful in evaluating the effectiveness of the AD action and determining whether additional rulemaking action would be needed. Submit comments using the following format: • Organize comments issue-by-issue. For example, discuss a request to change the compliance time and a request to change the service bulletin reference as two separate issues. • For each issue, state what specific change to the AD is being requested. • Include justification ( e.g., reasons or data) for each request. Comments are specifically invited on the overall regulatory, economic, environmental, and energy aspects of the rule that might suggest a need to modify the rule. All comments submitted will be available, both before and after the closing date for comments, in the Rules Docket for examination by interested persons. A report that summarizes each FAA-public contact concerned with the substance of this AD will be filed in the Rules Docket. Commenters wishing the FAA to acknowledge receipt of their comments submitted in response to this rule must submit a self-addressed, stamped postcard on which the following statement is made: “Comments to Docket Number 2000-NM-219-AD.” The postcard will be date stamped and returned to the commenter. ### Regulatory Impact The regulations adopted herein will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, it is determined that this final rule does not have federalism implications under Executive Order 13132. The FAA has determined that this regulation is an emergency regulation that must be issued immediately to correct an unsafe condition in aircraft, and that it is not a “significant regulatory action” under Executive Order 12866. It has been determined further that this action involves an emergency regulation under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979). If it is determined that this emergency regulation otherwise would be significant under DOT Regulatory Policies and Procedures, a final regulatory evaluation will be prepared and placed in the Rules Docket. A copy of it, if filed, may be obtained from the Rules Docket at the location provided under the caption ADDRESSES. ## Affected data sheets (1) (OpenAirDocs) The type certificate data sheets whose models the AD names. - [TCDS A22WE](https://openairdocs.org/tcds/A22WE): The Boeing Company; names 1 of 11 models: MD-11 ## Registered aircraft it may apply to (OpenAirDocs) Matched by airframe and engine model; the AD's applicability may narrow it by serial number, part number or equipment. - Aircraft: 4 (4 by airframe model, 0 by engine model) - Makers: Mcdonnell Douglas 4 Models with the most aircraft: - [Mcdonnell Douglas MD-11](https://openairdocs.org/model/mcdonnell-douglas-md-11): 4 aircraft (airframe model) All 1 models: https://openairdocs.org/ad/2000-15-14/models.md Every aircraft: https://openairdocs.org/ad/2000-15-14/aircraft.md ## Related documents - [AD 2004-12-16](https://openairdocs.org/ad/2004-12-16): Remote Control Circuit Breakers (RCCB) of Alternating Current (AC) Cabin Bus Switch · Boeing MD-11 and MD-11F. Effective Jul 26, 2004. Supersedes this AD No proposed rule in this release led to it. Its text cites no advisory circulars or STCs. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.