# Service difficulty reports: Boeing 767-2B7

A list on [Boeing 767-2B7](https://openairdocs.org/model/boeing-767-2b7.md).

Newest first. General aviation reporting is voluntary.

Page 1 of 8 · 373 reports

- [SDR USAA2015012000006](https://openairdocs.org/sdr/USAA2015012000006.md): Battery · discharged · Jan 19, 2015 · N252AU · Boeing 7672B7 · Emergency Equipment
  > FLIGHT ATTENDANT EMER FLASHLIGHTS FWD MIDDLE INBD & OTBD & AFT LT BATTERIES LOW. R & R FLIGHT ATTENDANT FLASHLIGHT BATTERIES.
- [SDR USAA2014122400005](https://openairdocs.org/sdr/USAA2014122400005.md): Pump · leaking · Dec 22, 2014 · N256AY · Boeing 7672B7 · Turbine Engine Oil System
  > ENROUTE, RT ENGINE OIL PRESSURE DROPPED TO 13 PSI, WITH OIL QTY LOSS. SHUTDOWN THE RT ENGINE. LANDED WITHOUT FURTHER INCIDENT. REPLACED THE NR 2 ENGINE LUBE PUMP DUE TO DAMAGED THREADS ON THE TGB INLET SCREEN. REPLACED THE SCAVENGE OIL FILTER. CHECKED TH
- [SDR USAA2014110700007](https://openairdocs.org/sdr/USAA2014110700007.md): Actuator · faulty · Nov 6, 2014 · N251AY · Boeing 7672B7 · Landing Gear Actuator
  > LEFT MLG DIDN'T STAY UP AFTER GEAR RETRACTION ON TAKEOFF. RECYCLED & SAME PROBLEM ON RETRACTION. R & R LT MAIN GEAR ACTUATOR.
- [SDR USAA2014110400004](https://openairdocs.org/sdr/USAA2014110400004.md): Cylinder · defective · Nov 1, 2014 · N252AU · Boeing 7672B7 · Escape Slide
  > FOUND THE LT OFF WING ESCAPE SLIDE INFLATION CYLINDER DEFECTIVE. REPLACED THE LT OFF WING ESCAPE SLIDE INFLATION CYLINDER.
- [SDR USAA2014110300010](https://openairdocs.org/sdr/USAA2014110300010.md): Relay · defective · Nov 1, 2014 · N252AU · Boeing 7672B7 · Escape Slide
  > SQUIB TEST NR 1 FAILS INTERMITTENTLY. R & R RELAY IN M1 TIME DELAY MODULE M1135.
- [SDR USAA2014103100001](https://openairdocs.org/sdr/USAA2014103100001.md): Actuator · faulty · Oct 30, 2014 · N252AU · Boeing 7672B7 · Emergency Equipment
  > SQUIB TEST 1 FAILS INTERMITTENTLY. R & R LT EMER EVACUATION SLIDE DOOR LATCH ACTUATOR.
- [SDR USAA2014101600023](https://openairdocs.org/sdr/USAA2014101600023.md): Relay · faulty · Oct 15, 2014 · N252AU · Boeing 7672B7 · Emergency Lighting
  > TROUBLESHOOT LT EMER ESC SLIDE LIGHT. R & R K838 RELAY.
- [SDR USAA2014100300013](https://openairdocs.org/sdr/USAA2014100300013.md): Battery Pack · discharged · Sep 27, 2014 · N253AY · Boeing 7672B7 · Emergency Lighting
  > DAILY CHECK, DURING LEASE RETURN. RT SIDE EXTERNAL EMER LIGHTS WILL NOT TEST. R & R BATTERY PACK M733 & PERFORMED TEST IAW AMM 33-51-07. CHECKED GOOD.
- [SDR USAA2014100300012](https://openairdocs.org/sdr/USAA2014100300012.md): Battery Pack · discharged · Sep 27, 2014 · N253AY · Boeing 7672B7 · Emergency Lighting
  > DAILY CHECK, DURING LEASE RETURN, RT SIDE EXTERNAL EMER LIGHTS WILL NOT TEST. R & R BATTERY PACK M731 & PERFORMED TEST IAW AMM 33-51-07. CHECKED GOOD.
