# AD 99-23-22 R2: Transponders

- Type: Airworthiness directive
- Status: Current
- Products: Airbus A300 B2-1A, A300 B2-1C, A300 B2-203, A300 B2K-3C, A300 B4-103, A300 B4-203, A300 B4-2C, A310-203, A310-204, A310-221, A310-222, A310-304 and 65 more
- Effective: April 20, 2000
- Published: April 20, 2000, 65 FR 21133–21134
- Issued: April 7, 2000
- Issued as: Final rule; rescission
- Supersedes: [AD 99-23-22 R1](https://openairdocs.org/ad/99-23-22-R1)
- Superseded by: Nothing supersedes this AD
- Product type: Aircraft, Large airplane
- Amendment: 39-11686
- Docket: 2000-NM-81-AD
- Registered aircraft: 1,335 may be affected, by airframe or engine model (OpenAirDocs)
- Official PDF: https://openairdocs.org/files/sha256/87/62/876284d7000ff1f916d426e5e3f83c848575ddac257da319158206674826c59f (from https://www.govinfo.gov/content/pkg/FR-2000-04-20/pdf/00-9247.pdf)
- Federal Register: https://www.federalregister.gov/documents/2000/04/20/00-9247/airworthiness-directives-various-transport-category-airplanes-equipped-with-mode-c-transponders-with
- FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/28C2E0DBE4A3005A862571AA004CF432.0001
- DRS record last changed: May 30, 2024
- Page: https://openairdocs.org/ad/99-23-22-R2

## Summary

This amendment rescinds Airworthiness Directive (AD) 99-23-22 R1, which is applicable to various transport category airplanes equipped with Mode “C” transponder(s) with single Gillham code altitude input. That AD requires repetitive tests to detect discrepancies of the Mode “C” transponder(s), air data computer, and certain wiring connections; and corrective actions, if necessary. The requirements of that AD were intended to prevent false advisories that direct the flightcrew to change course and either climb or descend, which could result in the flightcrew deviating the airplane from its assigned flight path, and a possible mid-air collision. Since the issuance of that AD, test data have been collected that demonstrate that the repetitive tests are unnecessary.

## The airworthiness directive

### The Rescission

Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

1. The authority citation for part 39 continues to read as follows:

2. Section 39.13 is amended by adding an airworthiness directive removing amendment 39-11473.

99-23-22 R2 Transport Category Airplanes: Amendment 39-11686. Docket No. 2000-NM-81-AD. Rescinds AD 99-23-22 R1, Amendment 39-11473.

Applicability: Transport category airplanes, as listed below, certificated in any category, equipped with any Mode “C” transponder with single Gillham code altitude input, including, but not limited to, the transponder part numbers listed below. Whether a Mode “C” transponder has a single Gillham code altitude input may be determined by reviewing the transponder installation instructions.

Airplane Models

Airbus Industrie

A300

A310

British Aerospace

BAe Avro 146-RJ

BAe ATP

Fokker

F28 Mark 0070

F28 Mark 0100

F28 Mark 1000-4000

Lockheed

L-1011 TriStar

L-188 Electra

CASA

CN-235

Dassault Aviation

Mystere Falcon 50

Mystere Falcon 900

Mystere Falcon 200

Fan Jet Falcon Series G

Boeing (MDC)

DC-10-30

DC-10-40

DC-9

DC-9-81

DC-9-82

DC-9-83

DC-9-87

Boeing 707

Boeing 727

Boeing 737

Boeing 747

Bombardier

CL-215-1A10

CL-215-6B11

CL-600-1A11

CL-600-2A12

CL-600-2B16

Gulfstream

G1159 (G-II)

G-1159A (G-III)

G-IV

Mode “C” Transponder Part Numbers

Rockwell Collins

622-2224-001

622-2224-003

522-2703-001

522-2703-011

787-6211-001

787-6211-002

Bendix

066-1056-00

066-1056-01

066-1123-00

2041599-6508

Wilcox

97637-201

97637-301

IFF

APX-100

APX-101

This rescission is effective April 20, 2000.

## Rule preamble

### Effective date

April 20, 2000.

### For further information contact

Peter Skaves, Aerospace Engineer, Airplane and Flight Crew Interface Branch, ANM-111, FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 227-2795; fax (425) 227-1320.

### SUPPLEMENTARY INFORMATION

On November 4, 1999, the Federal Aviation Administration (FAA) issued AD 99-23-22, amendment 39-11418 (64 FR 61493, November 12, 1999), as revised by AD 99-23-22 R1, amendment 39-11473 (64 FR 70181, December 16, 1999), applicable to various transport category airplanes equipped with Mode “C” transponder(s) with single Gillham code altitude input. That AD requires repetitive tests to detect discrepancies of the Mode “C” transponder(s), air data computer, and certain wiring connections; and corrective actions, if necessary. That action was prompted by reports that, during level flight, the Traffic Alert Collision Avoidance System (TCAS II) issued false advisories that directed the flightcrew to change course and either climb or descend. Such false advisories, if not corrected, could result in the flightcrew deviating the airplane from its assigned flight path and a possible mid-air collision.

