# Service difficulty reports: N68801

A list on [N68801](https://openairdocs.org/aircraft/N68801.md).

Matched to this aircraft by N-number and event date, checked against the reported serial number, make and model. Newest first.

- [SDR CALA2026051516296](https://openairdocs.org/sdr/CALA2026051516296.md): Acm · faulted · May 13, 2026 · N68801 · Boeing 737924ER · Cabin Cooling System
  > PACK LIGHT LIGHT ON AT CRUISE, LIGHT STAYS OFF AFTER RESET LEFT OPERATING UNDER MEL LEFT PACK SINGLE CHANNEL. COMPLIED WITH NON NORMAL. RESET WITH WARMER CONT CAB TEMP. LIGHT REMAINED OUT. 50 MINS LATER AT CRUISE LEFT PACK LIGHT AGAIN. COMPLIED NON NORMAL.
- [SDR CALA2026041315297](https://openairdocs.org/sdr/CALA2026041315297.md): Wire · broken · Apr 10, 2026 · N68801 · Boeing 737924ER · Light System Wiring
  > OPERATIONAL CHECK OF EMERGENCY LIGHTS, FOUND SEAT 22 ABC EMERGENCY AISLE LIGHT INOPERATIVE. T/S, WIRE FOUND TO BE BROKEN IN SEAT 22B. REPAIR THE WIRE IAW SWPM 20-10-11. OPS TESTED OK.
- [SDR CALA2025110410906](https://openairdocs.org/sdr/CALA2025110410906.md): Wheel · damaged · Nov 1, 2025 · N68801 · Boeing 737924ER · Wheel/Ski/Float
  > RTO DUE TO LOS OF ARCFT CONTROL ARCFT VEERED LEFT AT T/O PWR W/F ULL RIGHT RUDDER NORM THRUST PILOT REPORTED RTO AT 80 KNOTS AFTER HE HEARD A NOISE COMING FROM THE NLG AND AFTER AIRCRAFT STARTED PULLING TO THE LEFT EVEN WITH FULL RIGHT RUDDER. R & R LT NLG TI
- [SDR CALA2025102010268](https://openairdocs.org/sdr/CALA2025102010268.md): Potable Water · contaminated · Oct 20, 2025 · N68801 · Boeing 737924ER · Potable Water System
  > DRAIN AND REFILL THE POTABLE WATER SYSTEMS WITH FRESH WATER PER THE GMM COFFEE HAS CHEMICAL TAST E AND SMELL. REMADE COFF EE SAME RESULT. SUSPECT WATER TANK NEEDS FLUSH DRAIN AND REFILLED POTABLE WATER SYSTEM,
- [SDR CALA2025091108764](https://openairdocs.org/sdr/CALA2025091108764.md): Girt Bar · fod · Sep 9, 2025 · N68801 · Boeing 737924ER · Emergency Equipment
  > DOOR 2R GIRT BAR GETTING STUCK IN THE BRACKET PERFORMED INSPECTION OF DOOR 2R GIRT BAR HOLDER FOUND DIRT AND DEBRIS BETWEEN BRACKET. CLEANED BOTH BRACKETS. COULD NOT DUPLICATE DEFECT
- [SDR CALA2025090508498](https://openairdocs.org/sdr/CALA2025090508498.md): Attach Angle · cracked · Aug 20, 2025 · N68801 · Boeing 737924ER · Fuselage Main, Attach Fittings
  > LOWER FUSELAGEREAR SPAR STA 663 BULKHEAD VAPOR BARRIER UPPER HORIZONTAL ATTACHED ANGLE CRACKED AT LBL 7 REF AAR N/R 99943646. ACCOMPLISHED REPAIR AT VAPOR BARRIER UPPER HORIZONTAL ANGLE AT LBL7 IAW SRM 57.-10-10-2R-5.
- [SDR CALA2025082508076](https://openairdocs.org/sdr/CALA2025082508076.md): Angle · cracked · Aug 20, 2025 · N68801 · Boeing 737924ER · Fuselage Main, Bulkhead
