# NTSB CEN11LA237: Costruzioni Aeronautiche Tecna P2004 Bravo, N141AG, Austin, TX, March 18, 2011

- Type: NTSB accident investigation
- Classification: Accident · No injuries · Limited investigation · Final report
- Date: March 18, 2011, 13:20 local (18:20 UTC)
- Place: Austin, TX
- Coordinates: 30.225, -97.688888 (estimated)
- Nearby events: https://openairdocs.org/map.md?lat=30.2250&lon=-97.6889&mi=10
- Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping)
- Defining event: [Enroute: Loss of engine power (total)](https://openairdocs.org/ntsb-events/341)
- Highest injury: No injuries
- Injuries: 2 uninjured
- Status: Completed, report April 20, 2012
- Report: Approved by Office Director
- NTSB office: Central Region
- Parties: Federal Aviaton Administration, Tecnam North America, Agenzia Nazionale per la Sicurezza del Volo
- SAIBs cited in the narratives: [SAIB CE-09-35](https://openairdocs.org/saib/CE-09-35) (OpenAirDocs)
- NTSB case key (mKey): 78585
- NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=CEN11LA237
- NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/78585/pdf
- NTSB docket: https://data.ntsb.gov/Docket?ProjectID=78585
- Page: https://openairdocs.org/ntsb/CEN11LA237

## Probable cause

The loss of engine power due to fuel starvation for undetermined reasons.

## Findings

NTSB's coded findings; those marked are part of the probable cause.

- [Fluids: fuel](https://openairdocs.org/ntsb-findings/01071010): Aircraft › Fluids/misc hardware · Inadequate inspection; cases with it: [Costruzioni Aeronautiche Tecna P2004 BRAVO, 3 cases](https://openairdocs.org/ntsb-findings/01071010/cases.md?model=060001M), [All aircraft, 1,695 cases](https://openairdocs.org/ntsb-findings/01071010/cases.md)
- [Use of equip/info: use of checklist](https://openairdocs.org/ntsb-findings/02063030): Personnel issues › Task performance · Pilot; cases with it: [Costruzioni Aeronautiche Tecna P2004 BRAVO, 1 case](https://openairdocs.org/ntsb-findings/02063030/cases.md?model=060001M), [All aircraft, 336 cases](https://openairdocs.org/ntsb-findings/02063030/cases.md)
- [Not determined](https://openairdocs.org/ntsb-findings/05000000): Not determined › Not determined · Unknown/Not determined; cases with it: [Costruzioni Aeronautiche Tecna P2004 BRAVO, 3 cases](https://openairdocs.org/ntsb-findings/05000000/cases.md?model=060001M), [All aircraft, 2,247 cases](https://openairdocs.org/ntsb-findings/05000000/cases.md)
- [Fluids: fuel](https://openairdocs.org/ntsb-findings/01071010): Aircraft › Fluids/misc hardware · Not specified (probable cause); cases with it: [Costruzioni Aeronautiche Tecna P2004 BRAVO, 3 cases](https://openairdocs.org/ntsb-findings/01071010/cases.md?model=060001M), [All aircraft, 1,695 cases](https://openairdocs.org/ntsb-findings/01071010/cases.md)

## Sequence of events

The events NTSB coded, in order, by phase of flight. The defining event best describes what happened.

- [Enroute: Loss of engine power (total)](https://openairdocs.org/ntsb-events/341) (defining event); cases with it: [Costruzioni Aeronautiche Tecna P2004 BRAVO, 5 cases](https://openairdocs.org/ntsb-events/341/sequence.md?model=060001M), [All aircraft, 3,820 cases](https://openairdocs.org/ntsb-events/341/sequence.md)
- [Emergency descent: Off-field or emergency landing](https://openairdocs.org/ntsb-events/440); cases with it: [Costruzioni Aeronautiche Tecna P2004 BRAVO, 4 cases](https://openairdocs.org/ntsb-events/440/sequence.md?model=060001M), [All aircraft, 3,365 cases](https://openairdocs.org/ntsb-events/440/sequence.md)
- [Emergency descent: Collision with terr/obj (non-CFIT) ](https://openairdocs.org/ntsb-events/470); cases with it: [Costruzioni Aeronautiche Tecna P2004 BRAVO, 4 cases](https://openairdocs.org/ntsb-events/470/sequence.md?model=060001M), [All aircraft, 10,189 cases](https://openairdocs.org/ntsb-events/470/sequence.md)