### Actions Since Issuance of Previous AD

The compliance time for the initial test of the Mode “C” transponder(s) with single Gillham altitude code input, as required by AD 99-23-22 R1, has passed. Therefore, the FAA assumes that the test has been conducted at least once, and all applicable corrective actions have been accomplished, on all transport category airplanes affected by that AD. The following is a summary of the airplane inspections and test results:

Aircraft Test Results (AD 99-23-22 R1)

Aircraft test results reviewed = 1,142

Aircraft passing tests without corrective action required = 1,055

Aircraft failing tests with corrective action required = 87

Percent of aircraft that failed the AD test = 7.6%

Aircraft Wiring/Avionics Failures

Mode “C” transponder failures = 49

Air Data Computer (ADC) failures = 14

Encoding altimeter failures = 3

Gillham code wiring failures = 1

Miscellaneous wiring failures = 8

Failures sources under review = 12

The results of the transponder tests required by AD 99-23-22 R1 revealed that numerous Mode “C” transponders failed the test, and many of the Mode “C” test failures have been determined to be caused by a particular transponder type. All other test failures reported by operators appear to be random and isolated.

The FAA concludes that continued repetitive tests on the applicable airplane models listed in AD 99-23-22 R1 are unnecessary since the corrective actions have been accomplished on all transport category airplanes identified in that AD.

In addition, the FAA has determined that the repetitive performance of the tests required by AD 99-23-22 R1 may result in increased or accelerated component wear, which could contribute to reports of incorrect airplane altitude.

### Future Rulemaking

Over 50 percent of the airplane test failures have been reported by operators to be caused by Mode “C” transponders. The FAA is conducting further reviews to determine whether a systematic root cause failure of that Mode “C” transponder exists. Based on the results of these reviews, the FAA may consider further rulemaking to address potential problems concerning the Mode “C” transponder.

### FAA's Determination

Because the results of the tests required by AD 99-23-22 R1 have identified and corrected the causes of the identified unsafe condition, and because repetitive performance of the test may increase or accelerate component wear and contribute to reports of incorrect airplane altitude, the FAA has determined that it is necessary to rescind AD 99-23-22 R1 to prevent operators from performing unnecessary and potentially harmful repetitive tests.

Since this action rescinds a requirement to perform unnecessary actions, it has no adverse economic impact and imposes no additional burden on any person. Therefore, notice and public procedures hereon are unnecessary, and the rescission may be made effective upon publication in the Federal Register.

## Affected data sheets (16) (OpenAirDocs)

The type certificate data sheets whose models the AD names.

- [TCDS A20WE](https://openairdocs.org/tcds/A20WE): The Boeing Company; names 12 of 14 models: 747-100B Series, 747SP Series, 747-400D Series, 747-400F Series, 747-200B Series, 747-200F Series, 747-300 Series, 747-200C Series…
- [TCDS A16WE](https://openairdocs.org/tcds/A16WE): The Boeing Company; names 9 of 17 models: 737-500 Series, 737-100 Series, 737-200C Series, 737-800 Series, 737-300 Series, 737-200 Series, 737-700 Series, 737-400 Series…
- [TCDS A35EU](https://openairdocs.org/tcds/A35EU): Airbus SAS; names 8 of 17 models: A310-203, A310-204, A310-221, A310-324, A310-322, A310-325, A310-304, A310-222
- [TCDS A20EU](https://openairdocs.org/tcds/A20EU): Fokker Services B.V.; names 6 of 6 models: F28 Mark 1000, F28 Mark 4000, F28 Mark 2000, F28 Mark 0070, F28 Mark 3000, F28 Mark 0100
- [TCDS A3WE](https://openairdocs.org/tcds/A3WE): The Boeing Company; names 6 of 6 models: 727-100 Series, 727 Series, 727-200 Series, 727-100C Series, 727-200F Series, 727C Series
- [TCDS 4A21](https://openairdocs.org/tcds/4A21): The Boeing Company; names 4 of 4 models: 707-100B Short Body, 707-200, 707-100 Long Body, 707-100B Long Body
- [TCDS 4A26](https://openairdocs.org/tcds/4A26): The Boeing Company; names 4 of 4 models: 707-300B Series, 707-400 Series, 707-300 Series, 707-300C Series
- [TCDS A23WE](https://openairdocs.org/tcds/A23WE): Lockheed Martin Corporation; names 4 of 4 models: L-1011-385-1-14, L-1011-385-3, L-1011-385-1, L-1011-385-1-15
- [TCDS A6WE](https://openairdocs.org/tcds/A6WE): The Boeing Company; names 4 of 25 models: DC-9-81 (MD-81), DC-9-83 (MD-83), DC-9-87 (MD-87), DC-9-82 (MD-82)
- [TCDS A49EU](https://openairdocs.org/tcds/A49EU): BAE Systems (Operations) Limited; names 3 of 6 models: Avro 146-RJ85A, Avro 146-RJ70A, Avro 146-RJ100A
- [TCDS 4A22](https://openairdocs.org/tcds/4A22): Lockheed Martin Corporation; names 2 of 2 models: 188A, 188C
- [TCDS A12EA](https://openairdocs.org/tcds/A12EA): Gulfstream Aerospace Corporation; names 2 of 7 models: G-1159A, G-1159
- [TCDS A46EU](https://openairdocs.org/tcds/A46EU): Dassault Aviation; names 2 of 3 models: Mystere-Falcon 900, Mystere-Falcon 50
- [TCDS A7EU](https://openairdocs.org/tcds/A7EU): Dassault Aviation; names 2 of 11 models: Mystere-Falcon 200, Fan Jet Falcon Series G
- [TCDS A21NM](https://openairdocs.org/tcds/A21NM): Airbus Defense and Space S.A.; names 1 of 5 models: CN-235
- [TCDS A27NM](https://openairdocs.org/tcds/A27NM): BAE Systems (Operations) Limited; names 1 of 1 models: ATP