  > LOWER FUS CENTER WING BOX REAR SPAR STA 663 BULKHEAD VAPOR BARRIER UPPER HORIZONTAL ATTACHED ANGLE CRACKED AT RBL 7 E ACCOMPLISHED REPAIR AT VAPOR BARRIER UPPER HORIZONTAL ANGLE AT RBL 7 AS PER B737-9 SRM 57.-10-10-2R-5 ACCOMPLISHED REPAIR AT VAPOR BARRIER U
- [SDR CALA2025072406880](https://openairdocs.org/sdr/CALA2025072406880.md): Slide · damaged · Jul 21, 2025 · N68801 · Boeing 737924ER · Escape Slide
  > DOOR 2L EMERGENCY ESCAPE SLIDE GIRT BAR MATERIAL DAMAGED. REMOVED DOOR MOUNTED ESCAPE SLIDE REF AMM 25-66-01. INSTALLED SLIDE PACK AND COVER PER AMM 25-66-01-400-804 AND AMM 25-66-01-400-803. OK TO CONTINUE.
- [SDR CALA2025063006035](https://openairdocs.org/sdr/CALA2025063006035.md): Unknown · odor · Jun 28, 2025 · N68801 · Boeing 737924ER · Air Distribution System
  > HYD FLUID SMELL ON FLT DECK DESCNDING THROUGH 10500 FEET FLIGHT CREW FILLED OUT SMOKE / FUMES IN THE COCKPIT/ CABIN FORM. CHECKING FOR HYDRAULIC LEAKS, SMELLED HYDRAULIC FUMES WITH BOTH PACKS RUNNING, SMALL WET AREA UNDER KEEL BEAM IN THE BELLY BEACON AND INS
- [SDR CALA2025041503863](https://openairdocs.org/sdr/CALA2025041503863.md): Unknown · odor · Apr 13, 2025 · N68801 · Boeing 737924ER · Air Distribution System
  > THE ODOR OF JET FUEL IN THE FRONT HALF OF CABIN AND FLIGHT DECK HAS REOCCURED. AS REQUIRED BY FIM TASK 05-51-26-800-801-C1, FORM 46.6020 HAS BEEN FILLED OUT FOR THE PILOTS. PERFORMED TASK 05-51-26. NO ODOR DETECTED DURING ENGINE RUN. PROCEED TO REQUEST PLAC
- [SDR CALA2025041403741](https://openairdocs.org/sdr/CALA2025041403741.md): None · odor · Apr 13, 2025 · N68801 · Boeing 737924ER · Standard Practices/Structures
  > STRONG ODOR OF JET FUEL IN FLIGHT DECK AND FWD GALLEY AND CABIN. ODOR DISSIPATED OVER THE MINUTES; SUSPECT COMES FROM OUTSIDE. NO MX ACTION REQUIRED AT THIS TIME.
- [SDR CALA2025032603198](https://openairdocs.org/sdr/CALA2025032603198.md): Slide · unpacked · Mar 24, 2025 · N68801 · Boeing 737924ER · Escape Slide
  > EXCESSIVE SLIDE MATERIAL HANGING FROM BOTTOM DOOR 2R PERFORMED THE ESCAPE SLIDE PLAY CHECK PER AMM 25-66-01-200-801. NO ISSUES NOTED ON R2 DOOR ESCAPE SLIDE PACK.
- [SDR CALA2025031702845](https://openairdocs.org/sdr/CALA2025031702845.md): None · none · Mar 15, 2025 · N68801 · Boeing 737924ER · Standard Practices/Structures
  > WATER SUPPLY IN LAVATORY POOR QUALITY AFT LH LAV D TESTED WATER QUALITY IN ALL LAVS AND FOUND NO BAD SMELL OR BAD QUALITY WATER. ALL ARE FINE. ASKED 2 FLIGHT ATTENDANTS AND 2 OTHER WORKERS AND THEY ALL AGREED. FIM REF: 38-10 TASK 810.
- [SDR CALA2025013102156](https://openairdocs.org/sdr/CALA2025013102156.md): Bracket · out of adjust · Jan 29, 2025 · N68801 · Boeing 737924ER · Emergency Equipment
