# Service difficulty reports: N38459

A list on [N38459](https://openairdocs.org/aircraft/N38459.md).

Matched to this aircraft by N-number and event date, checked against the reported serial number, make and model. Newest first.

- [SDR CALA2026052516514](https://openairdocs.org/sdr/CALA2026052516514.md): Battery Pack · inoperative · May 24, 2026 · N38459 · Boeing 737924ER · Emergency Lighting
  > EMERGENCY EXIT LIGHTS ON AFT RIGHT SERVICE DOOR NOT ILLUMINATING. TROUBLESHOOT WITH AWD 33-51-14-5 SUSPECTED BAD BATTERY, SLAVED IN BATTERY FROM LEFT SIDE, LIGHTS WORKED NORMALLY, PUT LEFT BATTERY BACK AND REMOVED THE INOP RIGHT SIDE BATTERY FROM AC, CORRIS
- [SDR CALA2025090208365](https://openairdocs.org/sdr/CALA2025090208365.md): Acm · seized · Aug 30, 2025 · N38459 · Boeing 737924ER · Cabin Cooling System
  > DURING LANDING ROLL A STRONG ACRID SMOKE SMELL WAS NOTICED. BRAK ES SUSPCTD ADDED PHOTOS OF SMOKE REPORT FORM. INSPECTED BRAKES, NO DEFECTS NOTED. CREW REPORTED SMELL DISSIPATED DURING TAXI IN. SUSPECT CONSTRUCTION FUMES. ACCOMPLISHED GROUND CHECKS AS REQUIR
- [SDR CALA2025081907939](https://openairdocs.org/sdr/CALA2025081907939.md): Light · detached · Aug 18, 2025 · N38459 · Boeing 737924ER · Emergency Lighting
  > EMER EXIT LIGHT AT 20C IS HANGING OFF OF THE SEAT REPLACED END BAY BUMPER AND SECURED EMERGENCY LIGHT AT SEAT 20C REF CMM 25-21-58. OPS CHECK OF EMERGENCY LIGHTS GOOD IAW AMM 33-51-00.
- [SDR CALA2025010201748](https://openairdocs.org/sdr/CALA2025010201748.md): Seal · damaged · Dec 29, 2024 · N38459 · Boeing 737924ER · Passenger/Crew Doors
  > LOUD SQUEEL FROM DR 1L DURING THE INITIAL EVALUATION, FOUND A MINOR DAMAGES ON THE BOTTOM OF THE SEAL ATTACHED PICTURE SEAL IT IS DEFORMED, NO FOLLOWING THE CORRECT CONTORN OF THE DOOR PERFORMED SEAL REPAIR PROCEDURES IAW AMM 52-09-10-350-0801. AND SEAL WAS IN
- [SDR CALA2024091602433](https://openairdocs.org/sdr/CALA2024091602433.md): Angle · cracked · Sep 10, 2024 · N38459 · Boeing 737924ER · Fuselage Miscellaneous Structure
  > AREA UNDER WING TO BODY FAIRING, 191AR SUPPORT FRAME CRACKED AT THE UPPER AREA. REF AAR N/R:9905044
- [SDR CALA2024091102408](https://openairdocs.org/sdr/CALA2024091102408.md): Floorbeam · corroded · Sep 10, 2024 · N38459 · Boeing 737924ER · Fuselage Main, Floor Beam
  > CORROSION,ON FLOOR STRUCTURE IN AFT WET AREA AT BS 993,RBL 40. WL 208.1 REF. AAR N/R:9904848
- [SDR CALA2024091002406](https://openairdocs.org/sdr/CALA2024091002406.md): Fairing · cracked · Sep 9, 2024 · N38459 · Boeing 737924ER · Nacelle/Pylon, Main Frame
  > NO.2 ENGINE AFT FIXED FAIRING AFT EDGE CRACKED REF AAR N/R 9904799.
- [SDR CALA2023100402940](https://openairdocs.org/sdr/CALA2023100402940.md): Battery · failed · Oct 4, 2023 · N38459 · Boeing 737900ER · Emergency Lighting
  > EMERGENCY BATTERY PACK AT M1676 NIT HOLDING CHARGE REMOVED AND REPLACED BATTERY PACK IAW AMM CH 33-51-06. OPS CHECK GOOD.
- [SDR CALA2023100402939](https://openairdocs.org/sdr/CALA2023100402939.md): Battery Pack · failed · Oct 4, 2023 · N38459 · Boeing 737900ER · Emergency Lighting
  > EMERGENCY BATTER PACK AT M1675 NOT HOLDING CHARGE REMOVED AND REPLACED BATTERY PACK PER REF. AMM 33-51-06 OP CHECK GOOD PARTS USED: 99-3351-3-0015,QTY:1
- [SDR CALA2023070702189](https://openairdocs.org/sdr/CALA2023070702189.md): Regulator · inoperative · Jul 4, 2023 · N38459 · Boeing 737900ER · Compressor Bleed Valve
  > LEFT BLEED TRIP OFF DOES NOT RESET WITH CHECKLIST LEFT BLEEDTRIP IS A PREVIOUS OOS CONDITION AND A CURRENT A/R. THIS ITEM IS LOCKED FOR CONFIRMATION OF A POSITIVE FIX. TOMC BILSKI. PILOT INFO STATES THAT "BLEED TRIP OFF" LIGHT CAME AT 10,000 FT AHM UPDATE: ADD