- [SDR USAA2014100300011](https://openairdocs.org/sdr/USAA2014100300011.md): Arm · broken · Sep 26, 2014 · N253AY · Boeing 7672B7 · Emergency Equipment
  > LEASE RETURN. LEFT OFF WING SLIDE DISCONNECT HOUSING ARM BROKEN. R & R DISCONNECT HOUSING IAW AMM 25-65-04-044-149-001 & 25-65-04-414-154-001.
- [SDR USAA2014100300010](https://openairdocs.org/sdr/USAA2014100300010.md): Slide · damaged · Sep 26, 2014 · N253AY · Boeing 7672B7 · Escape Slide
  > LEASE RETURN CHECK. LEFT OFF WING SLIDE FWD DIAGONAL STRAP REINFORCEMENT HOOK BROKEN AT LOWER END. R & R SLIDE IAW AMM 25-65-05 PB 401. PARTS CHANGE INDICATED TT 8271263 SN OFF PG 0060 SLIDE, LT OFF WITH OFF 12-2561-9-0002 0060 ON 12-2561-9-0002 0016.
- [SDR USAA2014092200013](https://openairdocs.org/sdr/USAA2014092200013.md): Megaphone · broken · Sep 20, 2014 · N252AU · Boeing 7672B7 · Emergency Equipment
  > FORWARD EMER MEGA PHONE BROKEN. R & R FWD EMER MEGA PHONE AS REQUIRED. OPERATIONS CHECKED GOOD.
- [SDR USAA2014091500003](https://openairdocs.org/sdr/USAA2014091500003.md): Battery Pack · discharged · Sep 12, 2014 · N252AU · Boeing 7672B7 · Emergency Lighting
  > DURING DAILY CHECK, P61 SQUIB TEST NOT LIGHTING LT OVERWING EMER EXIT TEST LIGHT. REPLACED BATTERY PACK. OPERATIONAL CHECK IS GOOD.
- [SDR USAA2014090800005](https://openairdocs.org/sdr/USAA2014090800005.md): Plate · broken · Sep 6, 2014 · N255AY · Boeing 7672B7 · Service Doors
  > PLATE REINFORCEMENT BROKEN & PLATE IS BULGING ON R2 DOOR. REPLACED BROKEN PLATE AT R2 DOOR.
- [SDR USAA2014081500003](https://openairdocs.org/sdr/USAA2014081500003.md): Panel · malfunctioned · Aug 14, 2014 · N252AU · Boeing 7672B7 · Emergency Equipment
  > BRU DURING COCKPIT CHECK FOUND P61 SQUIB TEST 1 NOT SATISFACTORY FOR THE LT OVERWING EMER EXIT. REPLACED M00032 SQUIB TEST PANEL. VENDOR SHOP FINDINGS, UNIT TESTED EXTENSIVELY FOR INTERMITTENT OPERATION OF L5. L5 PASSED ALL TESTING. CUSTOMER COMPLAINT NOT
- [SDR USAA2014081100003](https://openairdocs.org/sdr/USAA2014081100003.md): Relay · no test · Aug 8, 2014 · N255AY · Boeing 7672B7 · Drag Control System
  > SPOILER SQUIBS WOULD NOT TEST ON P 61 PANEL. R & R RELAY K839 IN P19 PANEL.
- [SDR USAA2014080100001](https://openairdocs.org/sdr/USAA2014080100001.md): Slide · defective · Jul 31, 2014 · N252AU · Boeing 7672B7 · Escape Slide
  > SLIDE DEPLOYED, EMER LIGHTS DID NOT ILLUMINATE. R & R 2FW DOOR SLIDE.
- [SDR USAA2014062700007](https://openairdocs.org/sdr/USAA2014062700007.md): Bracket · missing · Jun 26, 2014 · N255AY · Boeing 7672B7 · Emergency Lighting
  > INNER LIGHT BRACKET MISSING FROM R2 EXIT SIGN. REPLACED EXIT SIGN.
