# NTSB investigations, FL: Aircraft maintenance event NTSB aviation accident and incident investigations since 1962: the probable cause, findings, aircraft, crew, weather and docket of each, linked to the FAA registry and the FAA’s own reports. ## Latest cases - [NTSB ERA25LA068](https://openairdocs.org/ntsb/ERA25LA068.md): Diamond Aircraft Ind DA 42 NG · Daytona Beach, FL · Accident · No injuries · Class 4 · Limited · Final report · Nov 15, 2024 · N508PA · Substantial damage > The maintenance technician’s failure to follow the manufacturer’s recommended procedures during a wheel and tire change to ensure proper clearance of the tire to the wheel well resulting in the right main wheel becoming stuck in the well and subsequent… - [NTSB ERA24LA211](https://openairdocs.org/ntsb/ERA24LA211.md): Piper PA32 · Apopka, FL · Accident · No injuries · Class 3 · Limited · Final report · May 8, 2024 · N908DK · Substantial damage > A partial loss of engine power due to sticking exhaust valves. Contributing to the accident was maintenance personnel’s failure to use available engine data while troubleshooting a known engine issue and maintenance personnel’s failure to comply with… - [NTSB ERA24LA185](https://openairdocs.org/ntsb/ERA24LA185.md): Bailey-Moyes Dragonfly · Groveland, FL · Accident · 1 fatal · Class 3 · Limited · Final report · Apr 19, 2024 · UNREG · Substantial damage > The pilot’s improper installation and inspection of the right lower wing strut attachment bolt, which resulted in the inflight failure of the right wing. - [NTSB ERA24LA122](https://openairdocs.org/ntsb/ERA24LA122.md): Bellanca 17-30A · Cape Coral, FL · Accident · No injuries · Class 3 · Limited · Final report · Feb 24, 2024 · N282SV · Substantial damage > A total loss of engine power due to fuel starvation as a result of the pilot’s failure to properly secure a fuel supply line. - [NTSB ERA24FA110](https://openairdocs.org/ntsb/ERA24FA110.md): Bombardier CL-600-2B16 · Naples, FL · Accident · 2 fatal · Class 3 · Field · Final report · Feb 9, 2024 · N823KD · Destroyed > Corrosion of both engines’ variable geometry (VG) system components, which led to their operation in an off-schedule position and resulted in near-simultaneous sub-idle rotating compressor stalls on approach, subsequent loss of thrust in both engines, and an… - [NTSB ERA23LA202](https://openairdocs.org/ntsb/ERA23LA202.md): Rockwell International 112 · Miami, FL · Accident · No injuries · Class 3 · Limited · Final report · Apr 18, 2023 · N12RX · Substantial damage > Failure of the right main landing gear due to inadequate hydraulic pressure as result of a torn O-ring that was installed on the hydraulic pack’s check valve during overhaul. - [NTSB ERA23LA173](https://openairdocs.org/ntsb/ERA23LA173.md): Beech P35 · Perry, FL · Accident · No injuries · Class 3 · Limited · Final report · Mar 5, 2023 · N9777Y · Substantial damage > Maintenance personnel’s incorrect torquing of the oil filter adapter jam nut, resulting in the failure of the adapter threads, a complete loss of oil, and subsequent total loss of engine power. - [NTSB ERA22LA159](https://openairdocs.org/ntsb/ERA22LA159.md): Dwyer Michael D Q · Spring Hill, FL · Accident · No injuries · Class 3 · Limited · Final report · Mar 17, 2022 · N3QP · Destroyed > The pilot’s improper modification of the pull starter motor, which resulted in its failure and the subsequent loss of engine power. - [NTSB ERA22LA080](https://openairdocs.org/ntsb/ERA22LA080.md): Piper PA-12 · Labelle, FL · Accident · Serious injuries · Class 4 · Limited · Final report · Nov 30, 2021 · N3098M · Substantial damage > The pilot’s improper fuel system modification, which resulted in a loss of engine power due to fuel exhaustion. - [NTSB ERA22LA064](https://openairdocs.org/ntsb/ERA22LA064.md): Mooney M20M · Tampa, FL · Accident · No injuries · Class 3 · Limited · Final report · Nov 15, 2021 · N21890 · Substantial damage > The total loss of engine power due to the failure of maintenance personnel to properly tighten the fuel supply line b-nut at the manifold valve during installation. - [NTSB ERA21LA328](https://openairdocs.org/ntsb/ERA21LA328.md): Piper