# NTSB CEN12LA326: Mooney M20J, N2159D, Ozark, AR, May 25, 2012 - Type: NTSB accident investigation - Classification: Accident · Minor injuries · Limited investigation · Final report - Date: May 25, 2012, 15:36 local (20:36 UTC) - Place: Ozark, AR - Coordinates: 35.510833, -93.839447 - Nearby events: https://openairdocs.org/map.md?lat=35.5108&lon=-93.8394&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Defining event: [Enroute-cruise: Loss of engine power (total)](https://openairdocs.org/ntsb-events/341) - Highest injury: Minor injuries - Injuries: 1 minor, 1 uninjured - Status: Completed, report June 11, 2014 - Report: Approved by Office Director - NTSB office: Central Region - Parties: FAA - Little Rock FSDO - NTSB case key (mKey): 83785 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=CEN12LA326 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/83785/pdf - NTSB docket: https://data.ntsb.gov/Docket?ProjectID=83785 - Page: https://openairdocs.org/ntsb/CEN12LA326 ## Probable cause The failure of a connecting rod due to oil starvation. ## Findings NTSB's coded findings; those marked are part of the probable cause. - [Fluids: oil](https://openairdocs.org/ntsb-findings/01071020): Aircraft › Fluids/misc hardware · Fluid level (probable cause); cases with it: [Mooney M20J, 3 cases](https://openairdocs.org/ntsb-findings/01071020/cases.md?model=5870219), [All aircraft, 174 cases](https://openairdocs.org/ntsb-findings/01071020/cases.md) - [Engine (reciprocating): recip engine power section](https://openairdocs.org/ntsb-findings/01058520): Aircraft › Aircraft power plant · Failure (probable cause); cases with it: [Mooney M20J, 3 cases](https://openairdocs.org/ntsb-findings/01058520/cases.md?model=5870219), [All aircraft, 233 cases](https://openairdocs.org/ntsb-findings/01058520/cases.md) ## Sequence of events The events NTSB coded, in order, by phase of flight. The defining event best describes what happened. - [Enroute-cruise: Loss of engine power (total)](https://openairdocs.org/ntsb-events/341) (defining event); cases with it: [Mooney M20J, 13 cases](https://openairdocs.org/ntsb-events/341/sequence.md?model=5870219), [All aircraft, 3,820 cases](https://openairdocs.org/ntsb-events/341/sequence.md) - [Landing: Collision with terr/obj (non-CFIT) ](https://openairdocs.org/ntsb-events/470); cases with it: [Mooney M20J, 41 cases](https://openairdocs.org/ntsb-events/470/sequence.md?model=5870219), [All aircraft, 10,189 cases](https://openairdocs.org/ntsb-events/470/sequence.md) ## Analysis The pilot reported that, during cruise flight, he noticed a change in engine sound and that he subsequently scanned the engine gauges, which were all within normal operating parameters. Shortly after, the engine rpm began to drop, the pilot heard a "pop" or "bang," and the propeller stopped rotating. The pilot attempted to glide the airplane to an alternate airport, but the airplane overshot the runway. The pilot then attempted to land on a nearby road, and the left wing of the airplane struck the ground during the maneuver. Oil streaking was observed on the airplane's exterior. Postaccident examination of the engine revealed that no oil was not present in the engine. During disassembly of the engine, the No. 4 connecting rod cap was found fractured, and pieces of the cap were found within the crankcase. Evidence indicated that the No. 4 connecting rod failed due to frictional heating and impact associated with a bearing failure. The Nos. 1 to 3 connecting rods and connecting rod bolts showed varying degrees of heat discoloration, and the evidence of heating in the Nos. 2 and 4 connecting rods indicated that the No. 4 bearing failure was due to lack of oil in the connecting rod bearings. The cause of the oil starvation could not be determined. ## Factual narrative On May 25, 2012, about 1536 central daylight time, a Mooney M20J single engine airplane, N2159D, experienced a total loss of engine power during cruise flight. The pilot subsequently attempted a landing at the Ozark Franklin County Airport (7M5), Ozark, Arkansas. The pilot sustained minor injuries and a passenger was not injured. The airplane sustained substantial damage to the fuselage and both wings. The airplane was registered to Tuttle and associates LLC, and operated by the pilot under the provisions of 14 Code of Federal Regulations Part 91 as a personal flight. Visual meteorological conditions prevailed and no flight plan had been filed. The flight originated from the Tulsa International Airport (TUL) and was destined for the Tunica Municipal Airport (UTA), Tunica, Mississippi when