- [SDR USAA2014062300013](https://openairdocs.org/sdr/USAA2014062300013.md): Handle · loose · Jun 21, 2014 · N256AY · Boeing 7672B7 · Passenger/Crew Doors
  > FWD ENTRY DOOR WOULD NOT ARM & DIFFICULT TO CLOSE. MX FOUND L1 DOOR ARMING HANDLE LOOSE. SECURED HANDLE. PERFORMED SATISFACTORY OPERATIONAL TEST OF L1 DOOR OPENING & CLOSING FUNCTIONS & SLIDE ARMING & DISARMING FUNCTIONS. ACFT OK FOR SERVICE.
- [SDR USAA2014060900001](https://openairdocs.org/sdr/USAA2014060900001.md): Thrust Reverser · damaged · Jun 8, 2014 · N255AY · Boeing 7672B7 · Engine Thrust Reverser
  > CLT FLT 749 MAD TO CLT. RT ENG OTBD THRUST REVERSER DAMAGED. R & R NR 2 ENG OTBD THRUST REVERSER. VENDOR SHOP FINDINGS, REPLACED THE DAMAGED SKINS OF THE CORE COWL.
- [SDR USAA2014060600016](https://openairdocs.org/sdr/USAA2014060600016.md): Wire · chafed · Jun 5, 2014 · N253AY · Boeing 7672B7 · Electrical Power System Wiring
  > PHL FLT 750 EN ROUTE PHL TO BRU. DURING CRUISE FLIGHT, JUST PRIOR TO ETOPS, THE ACFT LOST ALL POWER TO THE LT ACFT BUS. ALSO, THE APU FAULT LIGHT CAME ON WITH EICAS MSG APU FAULT. THE CREW PERFORMED THE APPROPRIATE RESETS & THE ACFT POWER RETURNED. THE CREW
- [SDR USAA2014052300005](https://openairdocs.org/sdr/USAA2014052300005.md): Battery · discharged · May 22, 2014 · N253AY · Boeing 7672B7 · Emergency Lighting
  > CUSTOMER CARE, LT & RT EXIT DOOR HATCH EMERGENCY EXIT SIGN LIGHTS INOPERATIVE. REPLACED M1209 EMERGENCY BATTERY & CHARGER ASSEMBLY IAW AMM 33-51-07. INSTALLATION CHECKED GOOD IAW AMM 33-51-07.
- [SDR USAA2014052300004](https://openairdocs.org/sdr/USAA2014052300004.md): Light · wrong part · May 22, 2014 · N253AY · Boeing 7672B7 · Emergency Lighting
  > FUEL MOD AFT GALLEY EMERGENCY PATH LIGHTING IS WRONG, NEEDS REPLACING. R & R AFT GALLEY EMERGENCY PATH LIGHTING IAW MM 33-51-10.
- [SDR USAA2014042900001](https://openairdocs.org/sdr/USAA2014042900001.md): Battery Pack · discharged · Apr 28, 2014 · N255AY · Boeing 7672B7 · Emergency Lighting
  > CLT EXTERIOR RT SIDE AFT 2 EMERGENCY LIGHTS INOPERATIVE. R & R EMERGENCY LIGHTS BATTERY PACK & CHARGER AT POSITION 733 & LIGHT SOCKET RT SIDE AFT CARGO DOOR AS REQUIRED. OPERATIONS CHECKED GOOD, OK FOR SERVICE.
- [SDR USAA2014042500001](https://openairdocs.org/sdr/USAA2014042500001.md): Light · inoperative · Apr 21, 2014 · N255AY · Boeing 7672B7 · Emergency Lighting
  > GIG ROW 22 RT OVERHEAD EMERGENCY LIGHT INOPERATIVE. REPLACED EXIT LIGHT ASSEMBLY, RT OVERHEAD ROW 22.
- [SDR USAA2014042100004](https://openairdocs.org/sdr/USAA2014042100004.md): Power Supply · inoperative · Apr 17, 2014 · N256AY · Boeing 7672B7 · Emergency Lighting
  > CLT L1 & L2 DOOR EXIT & THRESHOLD LIGHTS WOULD NOT TEST. REPLACED M1208 POWER SUPPLY.
- [SDR USAA2014032500010](https://openairdocs.org/sdr/USAA2014032500010.md): Strap · cracked · Mar 19, 2014 · N251AY · Boeing 7672B7 · Fuselage Main, Bulkhead
  > C1 CHECK TWO 1/8 INCH CRACKS IN OUTER CHORD STRAP AT BULKHEAD AT BS 1726.5, STRINGER 7R. REPAIRED BULKHEAD OUTER CHORD STRAP AT BS 1726.5, STRINGER 7R IAW SRM 53-80-01-2R-5.