PA-28-140 · Orlando, FL · Accident · Serious injuries · Class 3 · Limited · Final report · Aug 17, 2021 · N98304 · Substantial damage > A total loss of engine power due to fuel starvation that resulted from improper maintenance of the fuel selector valve and fuel selector valve cover. - [NTSB ERA21LA052](https://openairdocs.org/ntsb/ERA21LA052.md): Lancair Legacy FG · Hollywood, FL · Accident · 1 fatal · Class 3 · Limited · Final report · Nov 23, 2020 · N3UH · Substantial damage > The pilot/owner’s failure to properly reinstall the number 1 cylinder spark plug, which resulted in a partial loss of engine power during the initial climb. Contributing was the pilot's exceedance of the airplane’s critical angle of attack during an attempted… - [NTSB ERA19FA256](https://openairdocs.org/ntsb/ERA19FA256.md): Moriarty Marvin Aventura II · Minneola, FL · Accident · 1 fatal · Class 3 · Field · Final report · Aug 23, 2019 · N9143M · Substantial damage > The pilot’s improper modifications to the airplane’s engine, which resulted in the partial loss of engine power. Contributing to the outcome was the pilot's exceedance of the airplane’s critical angle of attack during an attempted return to the airport… - [NTSB CEN19LA174](https://openairdocs.org/ntsb/CEN19LA174.md): Robinson R44 · Key West, FL · Accident · No injuries · Class 3 · Limited · Final report · Jun 17, 2019 · N1241W · Substantial damage > The failure of maintenance personnel to properly secure the right-side tail boom mounting bolts which resulted in the failure of the bolts and an inflight separation of the tail rotor. - [NTSB ERA18LA178](https://openairdocs.org/ntsb/ERA18LA178.md): Piper PA 34-200 · Umatilla, FL · Accident · Minor injuries · Limited investigation · Final report · Jun 14, 2018 · N56213 · Substantial damage > Maintenance personnel ‘s failure to complete and verify the proper installation of the main landing gear (MLG) torque links’ attachment hardware, which resulted in the right MLG torque link disconnecting and the pilot’s subsequent inability to maintain… - [NTSB ERA18FA084](https://openairdocs.org/ntsb/ERA18FA084.md): Piper PA28 · Bonifay, FL · Accident · 1 fatal · Field investigation · Final report · Feb 21, 2018 · N3568K · Destroyed > A partial loss of engine power due to a stuck exhaust valve. Contributing to the accident was the pilot's decision to operate an airplane with a known mechanical deficiency and his failure to fly an appropriate traffic pattern that would have allowed the… - [NTSB ERA17LA287](https://openairdocs.org/ntsb/ERA17LA287.md): Cessna R182 · Clearwater, FL · Accident · No injuries · Limited investigation · Final report · Aug 19, 2017 · N9155C · Substantial damage > The improper maintenance of the landing gear system and subsequent failure of the hydraulic landing gear down return line, which resulted in a loss of hydraulic fluid and the pilot’s inability to extend and lock the main landing gear. - [NTSB ERA17FA148](https://openairdocs.org/ntsb/ERA17FA148.md): Piper PA 12 · Sanford, FL · Accident · 1 fatal · Field investigation · Final report · Apr 8, 2017 · N3280M · Destroyed > The incorrect rigging of the elevator control cables, which resulted in a reversal of elevator control inputs applied by the pilot during the takeoff, an excessive nose-high pitch, and subsequent aerodynamic stall after takeoff. Also causal was the inadequate… - [NTSB ERA17LA130](https://openairdocs.org/ntsb/ERA17LA130.md): Socata TB20 · Melbourne, FL · Accident · No injuries · Limited investigation · Final report · Feb 25, 2017 · N2519T · Substantial damage > Improper installation of the circlip within the nose gear strut, which resulted in the strut overextending in the wheel well and preventing the nose landing gear from extending during landing. - [NTSB ERA16LA268](https://openairdocs.org/ntsb/ERA16LA268.md): Frank Ware Velocity TXL · Sebastian, FL · Accident · No injuries · Limited investigation · Final report · Jul 23, 2016 · N916TC · Substantial damage > The total loss of engine power due to maintenance personnel’s improper setting of the aneroid adjustment. - [NTSB