the accident occurred. The pilot reported that while in cruise flight, he noticed a change in engine sound. He scanned the engine gauges and all were within the green arcs. The engine RPM began to drop and the pilot heard a bang or pop. The pilot reported that the propeller immediately stopped rotating. The pilot was given vectors to 7M5 by air traffic control. The pilot reported that he circled the airport 4 or 5 times and set up for landing. During the landing approach, the airplane was high and overshot the runway. The pilot turned to avoid buildings and attempted a landing on a nearby road but the airplane's left wing impacted the ground. The airplane sustained damage to its wings and fuselage. According to maintenance records, the most recent annual inspection was completed on May 11, 2012. At the time of the inspection, the engine had accumulated 258.5 hours since its most recent overhaul. The maintenance entry for the annual inspection of the engine noted that the propeller governor was removed and reinstalled for overhaul. The entry noted that the oil was changed and a ground run accomplished with satisfactory results. The airplane was powered by a Lycoming IO-360-A3B6D engine, serial number RL-20029-51A, rated to produce 200 horsepower. Initial examination of the airplane revealed oil streaking on the fuselage emanating from the cowl. Examination of the engine after the accident revealed that no oil was present in the engine and the aft connecting rod was protruding from a hole in the top of the engine crankcase. The propeller governor installation appeared to have been accomplished according to the instructions contained in the maintenance manual and leaking from the governor pad was not observed. The crankcase oil drain plug was installed with safety wire and no leaks observed. The source of the oil leak could not be identified. During later disassembly of the engine, it was found that the No. 4 connecting rod cap was missing and the crankshaft end of the connecting rod was deformed and discolored. Pieces of the missing connecting rod cap were found within the debris collected from the engine crankcase. While disassembling the engine it was notedthat very little torque was required to remove the intact connecting rod cap bolts, particularly on the No. 3 connecting rod. The No. 1 connecting rod and bearing showed no evidence of heat discoloration. The No. 2, 3 and 4 connecting rods all showed varying amounts of heat related discoloration with the No. 3 connecting rod showing more discoloration than the No. 2 connecting rod, and the No. 4 connecting rod showing more discoloration than the No. 3 connecting rod. All of the recovered connecting rod bolts along with the No. 3 connecting rod and cap, and the fractured pieces of the No. 4 connecting rod cap were examined in the NTSB Materials Laboratory. The fracture surfaces on the recovered pieces of the No. 4 connecting rod cap were obliterated by post-fracture damage. A piece of the bolt was trapped in the fractured cap and its fracture surface was almost completely obliterated, but the remaining portions of the fracture surface exhibited features consistent with overstress failure. Heat tinting was observed on the No. 4 connecting rod, the submitted pieces of the No. 4 connecting rod cap, and on the crankshaft end of the No. 3 connecting rod assembly, including the No. 3 connecting rod bolts. No heat tinting was noted on the No.1 and No. 2 connecting rod bolts. The No. 3 connecting rod was intact, but the cap showed impact marks on the inboard face. The cap half of the bearing was present in the cap. The bearing was tinted dark consistent with heat damage, and the edges at the middle of the bearing were extruded outward. Pits, delamination, and smeared material were observed on the interior surface. The pits and delaminations had an orange color consistent with a copper-lead intermediate layer. One of the connecting rod bolts from the No. 1 cylinder exhibited necking deformation in the grip portion of the bolt shank. The connecting rod bolts from cylinders 1 through3 were measured in diameter and length and compared to engineering drawings. One connecting rod bolt from the No.2 cylinder was within the specifications for length and minimum diameter. The other No. 2 connecting rod bolt was 0.001 inch below the minimum diameter but within the length specifications. The remaining bolts were longer and smaller in diameter than the specifications. ## Aircraft - Registration: [N2159D](https://openairdocs.org/deregistered/N2159D-2018-02-07), registration cancelled 2018-02-07, S/N 