# AD 89-26-02: Inspect Rudder Control - Type: Airworthiness directive - Status: Current - Products: Boeing DC-9-11, DC-9-12, DC-9-13, DC-9-14, DC-9-15, DC-9-15F, DC-9-21, DC-9-31, DC-9-32, DC-9-32 (VC-9C), DC-9-32F, DC-9-32F (C-9A) and 11 more - Effective: January 13, 1990 - Superseded by: Nothing supersedes this AD - Product type: Aircraft, Large airplane - Amendment: 39-6418 - Docket: 89-NM-73-AD - Registered aircraft: 113 may be affected, by airframe or engine model (OpenAirDocs) - FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/1E9831BC4C956453862569F200700118.0001 - DRS record last changed: May 30, 2024 - Page: https://openairdocs.org/ad/89-26-02 ## The airworthiness directive 89-26-02 MCDONNELL DOUGLAS: Amendment 39-6418. Docket No. 89-NM-73-AD. Applicability: Model DC-9-10 through -80, Model MD88, and C-9 (Military) series airplanes, certificated in any category. Compliance: Required as indicated, unless previously accomplished. To preclude failure of the rudder control sector, accomplish the following: A. Within 60 days after the effective date of this airworthiness directive (AD), visually inspect the rudder control sector for cracks and acceptable wall thickness, in accordance with Figure 2 of McDonnell Douglas Alert Service Bulletin A27-302, dated February 17, 1989. 1. If no cracks are found and the wall thickness is more than .020 inch, no further action is required. 2. If cracks are found or if a wall thickness of .020 inch or less is found, prior to further flight, perform either a permanent or temporary repair or replace the rudder control sector, in accordance with the accomplishment instructions of McDonnellDouglas Service Bulletin A27-302, dated February 17, 1989. 3. If a temporary repair is performed, replace or permanently repair the rudder control sector within 6 months or 1,000 landings, whichever occurs earlier, in accordance with McDonnell Douglas Service Bulletin A27-302, dated February 17, 1989. B. Within 15 days after the inspection required by paragraph A., above, submit a report of findings, positive or negative, to the Los Angeles Aircraft Certification Office, Attention: ANM-108L, FAA, Northwest Mountain Region, 3229 East Spring Street, Long Beach, California 90806-2425. C. An alternate means of compliance or adjustment of the compliance times, which provides an acceptable level of safety, may be used when approved by the Manager, Los Angeles Aircraft Certification Office, FAA, Northwest Mountain Region. NOTE: The request should be forwarded through an FAA Principal Maintenance Inspector (PMI), who will either concur or comment and then send it to theManager, Los Angeles Aircraft Certification Office, FAA, Northwest Mountain Region. D. Special flight permits may be issued in accordance with FAR 21.197 and 21.199 to operate airplanes to a base in order to comply with the requirements of this AD. All persons affected by this directive who have not already received the appropriate service documents from the manufacturer may obtain copies upon request to McDonnell Douglas Corporation, 3855 Lakewood Boulevard, Long Beach, California 90846, Attention: Director of Publications, C2-165 (54-60). These documents may be examined at the FAA, Northwest Mountain Region, Transport Airplane Directorate, 17900 Pacific Highway South, Seattle, Washington, or the Los Angeles Aircraft Certification Office, 3229 East Spring Street, Long Beach, California. This amendment (39-6418, AD 89-26-02) becomes effective January 13, 1990. ## Affected data sheets (1) (OpenAirDocs) The type certificate data sheets whose models the AD names. - [TCDS A6WE](https://openairdocs.org/tcds/A6WE): The Boeing Company; names 20 of 25 models: DC-9-12, DC-9-15F, MD-88, DC-9-41, DC-9-13, DC-9-34F, DC-9-81 (MD-81), DC-9-33F… ## Registered aircraft it may apply to (OpenAirDocs) Matched by airframe and engine model; the AD's applicability may narrow it by serial number, part number or equipment. - Aircraft: 113 (113 by airframe model, 0 by engine model) - Makers: Mcdonnell Douglas 107, Douglas 6 Models with the most aircraft: - [Mcdonnell Douglas DC-9-83(MD-83)](https://openairdocs.org/model/mcdonnell-douglas-dc-9-83-md-83): 49 aircraft (airframe model) - [Mcdonnell Douglas DC-9-82(MD-82)](https://openairdocs.org/model/mcdonnell-douglas-dc-9-82-md-82): 22 aircraft (airframe model) - [Mcdonnell Douglas MD-88](https://openairdocs.org/model/mcdonnell-douglas-md-88): 14 aircraft (airframe model) - [Mcdonnell Douglas DC-9-87](https://openairdocs.org/model/mcdonnell-douglas-dc-9-87): 13 aircraft (airframe model) - [Mcdonnell Douglas DC-9-15F](https://openairdocs.org/model/mcdonnell-douglas-dc-9-15f): 3 aircraft (airframe model) - [Mcdonnell Douglas DC-9-33F](https://openairdocs.org/model/mcdonnell-douglas-dc-9-33f): 3 aircraft (airframe model) - [Douglas DC-9-83](https://openairdocs.org/model/douglas-dc-9-83): 1 aircraft (airframe model) - [Douglas DC9-15](https://openairdocs.org/model/douglas-dc9-15): 1 aircraft (airframe model) - [Douglas DC-9-15F](https://openairdocs.org/model/douglas-dc-9-15f): 1 aircraft (airframe model) - [Douglas DC-9-21](https://openairdocs.org/model/douglas-dc-9-21): 1 aircraft (airframe model) - [Douglas DC-9-32F](https://openairdocs.org/model/douglas-dc-9-32f): 1 aircraft (airframe model) - [Mcdonnell Douglas DC-9-32](https://openairdocs.org/model/mcdonnell-douglas-dc-9-32): 1 aircraft (airframe model) - [Mcdonnell Douglas DC-9-32F](https://openairdocs.org/model/mcdonnell-douglas-dc-9-32f): 1 aircraft (airframe model) - [Douglas DC-9-33F](https://openairdocs.org/model/douglas-dc-9-33f): 1 aircraft (airframe model) - [Mcdonnell Douglas DC-9-87 (MD-87)](https://openairdocs.org/model/mcdonnell-douglas-dc-9-87-md-87): 1 aircraft (airframe model) All 16 models: https://openairdocs.org/ad/89-26-02/models.md Every aircraft: https://openairdocs.org/ad/89-26-02/aircraft.md Its text cites no advisory circulars or STCs. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.