ERA16LA156](https://openairdocs.org/ntsb/ERA16LA156.md): Atkinson Eaglet · Deland, FL · Accident · Minor injuries · Limited investigation · Final report · Apr 13, 2016 · N5AQ · Substantial damage > A total loss of engine power during initial climb due to a separation of the ignition plug. - [NTSB ERA15LA332](https://openairdocs.org/ntsb/ERA15LA332.md): Lancair IV · Fort Lauderdale, FL · Accident · Serious injuries · Limited investigation · Final report · Aug 30, 2015 · N864KM · Destroyed > The mechanic's improper installation of the turbocharger assembly, which resulted in oil starvation and a subsequent total loss of the engine power. - [NTSB ERA15LA289](https://openairdocs.org/ntsb/ERA15LA289.md): Piper PA-28R-180 · Fort Lauderdale, FL · Accident · No injuries · Limited investigation · Final report · Jul 23, 2015 · N4631J · Substantial damage > The undetected fatigue cracks in the engine and nose landing gear (NLG) strut mount assembly, which prevented the proper alignment of the NLG after it was extended and the pilots from being able to maintain directional control after touchdown. - [NTSB ERA15IA198](https://openairdocs.org/ntsb/ERA15IA198.md): Dassault-Breguet Mystere Falcon 900 · Orlando, FL · Incident · No injuries · Class 2 · Incident · Final report · Apr 16, 2015 · N610RL · Minor damage > Unknown maintenance personnel’s inadequate securing of a wiring bundle during a maintenance, repair, or modification event, which led to chafing of the wiring bundle, an electrical short and arcing, and a subsequent in-flight fire. - [NTSB ERA15LA014](https://openairdocs.org/ntsb/ERA15LA014.md): Cessna 180K · Boca Raton, FL · Accident · Minor injuries · Limited investigation · Final report · Oct 12, 2014 · N2590K · Substantial damage > Maintenance personnel’s failure to apply proper torque to the cylinder flange nuts and through bolts, which resulted in shifting of the Nos. 1 and 2 main bearings, loss of lubrication, failure of the crankshaft, and a subsequent total loss of engine power. - [NTSB ERA15IA008](https://openairdocs.org/ntsb/ERA15IA008.md): Cessna S550 · Tampa, FL · Incident · No injuries · Incident investigation · Final report · Oct 4, 2014 · N550AJ · No damage > The lack of flat roller bearings in the two elevator trim tab actuators and maintenance personnel’s inadequate lubrication of the left elevator trim tab actuator, both of which resulted in the overstress fracture of the left internal screw and subsequent… - [NTSB ERA14LA130](https://openairdocs.org/ntsb/ERA14LA130.md): Victor M Cordero RV-9A · Apopka, FL · Accident · Serious injuries · Limited investigation · Final report · Feb 23, 2014 · N19VC · Substantial damage > The failure of the propeller spline shaft, the drive disk adapter, and the propeller speed reduction unit (PSRU) input spline due to a lack of inspection and lubrication, which resulted in a total loss of propeller drive and a subsequent forced landing.… - [NTSB ERA14FA123](https://openairdocs.org/ntsb/ERA14FA123.md): Williams Christopher T Sonex · Wellington, FL · Accident · 1 fatal · Field investigation · Final report · Feb 17, 2014 · N732SX · Destroyed > The pilot's failure to maintain adequate airspeed following a partial loss of engine power during initial climb, which led to the airplane exceeding its critical angle of attack and experiencing an aerodynamic stall. Contributing to the accident was the… - [NTSB ERA14LA042](https://openairdocs.org/ntsb/ERA14LA042.md): Piper PA28 · Homestead, FL · Accident · No injuries · Limited investigation · Final report · Nov 11, 2013 · N1830T · Substantial damage > A total loss of engine power due to the in-flight separation of the No. 3 cylinder because of the fatigue cracking of its respective mounting studs and through bolts, which resulted from inadequate maintenance by unknown personnel. - [NTSB ERA13IA326](https://openairdocs.org/ntsb/ERA13IA326.md): Piper PA-34 · Palm Coast, FL · Incident · No injuries · Incident investigation · Final report · Jul 17, 2013 · N767PE · No damage > The installation of an incorrect rudder trim tab control rod by unknown maintenance personnel, which resulted in the rod failing in flight