  > DOOR 2L GIRT BAR HAS VERY WEAK TENSION ADJUSTED GIRT BAR RETAINER BRACKET. OPS CHKED GOOD.
- [SDR CALA2025012402031](https://openairdocs.org/sdr/CALA2025012402031.md): Unknown · odor · Jan 22, 2025 · N68801 · Boeing 737924ER · Air Distribution System
  > PUNGENT ODOR PRESENT IN CABIN ON DESCENT ACCOMPLISHED INITIAL AND CONDITIONAL INSPECTION PER MM 05-51-26-800-801-C1 ITEM 1.C(1) UPTO ITEM 1.C(2)(E)15). NO DEFECT (ODOR) PRESENT. SPOKE WITH TOMC NEED TO ISOLATE APU BLEED AFTER APU REPAIRED RAN APU BLEED AIR AN
- [SDR CALA2024102900950](https://openairdocs.org/sdr/CALA2024102900950.md): Oven · odor · Oct 26, 2024 · N68801 · Boeing 737924ER · Buffet/Galleys
  > FA REPORTS AIR FROM FWD GALLEY GASPER VENT HAS BURNT FOOD ODOR GALLEY GASPER VENT SMELLS NORMAL. APC OVEN BURNOUT AND REMAINING ODORS GONE.
- [SDR CALA2024011500119](https://openairdocs.org/sdr/CALA2024011500119.md): Anti-Ice Valve · inoperative · Jan 12, 2024 · N68801 · Boeing 737924ER · Engine Anti-Icing System
  > RTO LOW SPEED RIGHT ENG ANTI ICE INOP. UPDATE ROTABLE PARTS CHANGE #2 ENGINE ANTI-ICE VALVE COWL. ROTABLE PARTS CHANGE WAS INDICATED - TT # 1535801 SN OFF 0476 VALVE, ANTI-ICE OFF 29-3021-9-0002 0476 ON 29-3021-9-0002 1619 VALVE, ANTI-ICE OFF 29-3021-9-0002 04
- [SDR CALA2023092102843](https://openairdocs.org/sdr/CALA2023092102843.md): Filter · clogged · Sep 18, 2023 · N68801 · Boeing 737924ER · Turbine Engine Oil System
  > THE OIL FILTER BYPASS LIGHT STARTED BLINKING FOR APPROX 10 SEC F OLLOW ED BY STEADY BYPASS LGHT ACP IDT FOR CHIP DETECTORS AFTER DEBRIEFING CREW, IT WAS NOTED THAT ALL ENGINE PARAMETERS WERE NORMAL AND CREW MANUALLY SHUT ENGINE DOWN. CHIP DETECTORS REMOVED IN
- [SDR CALA2023032700904](https://openairdocs.org/sdr/CALA2023032700904.md): Seal · out of position · Mar 27, 2023 · N68801 · Boeing 737900ER · Doors
  > ENTRY DOOR EXTERIOR HANDLE DIFFICULT TO OPERATE AFT L2 ENTRY DOOR DIFICULT TO OPEN. L2 DOOR LINER DECORATIVE RUBBER SEAL ADJUSTED ON UPPER AFT CORNER OF DOOR LINER. OPS CHECK NORMAL FOR DOOR, REF AMM 52-13-00-860-804
- [SDR CALA2022093002575](https://openairdocs.org/sdr/CALA2022093002575.md): Battery Pack · none · Sep 30, 2022 · N68801 · Boeing 737 · Lighting System
  > EMERGENCY LIGHT L/H FWD. SEVERAL LIGHTS INOP (REF AAR NR 9994289 5) TROUBLESHOOTED EMERGENCY LIGHT AT L/H FWD, IAW B737 AMM 33-51-00 -710-801 & IAW B737WDM 33-51-21, FOUND BATTER PACK M1675 DISCHAR GED, REMOVED EMERGENCY LIGHT BATTERY PACK IAW B737 AMM 33-51-0
- [SDR CALA2022092602492](https://openairdocs.org/sdr/CALA2022092602492.md): Battery Pack · inoperative · Sep 23, 2022 · N68801 · Boeing 737900ER · Emergency Lighting
