# AD 92-19-05: Thrust Reverser System - Type: Airworthiness directive - Status: Current - Products: Boeing 757-200 Series, 757-200CB Series, 757-200PF Series and 757-300 Series - Effective: November 17, 1992 - Superseded by: Nothing supersedes this AD - Product type: Aircraft, Large airplane - Amendment: 39-8363 - Docket: 92-NM-78-AD - Registered aircraft: 270 may be affected, by airframe or engine model (OpenAirDocs) - FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/30E96F75B9890A2E8625696E0064FB7E.0001 - DRS record last changed: May 30, 2024 - Page: https://openairdocs.org/ad/92-19-05 ## The airworthiness directive 92-19-05 BOEING: Amendment 39-8363. Docket No. 92-NM-78-AD. Applicability: Model 757 airplanes equipped with Pratt and Whitney PW2000 series engines; as listed in Boeing Alert Service Bulletin 757-78A0029, dated February 28, 1992; certificated in any category. Compliance: Required as indicated, unless accomplished previously. To prevent in-flight deployment of one thrust reverser sleeve on one engine, which could result in reduced controllability of the airplane, accomplish the following: (a) Within 180 days after the effective date of this AD, rework the flow control tee assembly in the deploy lines on both engine struts, by removal of the poppet valves; install a restrictor check valve in the stow and deploy lines on each thrust reverser sleeve; and perform a functional test of the thrust reverser system; in accordance with Boeing Alert Service Bulletin 757-78A0029, dated February 28, 1992. (b) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, Seattle Aircraft Certification Office (ACO), FAA, Transport Airplane Directorate. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, Seattle ACO. NOTE: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the Seattle ACO. (c) Special flight permits may be issued in accordance with FAR 21.197 and 21.199 to operate the airplane to a location where the requirements of this AD can be accomplished. (d) The modification shall be done in accordance with Boeing Alert Service Bulletin 757-78A0029, dated February 28, 1992. This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR Part 51. Copies may be obtained from Boeing Commercial Airplane Group, P.O. Box 3707, Seattle, Washington 98124-2207. Copies may be inspected at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC 20001. (e) This amendment becomes effective on November 17, 1992. ## Affected data sheets (1) (OpenAirDocs) The type certificate data sheets whose models the AD names. - [TCDS A2NM](https://openairdocs.org/tcds/A2NM): The Boeing Company; names 4 of 4 models: 757-200CB Series, 757-200PF Series, 757-300 Series, 757-200 Series ## Registered aircraft it may apply to (OpenAirDocs) Matched by airframe and engine model; the AD's applicability may narrow it by serial number, part number or equipment. - Aircraft: 270 (270 by airframe model, 0 by engine model) - Makers: Boeing 270 Models with the most aircraft: - [Boeing 757-232](https://openairdocs.org/model/boeing-757-232): 63 aircraft (airframe model) - [Boeing 757-224](https://openairdocs.org/model/boeing-757-224): 40 aircraft (airframe model) - [Boeing 757-222](https://openairdocs.org/model/boeing-757-222): 38 aircraft (airframe model) - [Boeing 757-223](https://openairdocs.org/model/boeing-757-223): 23 aircraft (airframe model) - [Boeing 757-236](https://openairdocs.org/model/boeing-757-236): 20 aircraft (airframe model) - [Boeing 757-251](https://openairdocs.org/model/boeing-757-251): 18 aircraft (airframe model) - [Boeing 757-351](https://openairdocs.org/model/boeing-757-351): 16 aircraft (airframe model) - [Boeing 757-231](https://openairdocs.org/model/boeing-757-231): 13 aircraft (airframe model) - [Boeing 757-324](https://openairdocs.org/model/boeing-757-324): 9 aircraft (airframe model) - [Boeing 757-200 SERIES](https://openairdocs.org/model/boeing-757-200-series): 7 aircraft (airframe model) - [Boeing 757-204](https://openairdocs.org/model/boeing-757-204): 6 aircraft (airframe model) - [Boeing 757-225](https://openairdocs.org/model/boeing-757-225): 5 aircraft (airframe model) - [Boeing 757-230](https://openairdocs.org/model/boeing-757-230): 4 aircraft (airframe model) - [Boeing 757-258](https://openairdocs.org/model/boeing-757-258): 3 aircraft (airframe model) - [Boeing 757-256](https://openairdocs.org/model/boeing-757-256): 3 aircraft (airframe model) - [Boeing 757-260PF](https://openairdocs.org/model/boeing-757-260pf): 2 aircraft (airframe model) All 16 models: https://openairdocs.org/ad/92-19-05/models.md Every aircraft: https://openairdocs.org/ad/92-19-05/aircraft.md Its text cites no advisory circulars or STCs. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.