due to overload and subsequent uncontrolled rudder oscillations. - [NTSB ERA13LA199](https://openairdocs.org/ntsb/ERA13LA199.md): Maxfly Inc/Mckay WM Searey · Polk City, FL · Accident · Minor injuries · Limited investigation · Final report · Apr 11, 2013 · N914WM · Substantial damage > The improper installation of incorrect attachment hardware by maintenance personnel during an undocumented repair, which resulted in an in-flight structural failure and subsequent loss of aircraft control. Contributing to the accident was the covering of the… - [NTSB ERA13FA186](https://openairdocs.org/ntsb/ERA13FA186.md): Robinson R44 · Miami, FL · Accident · 2 fatal · Field investigation · Final report · Apr 3, 2013 · N3101H · Destroyed > The mechanic's failure to properly secure the pitch link hardware of one main rotor blade to the rotating swash plate, which resulted in the pitch link separating in flight and the pilot's subsequent loss of control. Contributing to the accident was the… - [NTSB ERA13LA188](https://openairdocs.org/ntsb/ERA13LA188.md): Cessna 402C · Fort Lauderdale, FL · Accident · No injuries · Limited investigation · Final report · Apr 1, 2013 · VQ-TIN · Substantial damage > The disconnection of the nose landing gear actuator, which resulted in the subsequent collapse of the nose landing gear. Contributing to the accident was the repair station’s inadequate maintenance, postmaintenance inspection process, and oversight of the… - [NTSB ERA13LA175](https://openairdocs.org/ntsb/ERA13LA175.md): Mooney M20F · Leesburg, FL · Accident · No injuries · Limited investigation · Final report · Mar 16, 2013 · N9387V · Substantial damage > The incorrect rigging of the landing gear emergency extension system by unknown maintenance personnel, which resulted in a failure of the emergency extension cable, and jamming of the normal extension gear motor. - [NTSB ERA13LA048](https://openairdocs.org/ntsb/ERA13LA048.md): Cirrus Design SR22 · Pahokee, FL · Accident · No injuries · Limited investigation · Final report · Oct 21, 2012 · N6839R · Substantial damage > A main landing gear wheel fire for reasons that could not be determined because postaccident examinations did not reveal any anomalies that would have precluded normal operations. - [NTSB ERA12LA524](https://openairdocs.org/ntsb/ERA12LA524.md): Piper PA-32R-301T · Riverview, FL · Accident · No injuries · Limited investigation · Final report · Aug 23, 2012 · N362DM · Substantial damage > Damage to the propeller governor gasket during installation by unknown persons, which resulted in a total loss of engine oil in flight and a subsequent forced landing. - [NTSB ERA12LA494](https://openairdocs.org/ntsb/ERA12LA494.md): Piper PA-44-180 · Titusville, FL · Accident · No injuries · Limited investigation · Final report · Aug 1, 2012 · N740FT · Substantial damage > Inadequate maintenance servicing and inspection of the nose landing gear, which resulted in the failure of the nose landing gear to lock and its subsequent collapse during landing. - [NTSB ERA12LA366](https://openairdocs.org/ntsb/ERA12LA366.md): Bell 206B · Longboat Key, FL · Accident · No injuries · Limited investigation · Final report · May 25, 2012 · N806LA · Substantial damage > Unknown personnel's failure to comply with the engine manufacturer's engine fuel pump replacement guidance, which resulted in a total loss of engine power due to the engine fuel pump failure. - [NTSB ERA12CA278](https://openairdocs.org/ntsb/ERA12CA278.md): Piper PA-18A · West Palm Beach, FL · Accident · Minor injuries · Data collection · Final report · Apr 12, 2012 · N12003 · Substantial damage > The inadequate assembly of the brakes, which caused them to lock during the landing roll when the airplane transitioned from asphalt to turf, resulting in the airplane nosing over. - [NTSB ERA12LA234](https://openairdocs.org/ntsb/ERA12LA234.md): Cessna 172K · Pensacola, FL · Accident · No injuries · Limited investigation · Final report · Mar 16, 2012 · N79509 · Substantial damage > A total loss of engine power due to the improper installation of the crankshaft gear bolt or lockplate by maintenance personnel. Contributing