  > EMERGENCY LIGHT L1517, L1507 AND L1513 INOP. REMOVED AND REPLACED BATTERY PACK. OPS CHK GOOD.
- [SDR CALA2022091402363](https://openairdocs.org/sdr/CALA2022091402363.md): Skin · dented · Sep 13, 2022 · N68801 · Boeing 7379 · Fuselage Structure (General)
  > FOUND DENT MEASURING 3" BY 4" AT STA 1008 BTW STGR 12L AND 13L. LOG PAGE 5813493 CREATED TO C/W DIP REQUIREMENTS OF EC/RA 5370-0 1049 STEP 6 WHICH REQUIRES PERMANENT REPAIR (WORK WITH ROUTINE 3 501632-2000-0500) (REF: AAR NR 99942390) PERFORMED PERMANENT REPAI
- [SDR CALA2022011800169](https://openairdocs.org/sdr/CALA2022011800169.md): Switch · defective · Jan 17, 2022 · N68801 · Boeing 737900 · Doppler System
  > UNCOMMANDED WX RADAR TEST ON TAKEOFF TWICE FOUND WEATHER RADAR CONTROL PANEL TEST SWITCH STICKING IN THE TEST POSITION. REQUIRES NEW PANEL M&E 29-3443-9-0008. NIS IN EWR. R/R WEATHER RADAR CONTROL PANEL I.A.W AMM REF# 34-43-91. PERFORMED INSTALLATION TEST GOOD
- [SDR CALA2021102001927](https://openairdocs.org/sdr/CALA2021102001927.md): Panel · missing · Oct 19, 2021 · N68801 · Boeing 737924ER · Horizontal Stabilizer Structure
  > PDA 1 RIGHT HORIZONTAL STAB TRAILING EDGE OUTBOARD ELEVATOR SEAL PANEL 344DB FOUND TO BE MISSING FROM THE AIRCRAFT. ALL SCREWS REMAIN EXCEPT FOR THE OUTBOARD 3. PANEL MEASURES APPROX 3.5" BY 72". PHOTO UPDATE
- [SDR CALA2018020400477](https://openairdocs.org/sdr/CALA2018020400477.md): Life Raft · low pressure · Feb 4, 2018 · N68801 · Boeing 737924ER · Life Raft
  > AFT CABIN FWD RAFT DOES NOT HAVE MINIMUM 3000 PSI AS INDICATED ON PRESSURE GAUGE. REPLACED AFT CABIN FWD RAFT IAW AMM 25-64-00.
- [SDR CALA2017071002174](https://openairdocs.org/sdr/CALA2017071002174.md): Lens · missing · Jul 10, 2017 · N68801 · Boeing 737924ER · Emergency Lighting
  > EMERGENCY LIGHT LENS MISSING AT SEATS 12C AND 37C. INSTALLED NEW LENS ASSY. OPS CHECKS GOOD.
- [SDR CALA2016102400812](https://openairdocs.org/sdr/CALA2016102400812.md): Slide · detached · Oct 24, 2016 · N68801 · Boeing 737924ER · Escape Slide
  > R2 DOOR SLIDE IS HANGING DOWN. REPLACED THE SLIDE PACK IAW AMM 25-66-01

## The whole list in SQL

Runs in DuckDB 1.2 or later on the release's Parquet files over HTTPS:

```sql
SELECT sdr_id, difficulty_date, n_number, aircraft_make, aircraft_model, part_name, part_condition, jasc_code, discrepancy
FROM 'https://openairdocs.org/data/latest/faa_service_difficulty_report.parquet'
WHERE n_number = 'N68801' AND registry_match = 'registration'
ORDER BY difficulty_date DESC
```

This list as a web page: https://openairdocs.org/aircraft/N68801/reports

---
OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.