## Analysis

Prior to the return leg of a cross-country flight, the pilot checked the airplane's fuel level by observing the fuel gauges. The pilot did not measure the actual fuel level; the Pilot’s Operating Handbook contains a warning that “pilots should verify actual fuel quantity visually in tanks before takeoff.” The airplane lost engine power while approaching the destination, and the pilot performed a forced landing; the airplane impacted a house, trees, and terrain. According to the pilot's calculations, the airplane “should have burned 4 gallons leaving 6 gallons.” However, the amount of fuel recovered postaccident was 2 gallons or less; the fuel tanks contain 0.25 gallons of unusable fuel. Although the pilot said that fuel was leaking after the accident, no fuel leaks were observed by or reported to first responders. There was some fuel found in one carburetor bowl, the other carburetor bowl did not have any fuel, and the gascolator did not have any fuel. Therefore, it is likely that the engine was not receiving adequate fuel to maintain power; however the investigation could not determine the reason for the starvation. No preimpact mechanical anomalies were detected.

## Factual narrative

On March 18, 2011, about 1320 central daylight time, a Costruzioni Aeronautiche Tecnam P2004 Bravo light sport airplane, N141AG, owned by US Aviation Group LLC and operated by Step Up Aviation LLC, sustained substantial damage when it impacted trees, a house, and terrain during a forced landing following an in-flight loss of engine power near Austin, Texas. The sport pilot and passenger reported no injuries. The personal flight was operating under the provisions of 14 Code of Federal Regulations Part 91 without a flight plan. Visual meteorological conditions prevailed. The flight originated from the Llano Municipal Airport (AQO), near Llano, Texas, about 1235, and was en route to the Austin-Bergstrom International Airport (AUS), near Austin, Texas, when the loss of engine power occurred. The pilot stated that he fully inspected the airplane during his preflight inspection. He said that he personally observed 14.5 to 15 gallons of fuel in the fuel tanks by using a "pre-measured stick" for this airplane and also confirmed the fuel reading on the fuel gauge. The pilot reported that it “was sufficient fuel” for the expected trip and enough fuel to exceed the “legal reserve.” He started the engine at 1020 and took off at 1040. He flew to AQO at 2,500 feet above mean sea level (MSL) with a power setting of 4,800 RPM and landed at AQO at 1130. According to the pilot, the operating handbook (POH) indicated that his fuel burn was 4.4 gallons per hour and his calculated total fuel burn for the flight to AQO was 4 gallons. The pilot stated that he had lunch and returned to AQO. He said, “I believed I had at least 10 gallons of fuel, which was confirmed on gauges.” The pilot’s report did not indicate that he visually rechecked the fuel tanks at AQO with the pre-measured stick. The pilot started the airplane engine at 1230 and took off at 12:35. He flew the return flight at 2,500 feet MSL direct to AUS. He reported that he lost engine power at 1320 after receiving air traffic control vectors to AUS. The pilot said that the flight to AUS was 50 minutes of flight time and that the airplane “should have burned 4 gallons leaving 6 gallons.” The pilot reported that he was unsure of why the engine stopped, but believed that it wasn't from fuel starvation. The pilot said the FAA drained 2 gallons of fuel from the aircraft well after the forced landing. After the airplane came to rest, fuel was leaking. The pilot was sure a good bit of fuel leaked out prior to the tanks being drained. The airplane impacted trees, a house, and terrain near the intersection of Suena Drive and Vasquez Street about 325 degrees and 1.25 nautical miles from the AUS runway 17R threshold. A Federal Aviation Administration (FAA) inspector examined the wreckage on-scene. The outboard section of the right wing, fuselage, and empennage sustained substantial damage. The inspector was able to recover fuel that he collected in a two-gallon container and he did not see any leaking fuel. There wassome fuel found in one carburetor bowl and the other carburetor bowl did not have any fuel. The gascolator did not have any fuel. No preimpact anomalies were detected. A first responder stated that there were no reported fuel leaks from the airplane and stated that he did not recall any fuel leaks. According to the POH, the airplane was equipped with two integral wing fuel tanks, which each had a capacity of 13.2 gallons. The airplane had a total fuel capacity of 26.4 gallons of which 26.15 gallons was usable fuel. Excerpts from the performance charts indicated: Pressure altitude Hp: 2000 ft OAT: +11°C Engine RPM ... Consumption (gal/h) ... 4600 4 5000 4.8 5200 5.2 Pressure altitude Hp: 4000 ft OAT: +7°C Engine RPM ... Consumption (gal/h) ... 4600 4 5000 4.5 5200 4.9 The POH had a warning in checklist procedures. The checklist, in part, stated: WARNING Fuel level indicated by the fuel quantity indicators (on the instrument panel) is only indicative. For flight safety, pilot should verify actual fuel quantity visually in tanks before takeoff. At 1332, the recorded temperature and dew point at AUS was respectively 28 degrees C and 17 degrees C. The carburetor icing probability chart from FAA Special Airworthiness Information Bulletin: CE-09-35 Carburetor Icing Prevention, June 30, 2009, shows a probability of serious icing at glide power at the local recorded temperature and dew point.

