# NTSB CHI06FA110: Messerschmitt-Bolkow-Blohm BO 105LS A-3, N202LF, Green Bay, WI, April 13, 2006 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: April 13, 2006, 10:22 local (15:22 UTC) - Place: Green Bay, WI - Coordinates: 44.471389, -87.994445 - Nearby events: https://openairdocs.org/map.md?lat=44.4714&lon=-87.9944&mi=10 - Phase of flight: [Takeoff](https://openairdocs.org/ntsb-phases/300) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 1 fatal - Status: Completed, report January 31, 2008 - Report: Approved by Office Director - Parties: FAA - Milwaukee FSDO, American Eurocopter, LLC, County Rescue Services, Inc., Rolls-Royce - SAIBs cited in the narratives: [SAIB SW-06-65](https://openairdocs.org/saib/SW-06-65) (OpenAirDocs) - NTSB case key (mKey): 63492 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=CHI06FA110 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/63492/pdf - Page: https://openairdocs.org/ntsb/CHI06FA110 ## Probable cause The pilot's inadequate preflight check of the flight controls prior to takeoff and the directional contol not possible by the pilot. Additional causes were the improper installation of the anti-torque pedal cover by company personnel which blocked the flight control system. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of control - in flight, takeoff - flight control system - blocked(total) (cause) - preflight planning/preparation - inadequate, pilot in command (cause) - maintenance,installation - improper, company maintenance personnel (cause) - directional control - not possible, pilot in command (cause) - In flight collision with terrain/water, descent - terrain condition - open field ## Analysis The emergency medical helicopter impacted terrain following takeoff when it began spinning around its vertical axis to a height of approximately 200-300 feet and descended without directional control. The copilot's anti-torque control pedals were found in their full forward position with a safety wire installation that would provide for forward travel of the anti-torque pedals which was contrary to specifications cited in the field approval for the pedal cover. Aircraft logbook entries show that the cover was reinstalled following a company training and evaluation flight. ## Factual narrative HISTORY OF FLIGHT On April 13, 2006, at 1022 central daylight time, a Messerschmitt-Bolkow-Blohm BO 105LS A-3, N202LF, operated by County Rescue Services, Inc., as an emergency medical service (EMS) helicopter, received substantial damage on impact with terrain following a reported loss of directional control during takeoff from the operator's heliport, GRBC Rescue Heliport, Green Bay, Wisconsin. Visual meteorological conditions prevailed at the time of the accident. The 14 CFR Part 91 flight was not operating on a flight plan. The pilot was fatally injured. The local flight was originating at the time of the accident. The pilot was conducting a maintenance test flight to check the VOR receiver that had been recently installed on the helicopter. Witnesses reported that as the helicopter lifted off the dolly located on the helipad (107 feet by 75 feet, concrete), it started rotating around the helicopter's vertical axis. They stated that the helicopter reached an altitude of approximately 200-300 feet above ground while still rotating. The helicopter stopped spinning and started "a rapid descent". The witnesses stated that the helicopter was descending at a speed "far greater than was reasonably possible" for a normal landing. The witnesses reported the helicopter struck the ground in an upright position. PERSONNEL INFORMATION According to Federal Aviation Administration (FAA) records, the pilot was issued a commercial pilot certificate with airplane single-engine land and rotorcraft-helicopter ratings on June 18, 2004. The pilot also held an instrument rating for airplanes and helicopters. On June 30, 2005, the pilot was issued a second class medical certificate with the limitation "use corrective glasses all times". According to the operator's accident report, the pilot had accumulated 3,074 hours of total flight time, with 2,900 hours in helicopters. The pilot had 85 hours in the accident helicopter model. The pilot had flown 48 hours in the previous 90 days and 16 hours in the previous 30 days. The pilot had flown 4 hours in the accident model in the previous 30 days. According to operator records, the pilot successfully completed a 14 CFR Part 135 checkride, administered by a company 14 CFR Part 135 check airman, on March 31, 2006. AIRCRAFT INFORMATION The helicopter was a Messerschmitt-Bolkow-Blohm BO 105LS A-3, serial number 2014, built in 1987. The helicopter was converted for use as an EMS helicopter and was capable of seating 4 people. It had a certified max gross weight of 5,732 lbs. The helicopter was issued a standard airworthiness certificate on September 8, 1988, and was operated by County Rescue Services, Inc. The FAA issued the current aircraft