# NTSB CEN14LA021: Pohoski RV 4, N10XP, New Waverly, TX, October 19, 2013 - Type: NTSB accident investigation - Classification: Accident · No injuries · Limited investigation · Final report - Date: October 19, 2013, 16:00 local (21:00 UTC) - Place: New Waverly, TX - Coordinates: 30.547222, -95.436386 (estimated) - Nearby events: https://openairdocs.org/map.md?lat=30.5472&lon=-95.4364&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Defining event: [Enroute: Fire/smoke (non-impact)](https://openairdocs.org/ntsb-events/150) - Highest injury: No injuries - Injuries: 1 uninjured - Status: Completed, report September 29, 2014 - Report: Approved by Office Director - NTSB office: Central Region - Parties: Federal Aviation Administration - NTSB case key (mKey): 88325 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=CEN14LA021 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/88325/pdf - NTSB docket: https://data.ntsb.gov/Docket?ProjectID=88325 - Page: https://openairdocs.org/ntsb/CEN14LA021 ## Probable cause An in-flight fire for reasons that could not be determined because the wreckage was consumed by fire. ## Findings NTSB's coded findings; those marked are part of the probable cause. - [Not determined](https://openairdocs.org/ntsb-findings/05000000): Not determined › Not determined · Unknown/Not determined (probable cause); cases with it: [Pohoskijames G RV-4, 1 case](https://openairdocs.org/ntsb-findings/05000000/cases.md?model=05608FB), [All aircraft, 2,247 cases](https://openairdocs.org/ntsb-findings/05000000/cases.md) ## Sequence of events The events NTSB coded, in order, by phase of flight. The defining event best describes what happened. - [Enroute: Fire/smoke (non-impact)](https://openairdocs.org/ntsb-events/150) (defining event); cases with it: [Pohoskijames G RV-4, 1 case](https://openairdocs.org/ntsb-events/150/sequence.md?model=05608FB), [All aircraft, 504 cases](https://openairdocs.org/ntsb-events/150/sequence.md) - [Emergency descent: Fire/smoke (non-impact)](https://openairdocs.org/ntsb-events/150); cases with it: [Pohoskijames G RV-4, 1 case](https://openairdocs.org/ntsb-events/150/sequence.md?model=05608FB), [All aircraft, 504 cases](https://openairdocs.org/ntsb-events/150/sequence.md) - [Landing: Off-field or emergency landing](https://openairdocs.org/ntsb-events/440); cases with it: [Pohoskijames G RV-4, 1 case](https://openairdocs.org/ntsb-events/440/sequence.md?model=05608FB), [All aircraft, 3,365 cases](https://openairdocs.org/ntsb-events/440/sequence.md) - [Landing: Fire/smoke (non-impact)](https://openairdocs.org/ntsb-events/150); cases with it: [Pohoskijames G RV-4, 1 case](https://openairdocs.org/ntsb-events/150/sequence.md?model=05608FB), [All aircraft, 504 cases](https://openairdocs.org/ntsb-events/150/sequence.md) ## Analysis The pilot reported that he smelled "electrical" smoke during a cross-country flight in his experimental amateur-built airplane. The pilot decided to land immediately and moved the throttle to idle. He diverted the airplane, but, when he realized that the airplane was not going to be able to reach the diversion airpark, he executed a precautionary landing to a pasture. The airplane was intact when it came to rest. After the pilot exited the airplane, he saw smoke and flames coming from the tunnel located at the firewall between the rudder pedals that housed the forward stick assembly, fuel filter, fuel selector valve, electric fuel boost pump, and a conduit for wires from the back of the airplane. The stainless steel firewall remained intact; however, the wires and controls that ran through the fittings were burned. The pilot reported that no fuel was seeping, that he saw no blue stains, and that he did not smell fuel in the cockpit. The cause of the in-flight fire could not be determined due to the extent of the fire damage. ## Factual narrative On October 19, 2013, about 1600 central daylight time, an experimental amateur-built Pohoski RV4 airplane, N10XP, landed off-field near New Waverly, Texas, when the pilot smelled smoke in the cockpit. The pilot was uninjured. The airplane was destroyed during a subsequent ground fire. The airplane was registered to and operated by the pilot under the provisions of 14 Code of Federal Regulations Part 91 as a personal flight. Day visual flight rules (VFR) conditions prevailed for the flight, which did not operate on a VFR flight rules flight plan. The flight originated from the Livingston Municipal Airport (00R), near Livingston, Texas, about 1540, and was destined for the Sandy Creek Airstrip, near New Waverly, Texas. According to the pilot, the airplane was refueled at 00R at 1528. About four miles from the intended destination, he smelled and saw smoke and turned toward Estates Airpark, which