## Aircraft

- Registration: [N141AG](https://openairdocs.org/aircraft/N141AG), registered now, S/N 104, built 2007 (OpenAirDocs)
- Reported make and model: COSTRUZIONI AERONAUTICHE TECNA P2004 BRAVO
- Registry model: [Costruzioni Aeronautiche Tecna P2004 BRAVO](https://openairdocs.org/model/costruzioni-aeronautiche-tecna-p2004-bravo) (registry code 060001M) (OpenAirDocs)
- Registry engine: [Rotax 912ULS series](https://openairdocs.org/engine/rotax-912uls-series) (registry code 55572, 4 cycle) (OpenAirDocs)
- Category: Airplane
- Serial number: 104
- Engines: ROTAX 912ULS 100 horsepower reciprocating
- Damage: Substantial damage
- Flight: Personal, Part 91
- Operator: Step Up Aviation LLC
- Registered owner: US Aviation Group LLC
- Airworthiness certificate: Special, Special light-sport (Special)
- Last inspection: 100 hour, March 18, 2011
- Departed: AQO, Llano, TX
- Destination: AUS, Austin, TX
- Airport: AUS, Austin-Bergstrom IAP

## Flight crew

As NTSB recorded them. NTSB leaves out names.

- Pilot; age 18; injuries: none; sport pilot; airplane ratings: single-engine land; medical: class 3, with waivers/limitations; last flight review January 3, 2011; seat: left; flight hours: 47 total, 40 in this make and model, 14 as pilot in command, 18 in the last 90 days, 6 in the last 30 days

## Weather

- Conditions: Visual (VMC), Day
- Wind: 200° at 13 knots
- Visibility: 10 statute miles
- Lowest ceiling: none
- Temperature: 82 °F, dew point 63 °F
- Altimeter: 30.12 inHg
- Observed at: AUS, 2 nm away

## FAA reports on this event (1)

The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs).

- [Accident 20110318003929A](https://openairdocs.org/incident/20110318003929A), Mar 18, 2011: Costruzioni Aeronautiche Tecna P2004 BRAVO, Austin, TX, Substantial damage. Pilot stated he departed Austin, with 15 gallons of fuel, flew to lano Texas and returned, engine quit on approach to Austin airport, had one passanger, he…

## Docket (7 files)

The files NTSB released with the investigation on February 7, 2012, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=78585. 3.9 MB in all.

- Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1 (item 1, .PDF, 332 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40360948&FileExtension=.PDF&FileName=Pilot%2FOperator%20Aircraft%20Accident%20Report,%20NTSB%20Form%206120.1-Redacted.PDF
- Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1 - Attachments (item 2, .PDF, 2.4 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40360947&FileExtension=.PDF&FileName=Pilot%2FOperator%20Aircraft%20Accident%20Report,%20NTSB%20Form%206120.1%20-%20Attachments-Redacted.PDF
- Miscellaneous - POH Excerpt (item 3, .PDF, 920 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40361116&FileExtension=.PDF&FileName=Miscellaneous%20-%20POH%20Excerpt-Master.PDF
- Correspondence - E-mail Record of Conversation (item 4, .PDF, 95 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40361189&FileExtension=.PDF&FileName=Correspondence%20-%20E-mail%20Record%20of%20Conversation-Redacted.PDF
- Miscellaneous - Communication Summary (item 5, .PDF, 51 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40360564&FileExtension=.PDF&FileName=Miscellaneous%20-%20Communication%20Summary-Master.PDF
- Miscellaneous - Communication Summary (item 6, .PDF, 79 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40361110&FileExtension=.PDF&FileName=Miscellaneous%20-%20Communication%20Summary-Master.PDF
- Miscellaneous - Carb Icing Chart (item 7, .PDF, 50 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40361164&FileExtension=.PDF&FileName=Miscellaneous%20-%20Carb%20Icing%20Chart-Master.PDF

From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model.

---
OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.