24-0547, built 1978 (OpenAirDocs) - Reported make and model: MOONEY M20J - Registry model: [Mooney M20J](https://openairdocs.org/model/mooney-m20j) (registry code 5870219) (OpenAirDocs) - Category: Airplane - Serial number: 24-0547 - Airframe hours: 4865 - Engines: Lycoming IO-360-A3B6D 200 horsepower reciprocating - Damage: Substantial damage - Flight: Personal, Part 91 - Airworthiness certificate: Standard, Normal - Last inspection: Annual, May 11, 2012 - Departed: TUL, Tulsa, OK - Destination: UTA, Tunica, MS - Airport: 7M5, Ozark Franklin County Airport, runway 22, 3,302 × 75 ft, asphalt ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 58; injuries: minor; private; airplane ratings: single-engine land; medical: class 3, without waivers/limitations; seat: left ## Weather - Conditions: Visual (VMC), Day - Wind: 170° at 7 knots, gusting 16 - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 91 °F, dew point 64 °F - Altimeter: 29.87 inHg - Observed at: FSM, 28 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20120525008979A](https://openairdocs.org/incident/20120525008979A), May 25, 2012: Mooney M20J, Ozark, AR, Destroyed. On may 25, 2012, at approximately 1536 CDT, N2159D, a Mooney M20J aircraft, operated by a private pilot attempted an emergency landing at the Ozark-franklin… ## Docket (13 files) The files NTSB released with the investigation on May 8, 2014, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=83785. 32.2 MB in all. - Pilot Statement (item 1, .PDF, 130 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412131&FileExtension=.PDF&FileName=Pilot%20Statement-Redacted.PDF - Maintenance Record Excerpts (item 2, .PDF, 715 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412132&FileExtension=.PDF&FileName=Maintenance%20Record%20Excerpts-Redacted.PDF - Accident Scene Diagram by FAA Inspector (item 3, .PDF, 183 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412133&FileExtension=.PDF&FileName=Accident%20Scene%20Diagram%20by%20FAA%20Inspector-Master.PDF - Materials Laboratory 15 - Factual Report 13-105 (item 4, .PDF, 196 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40409795&FileExtension=.PDF&FileName=Materials%20Laboratory%2015%20-%20Factual%20Report%2013-105-Master.PDF - Photo 1. Right view of airplane (Photo Courtesy of FAA) (item 5, .PDF, 4.3 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412134&FileExtension=.PDF&FileName=Photo%201.%20Right%20view%20of%20airplane%20(Photo%20Courtesy%20of%20FAA)-Master.PDF - Photo 2. Front view of airplane (Photo Courtesy of FAA) (item 6, .PDF, 4.7 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412135&FileExtension=.PDF&FileName=Photo%202.%20Front%20view%20of%20airplane%20(Photo%20Courtesy%20of%20FAA)-Master.PDF - Photo 3. Rear view of airplane (Photo Courtesy of FAA) (item 7, .PDF, 4.0 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412136&FileExtension=.PDF&FileName=Photo%203.%20Rear%20view%20of%20airplane%20(Photo%20Courtesy%20of%20FAA)-Master.PDF - Photo 4. Left view of airplane (Photo Courtesy of FAA) (item 8, .PDF, 3.1 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412137&FileExtension=.PDF&FileName=Photo%204.%20Left%20view%20of%20airplane%20(Photo%20Courtesy%20of%20FAA)-Master.PDF - Photo 5. View of left wing leading edge oil streaking (Photo Courtesy of FAA) (item 9, .PDF, 4.0 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412138&FileExtension=.PDF&FileName=Photo%205.%20View%20of%20left%20wing%20leading%20edge%20oil%20streaking%20(Photo%20Courtesy%20of%20FAA)-Master.PDF - Photo 6. View of left fuselage showing oil streaking (Photo Courtesy of FAA) (item 10, .PDF, 4.6 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412139&FileExtension=.PDF&FileName=Photo%206.%20View%20of%20left%20fuselage%20showing%20oil%20streaking%20(Photo%20Courtesy%20of%20FAA)-Master.PDF - Photo 7. Connecting rod protruding through engine case (Photo Courtesy of FAA) (item 11, .PDF, 4.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412140&FileExtension=.PDF&FileName=Photo%207.%20Connecting%20rod%20protruding%20through%20engine%20case%20(Photo%20Courtesy%20of%20FAA)-Master.PDF - Photo 8. Connecting rods after disassembly (item 12, .PDF, 1.0 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412141&FileExtension=.PDF&FileName=Photo%208.%20Connecting%20rods%20after%20disassembly-Master.PDF - Photo 9. Number 4 connecting rod (item 13, .PDF, 1.1 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40412142&FileExtension=.PDF&FileName=Photo%209.%20Number%204%20connecting%20rod-Master.PDF From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.