## Registered aircraft it may apply to (OpenAirDocs)

Matched by airframe and engine model; the AD's applicability may narrow it by serial number, part number or equipment.

- Aircraft: 1,335 (1,335 by airframe model, 0 by engine model)
- Makers: Boeing 917, Dassault 140, Mcdonnell Douglas 85, Dassault-Breguet 82, Gulfstream Aerospace 32, Gulfstream American 29, British Aerospace 12, Grumman 8, Lockheed 8, Airbus Industrie 4

Models with the most aircraft:

- [Boeing 737-823](https://openairdocs.org/model/boeing-737-823): 278 aircraft (airframe model)
- [Boeing 737-800](https://openairdocs.org/model/boeing-737-800): 139 aircraft (airframe model)
- [Boeing 737-824](https://openairdocs.org/model/boeing-737-824): 135 aircraft (airframe model)
- [Dassault MYSTERE-FALCON 50](https://openairdocs.org/model/dassault-mystere-falcon-50): 88 aircraft (airframe model)
- [Dassault-Breguet MYSTERE FALCON 900](https://openairdocs.org/model/dassault-breguet-mystere-falcon-900): 73 aircraft (airframe model)
- [Boeing 737-832](https://openairdocs.org/model/boeing-737-832): 73 aircraft (airframe model)
- [Boeing 737-890](https://openairdocs.org/model/boeing-737-890): 60 aircraft (airframe model)
- [Dassault MYSTERE FALCON 900](https://openairdocs.org/model/dassault-mystere-falcon-900): 52 aircraft (airframe model)
- [Mcdonnell Douglas DC-9-83(MD-83)](https://openairdocs.org/model/mcdonnell-douglas-dc-9-83-md-83): 49 aircraft (airframe model)
- [Boeing 737-724](https://openairdocs.org/model/boeing-737-724): 36 aircraft (airframe model)
- [Gulfstream Aerospace G-1159A](https://openairdocs.org/model/gulfstream-aerospace-g-1159a): 32 aircraft (airframe model)
- [Gulfstream American G-1159A](https://openairdocs.org/model/gulfstream-american-g-1159a): 27 aircraft (airframe model)
- [Mcdonnell Douglas DC-9-82(MD-82)](https://openairdocs.org/model/mcdonnell-douglas-dc-9-82-md-82): 22 aircraft (airframe model)
- [Boeing 737-790](https://openairdocs.org/model/boeing-737-790): 14 aircraft (airframe model)
- [Boeing 737-752](https://openairdocs.org/model/boeing-737-752): 13 aircraft (airframe model)
- [Mcdonnell Douglas DC-9-87](https://openairdocs.org/model/mcdonnell-douglas-dc-9-87): 13 aircraft (airframe model)
- [British Aerospace AVRO 146-RJ85A](https://openairdocs.org/model/british-aerospace-avro-146-rj85a): 12 aircraft (airframe model)
- [Boeing 747-446](https://openairdocs.org/model/boeing-747-446): 10 aircraft (airframe model)
- [Boeing 727-223](https://openairdocs.org/model/boeing-727-223): 9 aircraft (airframe model)
- [Dassault-Breguet MYSTERE FALCON 200](https://openairdocs.org/model/dassault-breguet-mystere-falcon-200): 9 aircraft (airframe model)

All 109 models: https://openairdocs.org/ad/99-23-22-R2/models.md
Every aircraft: https://openairdocs.org/ad/99-23-22-R2/aircraft.md

## Related documents

- [AD 99-23-22 R1](https://openairdocs.org/ad/99-23-22-R1) (historical): Transponders · Transport Category Transponders. Effective Nov 29, 1999. Replaced by this AD

No proposed rule in this release led to it. Its text cites no advisory circulars or STCs.

---
OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.