# AD 46-23-03: Aileron control column fitting

- Type: Airworthiness directive
- Status: Current
- Products: Univair 415-C, 415-CD and 415-D
- Superseded by: Nothing supersedes this AD
- Product type: Aircraft, Small airplane
- Registered aircraft: 1,005 may be affected, by airframe or engine model (OpenAirDocs)
- FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/379237A04C2EA15786256A4D005DABAB.0001
- DRS record last changed: May 30, 2024
- Page: https://openairdocs.org/ad/46-23-03

## The airworthiness directive

46-23-03 ERCO: (Was Mandatory Note 3 of AD-718-6.) Applies Only to 415-C, -CD and -D Aircraft Serial Numbers 113 to 1306, Inclusive. To be accomplished immediately. Due to the possibility of a defective fitting on the upper end of the control column shaft (Erco P/N 415-52129) in the aileron control system, the system should be tested to a load of 94 pounds, applied at the periphery of the control wheel. The ailerons should be blocked for the test. Each control wheel should be tested. The neutral position of the wheel should be noted before the test and if undue slack exists in the system it should be tightened. After the test, again note the neutral position and, if the position has changed more than about 5 degrees, the control column (part number above) should be replaced. If, after the test, the neutral position is within about 5 degrees of the original position, the ailerons should be freed and the system operated with the nose wheel on and off the ground. If the systemoperated freely and a visual inspection indicates that the system is in good condition, no change is necessary. An appropriate logbook entry shall be made to indicate that the above has been complied with. (Erco Service Bulletin No. 7 covers this same subject.)

## Affected data sheets (2) (OpenAirDocs)

The type certificate data sheets whose models the AD names.

- [TCDS A-718](https://openairdocs.org/tcds/A-718): Univair Aircraft Corporation; names 2 of 2 models: 415-CD, 415-C
- [TCDS A-787](https://openairdocs.org/tcds/A-787): Univair Aircraft Corporation; names 1 of 8 models: 415-D

## Registered aircraft it may apply to (OpenAirDocs)

Matched by airframe and engine model; the AD's applicability may narrow it by serial number, part number or equipment.

- Aircraft: 1,005 (1,005 by airframe model, 0 by engine model)
- Makers: Ercoupe 772, Engineering & Research 200, Forney 20, Erco 12, Univair 1

Models with the most aircraft:

- [Ercoupe 415-C](https://openairdocs.org/model/ercoupe-415-c): 623 aircraft (airframe model)
- [Engineering & Research 415-C](https://openairdocs.org/model/engineering-research-415-c): 160 aircraft (airframe model)
- [Ercoupe 415-D](https://openairdocs.org/model/ercoupe-415-d): 101 aircraft (airframe model)
- [Ercoupe 415-CD](https://openairdocs.org/model/ercoupe-415-cd): 48 aircraft (airframe model)
- [Engineering & Research 415-D](https://openairdocs.org/model/engineering-research-415-d): 24 aircraft (airframe model)
- [Forney 415-C](https://openairdocs.org/model/forney-415-c): 17 aircraft (airframe model)
- [Engineering & Research 415-CD](https://openairdocs.org/model/engineering-research-415-cd): 16 aircraft (airframe model)
- [Erco 415-C](https://openairdocs.org/model/erco-415-c): 7 aircraft (airframe model)
- [Erco 415-D](https://openairdocs.org/model/erco-415-d): 4 aircraft (airframe model)
- [Forney 415-D](https://openairdocs.org/model/forney-415-d): 2 aircraft (airframe model)
- [Forney 415-CD](https://openairdocs.org/model/forney-415-cd): 1 aircraft (airframe model)
- [Erco 415-CD](https://openairdocs.org/model/erco-415-cd): 1 aircraft (airframe model)
- [Univair 415-D](https://openairdocs.org/model/univair-415-d): 1 aircraft (airframe model)

All 13 models: https://openairdocs.org/ad/46-23-03/models.md
Every aircraft: https://openairdocs.org/ad/46-23-03/aircraft.md

Its text cites no advisory circulars or STCs.

---
OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.