- [SDR USAA2014021900005](https://openairdocs.org/sdr/USAA2014021900005.md): Battery · discharged · Feb 18, 2014 · N252AU · Boeing 7672B7 · Emergency Equipment
  > Z RT EMERGENCY FLASHLIGHT AT STATION 4R DOES NOT FLASH. REPLACED FLASHLIGHT BATTERY 4R.
- [SDR USAA2014021900004](https://openairdocs.org/sdr/USAA2014021900004.md): Light · inoperative · Feb 18, 2014 · N255AY · Boeing 7672B7 · Emergency Lighting
  > GRU ROW 16 LT AISLE EMERGENCY LIGHT INOPERATIVE. R & R ROW 16 LT AISLE EMERGENCY LIGHT, TESTED OK.
- [SDR USAA2014020700013](https://openairdocs.org/sdr/USAA2014020700013.md): Computer · faulty · Feb 5, 2014 · N252AU · Boeing 7672B7 · Autopilot Computer
  > CLT FLT 1729 EN ROUTE PHL TO CLT. C AUTOPILOT COMMANDED AN ABRUPT INCREASE IN PITCH APPROACHING 30 DEGREES & RESULTING RAPID LOSS OF AIRSPEED AT 1400 FT AFTER TAKEOFF, IMMEDIATELY AFTER ENGAGING. MX PERFORMED FAULT ISOLATION PROCEDURES, NO TROUBLE FOUND. RE
- [SDR USAA2014011500008](https://openairdocs.org/sdr/USAA2014011500008.md): Switch · failed · Jan 14, 2014 · N251AY · Boeing 7672B7 · Emergency Equipment
  > SQUIB TEST FAILED TEST 2 EMERGENCY ESCAPE LIGHTS INOPERATIVE. R & R SQUIB PANEL, OPS CHECKED GOOD. UNIT FAILS FUNCTIONAL TESTING. LAMPS L1 & L2 ARE INTERMITTENT WHEN PRESSED. UNIT ALSO FAILS TO ILLUMINATE L5 WITH L5 & S2 PRESSED & NEGATIVE IS APPLIED TO J3
- [SDR USAA2014010200003](https://openairdocs.org/sdr/USAA2014010200003.md): Battery · discharged · Dec 30, 2013 · N255AY · Boeing 7672B7 · Emergency Lighting
  > CLT COCKPIT EMERGENCY EXIT LIGHT BATTERIES DEAD. REPLACED BATTERIES, OPERATIONS CHECKED GOOD.
- [SDR USAA2013122700003](https://openairdocs.org/sdr/USAA2013122700003.md): Control Panel · faulty · Dec 26, 2013 · N256AY · Boeing 7672B7 · Cabin Pressure Control System
  > FLT 751 ENROUTE, RECEIVED FWD EQ OVERHEAT MESSAGE FOLLOWED BY UNCONTROLLABLE CABIN AIR PRESSURE. DECLARED AN EMERGENCY & PERFORMED A RAPID DESCENT TO 10,000 FT. RETURNED TO DEPARTURE & LANDED WITHOUT FURTHER INCIDENT. MX REPLACED THE CABIN PRESSURE SELECTO
- [SDR USAA2013122400001](https://openairdocs.org/sdr/USAA2013122400001.md): Fan · inoperative · Dec 23, 2013 · N253AY · Boeing 7672B7 · Air Distribution Fan
  > LEFT RECIRCULATION FAN, EICAS C, LIGHT ELEC SMELL IN COCKPIT & CABIN, ENDED WHEN RECYCLING FAILED. R & R FAN CABIN AIR CIRCULATION. OPS CHECKED GOOD.
- [SDR USAA2013121200001](https://openairdocs.org/sdr/USAA2013121200001.md): Slide · unsecure · Dec 12, 2013 · N256AY · Boeing 7672B7 · Escape Slide
  > C1 CHECK, RT OFF WING ESCAPE SLIDE ASSEMBLY UNLACED, SLIDE NOT SECURED. REPLACED RT ESCAPE SLIDE ASSEMBLY & INSTALLED IAW B767 AMM 25-65-05-424-056.