was the closest airport. The smoke increased in intensity so the pilot retarded the throttle to idle. He executed a precautionary landing in a pasture north of the diversion airpark. The airplane was intact when it came to rest and the pilot saw smoke and flames as he exited the airplane. The pilot reported that the airplane burned and that a patch of grass, about a 15-foot diameter, was burned around the aircraft. The pilot indicated the smoke and fire was coming from the tunnel (at the firewall, between the rudder pedals) that is between your feet, in the RV-4. He stated that the fuel selector was mounted as shown on the kit manufacturer's plans for the tunnel. The selector valve's out-port was connected to a fuel filter, the filter was connected to an electric fuel pump, and the pump was connected to a bulkhead fitting on the firewall. The tunnel additionally housed the forward stick assembly and a conduit for wires from the back of the aircraft. The pilot said that the stainless steel firewall remained intact, however the wires and controls which ran through fittings did burn. The battery was mounted in the baggage compartment and not in the tunnel as shown on the plans for center of gravity consideration. The pilot stated that there was absolutely no seeping fuel; no telltale blue stains or fuel smell in the cockpit. He said that he did a "lot" of aerobatics, and in positive or negative g flight there was no smell of fuel. The pilot stated that the smoke he smelled was not electrical smoke but combustion smoke. He did not have time to look under the panel or troubleshoot the smoke and landed immediately. After landing, the pilot did see flames at the firewall side of the tunnel as he exited the airplane. He said, "What caused it I do not know." The pilot said that the first item he checked on a preflight is fuel or oil under the airplane. The engine was always leak free and the floor was dry when he took the airplane out before the accident flight. ## Aircraft - Registration: [N10XP](https://openairdocs.org/deregistered/N10XP-2016-01-07), registration cancelled 2016-01-07, S/N 1130, built 1990 (OpenAirDocs) - Reported make and model: POHOSKI RV 4 (NO SERIES) - Registry model: [Pohoskijames G RV-4](https://openairdocs.org/model/pohoskijames-g-rv-4) (registry code 05608FB) (OpenAirDocs) - Registry engine: [Amateur-built UNKNOWN ENG](https://openairdocs.org/engine/amateur-built-unknown-eng) (registry code 99999) (OpenAirDocs) - Category: Airplane, amateur-built - Serial number: 1130 - Year built: 1990 - Airframe hours: 1473.6 - Engines: Teledyne Matituck TMX IO 360 180 horsepower reciprocating - Damage: Destroyed - Fire: Both - Flight: Personal, Part 91 - Airworthiness certificate: Special, Experimental (Special); Special, Restricted (Special) - Last inspection: Condition, January 24, 2013 - Departed: 00R, LIVINGSTON, TX - Destination: New Waverly, TX - Airport: XS09, Estates Airpark ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 64; injuries: none; commercial, flight engineer, airline transport; airplane ratings: single-engine sea; instrument ratings: airplane; medical: class 3, without waivers/limitations; last flight review November 15, 2011; seat: front; restraint: 3-point; flight hours: 16,500 total, 1,548 in this make and model, 13,578 as pilot in command, 18 in the last 90 days, 6 in the last 30 days ## Weather - Conditions: Visual (VMC), Day - Wind: 350° at 9 knots, gusting 15 - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 68 °F, dew point 43 °F - Altimeter: 30.09 inHg - Observed at: KCXO, 11 nm away ## Docket (5 files) The files NTSB released with the investigation on May 7, 2014, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=88325. 1.8 MB in all. - Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1 (item 1, .PDF, 1.4 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40402981&FileExtension=.PDF&FileName=Pilot%2FOperator%20Aircraft%20Accident%20Report,%20NTSB%20Form%206120.1-Redacted.PDF - Communication Summary (item 2, .PDF, 80 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40411992&FileExtension=.PDF&FileName=Communication%20Summary%20-Master.PDF - Communication Summary (item 3, .PDF, 85 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40411993&FileExtension=.PDF&FileName=Communication%20Summary-Master.PDF - Van’s Drawing number 27-4 (item 4, .PDF, 142 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40411994&FileExtension=.PDF&FileName=Van%E2%80%99s%20Drawing%20number%2027-4-Master.PDF - Van’s Drawing number 39-4 (item 5, .PDF, 142 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40411995&FileExtension=.PDF&FileName=Van%E2%80%99s%20Drawing%20number%2039-4-Master.PDF From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.