to the accident was the lack of suitable terrain for a forced landing. - [NTSB ERA12LA219](https://openairdocs.org/ntsb/ERA12LA219.md): Cirrus Design SR22 · Homestead, FL · Accident · No injuries · Limited investigation · Final report · Mar 9, 2012 · N444VR · Substantial damage > The inadequate servicing and maintenance of the engine and the airplane owner and maintenance personnel's disregard of the manufacturer's recommended engine overhaul schedule and service bulletins, which resulted in an in-flight internal failure and seizure… - [NTSB ERA10LA235](https://openairdocs.org/ntsb/ERA10LA235.md): Cessna 152 · Avon Park, FL · Accident · No injuries · Limited investigation · Final report · Apr 18, 2010 · N5499B · Substantial damage > The operator's failure to correct known deficiencies with the carburetor, which resulted in a complete loss of engine power and subsequent forced landing by the pilot. Also causal was the operator's decision to rent the airplane in an unairworthy condition. - [NTSB ERA09LA221](https://openairdocs.org/ntsb/ERA09LA221.md): T51 T51 · Lake Wales, FL · Accident · No injuries · Limited investigation · Final report · Mar 25, 2009 · N332BC · Substantial damage > A partial loss of engine power due to the carburetor not being secured to its mounting pad. - [NTSB ERA09LA184](https://openairdocs.org/ntsb/ERA09LA184.md): Kevin Eldredge Stewart · Ocala, FL · Accident · 1 fatal · Limited investigation · Final report · Mar 6, 2009 · N551X · Substantial damage > A loss of engine power due to contamination and clogging of the fuel system by a post-assembly fuel tank sealant. - [NTSB ERA09LA047](https://openairdocs.org/ntsb/ERA09LA047.md): Bell 206B · Boynton Beach, FL · Accident · Minor injuries · Limited investigation · Final report · Nov 11, 2008 · N281CB · Substantial damage > A loss of engine power due to an undertorqued air line fitting to the fuel control. - [NTSB ERA09LA015](https://openairdocs.org/ntsb/ERA09LA015.md): Cessna 172 · Kissimmee, FL · Accident · Serious injuries · Limited investigation · Final report · Oct 12, 2008 · N734BL · Substantial damage > The pilot's inadequate preflight inspection, which resulted in a total loss of engine power during initial climb due to fuel contamination. Contributing to the accident was a fuel tank cap that did not seal properly. - [NTSB MIA08CA201](https://openairdocs.org/ntsb/MIA08CA201.md): Cox Clyde H Fshr Aero Vsns Clbty · Tampa, FL · Accident · Serious injuries · Data collection · Final report · Sep 25, 2008 · N716HJ · Substantial damage > The pilot’s failure to maintain control of the airplane during takeoff due to inadequate maintenance. - [NTSB NYC08LA213](https://openairdocs.org/ntsb/NYC08LA213.md): Marrin Pitts S-1 · St. Petersburg, FL · Accident · Minor injuries · Limited investigation · Final report · Jun 12, 2008 · N347MM · Substantial damage > The pilot's failure to maintain adequate airspeed following a partial loss of engine power, which resulted in an aerodynamic stall. Contributing to the accident was improper maintenance practices during the construction of the airplane, which resulted in… ## The whole list in SQL Runs in DuckDB 1.2 or later on the release's Parquet files over HTTPS: ```sql SELECT c."ntsbNumber", c."eventDate", c."eventType", c."eventCity", c."eventStateOrRegion", a.n_number, a."aircraftMake", a."aircraftModel", c."highestInjuryLevel", c."totalFatal", c."completionStatus", c.report_url FROM 'https://openairdocs.org/data/latest/ntsb_case_detail.parquet' c LEFT JOIN 'https://openairdocs.org/data/latest/ntsb_aircrafts.parquet' a ON a.case_mkey = c."mKey" AND a.position = 1 WHERE c."eventStateOrRegion" = 'FL' AND c."eventCountry" = 'USA' AND c."mKey" IN (SELECT s.case_mkey FROM 'https://openairdocs.org/data/latest/ntsb_events.parquet' s WHERE s."tier2Number" = '040' AND s.case_mkey IN (SELECT case_mkey FROM 'https://openairdocs.org/data/latest/ntsb_events.parquet' WHERE "isDefiningEvent")) ORDER BY c."eventDate" DESC, c."ntsbNumber" DESC ``` This list as a web page: https://openairdocs.org/ntsb-events/040/sequence?state=FL --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.