- [SDR USAA2013120500003](https://openairdocs.org/sdr/USAA2013120500003.md): Battery · discharged · Dec 4, 2013 · N251AY · Boeing 7672B7 · Emergency Lighting
  > CLT COCKPIT EMERGENCY LIGHT BATTERIES DEAD. R & R BATTERIES.
- [SDR USAA2013120300001](https://openairdocs.org/sdr/USAA2013120300001.md): Charger · malfunctioned · Dec 2, 2013 · N253AY · Boeing 7672B7 · Emergency Lighting
  > PHL THREE AFT LT EMERGENCY GND ILLUMINATION LIGHTS DID NOT COME ON DURING TEST. R & R EMERGENCY LIGHT POWER SUPPLY BATTERY CHARGER AT M738 POSITION. OPERATIONS CHECKED GOOD.
- [SDR USAA2013112900012](https://openairdocs.org/sdr/USAA2013112900012.md): Pin · bent · Nov 27, 2013 · N251AY · Boeing 7672B7 · Engine Fuel System Wiring
  > LEFT ENG FUEL FILTER FAULT EICAS MSG DURING CRUISE FLIGHT. THE FLIGHT DIVERTED TO THE NEAREST SUITABLE AIRPORT & THE FLIGHT LANDED WITHOUT FURTHER INCIDENT. FOUND BENT PIN AT CONNECTOR D4202P PIN 1. REPLACED PIN & CONNECTOR D4202P.
- [SDR USAA2013112900011](https://openairdocs.org/sdr/USAA2013112900011.md): Pressure Switch · faulty · Nov 26, 2013 · N251AY · Boeing 7672B7 · Fuel Pressure Sensor
  > DUB FLT 750 EN ROUTE PHL TO BRU. EICAS MESSAGE LT ENG FUEL FILT DISPLAYED DURING CRUISE FLIGHT. A DIVERSION TO THE NEAREST SUITABLE AIRPORT WAS REQUIRED BY THE QRH. THE FLIGHT DIVERTED TO DUB & LANDED WITHOUT FURTHER INCIDENT. REPLACED THE FUEL FILTER ELE
- [SDR USAA2013112200005](https://openairdocs.org/sdr/USAA2013112200005.md): Aileron · delaminated · Nov 18, 2013 · N256AY · Boeing 7672B7 · Ailerons
  > C1 CHECK DELAMINATION ON RT AILERON AT APPROXIMATELY 75 INCHES OTBD OF INBD END & 13.5 INCHES FWD OF AFT TE. REPLACED RT AILERON IAW JOB CARD 12L56027004.
- [SDR USAA2013091600006](https://openairdocs.org/sdr/USAA2013091600006.md): Cover · unsecure · Sep 14, 2013 · N256AY · Boeing 7672B7 · Emergency Lighting
  > EXIT SIGN COVER 2L JUMPSEAT FELL OUT. COVER REINSTALLED; OPC SATISF.
- [SDR USAA2013070300003](https://openairdocs.org/sdr/USAA2013070300003.md): Service Cart · faulty · Jul 1, 2013 · N256AY · Boeing 7672B7 · Buffet/Galleys
  > EN-ROUTE, THE GALLEY FOOD HEATING UNIT IN THE AFT GALLEY MELTED THE PLASTIC FOOD TRAYS AND EMITTED AN ODOR. THEY WERE NEW FOOD TRAYS. MX EXCHANGED ALL HEATING UNITS AND VISUALLY CHECKED ALL CORDS. NO DAMAGE FOUND.
- [SDR USAA2013062000004](https://openairdocs.org/sdr/USAA2013062000004.md): Cover · faulty · Jun 19, 2013 · N253AY · Boeing 7672B7 · Escape Slide
  > L1 DOOR SLIDE COVER LOOSE. DOOR ALSO DOES NOT OPEN FULLY. REMOVED AND INSTALLED L1 DOOR SLIDE.
- [SDR USAA2013052700007](https://openairdocs.org/sdr/USAA2013052700007.md): Charger · inoperative · May 23, 2013 · N255AY · Boeing 7672B7 · Emergency Lighting
  > RT 2 AFT MOST EMERGENCY SLIDE. GROUND ILLUMINATION LIGHTS FAILED TO LIGHT. R & R BATTERY CHARGER ASSY.