- [SDR CALA2022071501763](https://openairdocs.org/sdr/CALA2022071501763.md): Fire Detector · warning message · Jul 15, 2022 · N38459 · Boeing 737924ER · Smoke Detection
  > NO. 2 ENGINE OVERHEAT LIGHT AND MASTER CAUTION ILLUM ON CLIMB. L IGHT EXT W/ THROTTLE AT IDLE UPDATED MAA CODE FIX USING VENDOR MAA SCREEN UPDATED MAA CODE FIX USING VENDOR MAA SCREEN PLEASE CONTACT TOMC BEFORE COMMENCING ANY WORK. PLEASE CONTACT TOMC BEFORE C
- [SDR CALA2022070401645](https://openairdocs.org/sdr/CALA2022070401645.md): Fuel Heater · high pressure · Jul 4, 2022 · N38459 · Boeing 737924ER · Engine Exhaust System
  > NUMBER 2 ENGINE OIL FILTER BYPASS MASTER CAUTION. DID NOT EXTINGUISH CREW REPORTS HIGHER OIL PRESSURE ON #2 ENG AROUND 140PSI AND OIL QUANTITY IS 99%. REMOVED AND REPLACED #2 ENG SERVO FUEL HEATER,#2 ENG FUEL OIL HEAT EXCHANGER PER TOMC REQUEST. #2 ENG SERVO
- [SDR CALA2022053001392](https://openairdocs.org/sdr/CALA2022053001392.md): Loop · faulty · May 30, 2022 · N38459 · Boeing 737924ER · Smoke Detection
  > ENG 2 OVERHEAT LIGHT LIGHT IS ON R ENG OVERHEAT LT ILLUMINATED CLIMBING THRU 10000 FEET UPDATED MAA CODE FIX USING VENDOR MAA SCREEN PLEASE CONTACT TOMC BEFORE COMMENCING ANY WORK. T/S IRW FIM 26-10 TASK 810 AND WD 26-11-21 FOUND ENG #2 CORE RH LOOP A FAULTY.
- [SDR CALA2019072401240](https://openairdocs.org/sdr/CALA2019072401240.md): Lens · missing · Jul 22, 2019 · N38459 · Boeing 737924ER · Emergency Lighting
  > EMER PATH LIGHTING COVER MISSING AT FIRST CLASS CLOSET A/C LEFT. RPL''D LENS, LIGHT OPS NORMAL.
- [SDR CALA201906301075](https://openairdocs.org/sdr/CALA201906301075.md): Brake Assy · failed · Jun 25, 2019 · N38459 · Boeing 737924ER · Landing Gear Brake System
  > NR 3 BRAKE ALIGNMENT PIN FOR BRAKE DISC BROKEN AND BRAKE COMING APART REMOVED AND REPLACED BRAKE ASSY REF AMM 32-41-41-400-801 BRAKE OPS CHECKS NORMAL ROTABLE PARTS CHANGE WAS INDICATED
- [SDR CALA2018011200167](https://openairdocs.org/sdr/CALA2018011200167.md): Lens · loose · Jan 12, 2018 · N38459 · Boeing 737924ER · Emergency Lighting
  > EMERGENCY LIGHT LENS NEXT TO THE FWD CLOSET LOOSE. INSTALLED A NEW LENS.
- [SDR CALA2017103003843](https://openairdocs.org/sdr/CALA2017103003843.md): Module · defective · Oct 30, 2017 · N38459 · Boeing 737924ER · Lighting System
  > 36A SLIDE ROW LIGHT BLINKS. REPLACED LED MODULE AT WINDOW/SIDEWALL 36A, OPS CKS GOOD. REF AM M33-21-00.
- [SDR CALA2017061801878](https://openairdocs.org/sdr/CALA2017061801878.md): Lens · broken · Jun 18, 2017 · N38459 · Boeing 737924ER · Emergency Lighting
  > ROW 26ABC SEAT EMERGENCY LIGHT IS BROKEN. REPLACED BROKEN EMERGENCY LIGHT LENS AND SECURED IN SEAT. REF AMM 33-51-11. OPS NORMAL.
- [SDR CALA2017060901782](https://openairdocs.org/sdr/CALA2017060901782.md): Girt Bar · out of adjust · Jun 9, 2017 · N38459 · Boeing 737924ER · Cabin Equipment/Furnishings
  > GIRT BAR NEEDS ADJUSTING. 1R REMOVED SLIDE PACK AND BUSTLE, ADJUSTED GIRT BAR AND INSTALLED SLIDE AND BUSTLE IAW AMM 25-66-01.

## The whole list in SQL

Runs in DuckDB 1.2 or later on the release's Parquet files over HTTPS:

```sql
SELECT sdr_id, difficulty_date, n_number, aircraft_make, aircraft_model, part_name, part_condition, jasc_code, discrepancy
FROM 'https://openairdocs.org/data/latest/faa_service_difficulty_report.parquet'
WHERE n_number = 'N38459' AND registry_match = 'registration'
ORDER BY difficulty_date DESC
```

This list as a web page: https://openairdocs.org/aircraft/N38459/reports

---
OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.