- [SDR USAA20110622BB062](https://openairdocs.org/sdr/USAA20110622BB062.md): Unknown · malfunctioned · Jun 21, 2011 · N251AY · Boeing 7672B7 · Landing Gear Retraction/Extension System
  > PHL FLT 1071 PHL TO SJU. AFTER TAKEOFF, GOT GEAR DISAGREE EICAS. RIGHT MAIN DID NOT RETRACT. EXTENDED GEAR, GOT 3 GREEN AND RECYCLED TO UP NORMALLY. NORMAL OPERATIONS ON SUBSEQUENT LANDING. MAINTENANCE JACKED AIRCRAFT. CYCLED LANDING GEAR SEVERAL TIMES
- [SDR USAA20110616BB055](https://openairdocs.org/sdr/USAA20110616BB055.md): Trim Panel · loose · Jun 15, 2011 · N253AY · Boeing 7672B7 · Service Doors
  > PHL - RIGHT FORWARD DOOR DIFFICULT TO CLOSE. MAINTENANCE FOUND UPPER DOOR LINING PANEL WAS LOOSE AND FALLING OUT OF TRACK. SECURED PANEL. OPS CHECKS GOOD. OK FOR SERVICE.
- [SDR USAA20110615BB053](https://openairdocs.org/sdr/USAA20110615BB053.md): Fan Blade · damaged · Jun 12, 2011 · N256AY · Boeing 7672B7 · Turbine Engine Compressor Section
  > ATH FLT 759 EN ROUTE ATH TO PHL. DURING TAKEOFF, AT ABOUT 50 FT AGL, A LOUD NOISE FOLLOWED BY A LEFT ENGINE VIBRATION OCCURRED. THE LEFT ENGINE POWER WAS PULLED BACK. THE CAPTAIN DECLARED AN EMERGENCY AND RETURNED TO THE FIELD IN ATH. THE FLIGHT LANDED W
- [SDR USAA20110601BB041](https://openairdocs.org/sdr/USAA20110601BB041.md): Hinge · worn · May 28, 2011 · N255AY · Boeing 7672B7 · Passenger/Crew Doors
  > CLT - THE LEFT FORWARD ARMING LEVER COVER WAS NOT FLUSH WHEN THE L1 DOOR WAS OPENED. MAINTENANCE REMOVED AND REPLACED THE FORWARD ENTRY DOOR ARMING LEVER HINGE.
- [SDR USAA20110525BB039](https://openairdocs.org/sdr/USAA20110525BB039.md): Battery Pack · discharged · May 24, 2011 · N251AY · Boeing 7672B7 · Escape Slide
  > CLT - THE EMERGENCY ESCAPE SQUIB LIGHT FAILED TO COME ON DURING TEST (LEFT LIGHT). MAINTENANCE REMOVED AND REPLACED THE RIGHT, OFF-WING ESCAPE SYSTEM BATTERY PACK.
- [SDR USAA20110516BB036](https://openairdocs.org/sdr/USAA20110516BB036.md): Power Supply · inoperative · May 13, 2011 · N251AY · Boeing 7672B7 · Emergency Lighting
  > THE EMERGENCY LIGHT ASSEMBLY IN THE CEILING AT SEAT ROW 12 WAS INOPERATIVE BOTH LEFT AND RIGHT. MAINTENANCE REPLACED POWER SUPPLIES M737 AND M732. OPERATIONALLY CHECKS GOOD.

Next page: https://openairdocs.org/model/boeing-767-2b7/reports.md?page=2

## The whole list in SQL

Runs in DuckDB 1.2 or later on the release's Parquet files over HTTPS:

```sql
SELECT sdr_id, difficulty_date, n_number, aircraft_make, aircraft_model, part_name, part_condition, jasc_code, discrepancy
FROM 'https://openairdocs.org/data/latest/faa_service_difficulty_report.parquet'
WHERE aircraft_model_key = '7672B7'
ORDER BY difficulty_date DESC
```

This list as a web page: https://openairdocs.org/model/boeing-767-2b7/reports

---
OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.