registration certificate on September 21, 2000. The last approved airworthiness inspection program (AAIP) inspection was completed on March 22, 2006. The helicopter had a total service time of 4,823 hours at the time of the accident. A review of the airframe maintenance records found no history of unresolved operational issues. The helicopter was equipped with two 500 shaft horsepower Allison/Rolls-Royce 250-C28C turbo shaft engines, serial numbers CAE 280089 and CAE 280056 for the #1 and #2 engines, respectively. The #1 and #2 engines had total service times of 4,707.1 and 4,695.1 hours, respectively, at the time of the accident. A review of the engine maintenance records found no history of unresolved operational issues. When the helicopter was converted to EMS use, the left front seat was reversed and the anti-torque control pedals in front of the seat are covered with a box. The original installation was performed on December 9, 1988, through a field approval by the FAA's Flight Standards Service and documented in Major Repair and Alteration (FAA Form 337) form. The FAA Form 337 states, in part: "Temporary removal of the covers shall be performed by a licensed airframe mechanic with a logbook entry only." WRECKAGE AND IMPACT INFORMATION The helicopter wreckage came to rest upright in a field adjacent to the operator's heliport. There were no ground scars near the point of impact. Three of the four main rotor blades remained attached to the main rotor head. The tail boom remained attached to the fuselage. At left front (co-pilot) seat position, a box was found covering the anti-torque control pedals with a placard on the cover in red letters on a white background that stated: "Caution! The pedals must be in the full aft position for cover installation." Upon removal of the cover, the anti-torque control pedals were found to be in their full forward position and the safety wire was installed backwards. The forward travel of the left anti-torque control pedal was limited by a flange on the inside of the cover. The forward travel of the left pedal before contacting the internal flange was approximately 1.25 inches. TESTS AND RESEARCH On March 30, 2006, two entries were made in the aircraft logbook regarding the co-pilot anti-torque control pedal cover. The two entries stated: "3-30-06 ACTT 4,821.5 Installed dual controls I/A/W CRS Training Manual" "3-30-06 ACTT 4,823.3 Removed dual controls IAW CRS Tr Man" The first entry was signed by the operator's director of operations and the second entry was signed by the operator's chief pilot, both of whom had received the training necessary to install and remove the anti-torque control pedal cover in accordance with company operation specifications and training requirements. The cover had been removed for a dual pilot training and evaluation session prior to the accident flight. The accident flight was the first flight after the co-pilot anti-torque control pedal cover had been re-installed. According to the FAA Form 337, the adjustable anti-torque control pedals are required to be in their full aft position before the cover is installed. The anti-torque control pedal cover is also required to have the placard "Caution! The pedals must be in the full aft position for cover installation" written in white letters on a red background. According to the helicopter manufacturer's representative, there are two drag screws on both pilot and co-pilot pedal assemblies that are required to be adjusted to "no play" between the end of the screws and the floor plate. The screws on both pedal assemblies were not adjusted to "no play" and the measured distance from the screws to the floor was approximately 0.025 inch. MEDICAL AND PATHOLOGICAL INFORMATION An autopsy was performed on the pilot by the Brown County Medical Examiner. The FAA Civil Aeromedical Institute prepared a Final Forensic Toxicology Accident Report. The report was negative for all substances tested. ADDITIONAL INFORMATION A Special Airworthiness Information Bulletin, SW-06-65, was issued following the accident. The parties to the investigation were the FAA, American Eurocopter LLC, Rolls-Royce, and County Rescue Services Inc. The Transportation Safety Board of Canada provided an accredited representative to the investigation. The aircraft wreckage was released to a representative of the owner. ## Aircraft - Registration: [N202LF](https://openairdocs.org/deregistered/N202LF-2006-07-25), registration cancelled 2006-07-25, S/N 2014, built 1988 (OpenAirDocs) - Reported make and model: Messerschmitt-Bolkow-Blohm BO 105LS A-3 - Registry model: [Messerschmitt-Bolkow-Blohm BO 105LS A-3](https://openairdocs.org/model/messerschmitt-bolkow-blohm-bo-105ls-a-3) (registry code 5626020) (OpenAirDocs) - Registry engine: [Allison 250-C28 series](https://openairdocs.org/engine/allison-250-c28-series) (registry code 03022, turbo-shaft) (OpenAirDocs) - Category: Helicopter - Serial number: 2014 - Airframe hours: 4823 - Engines: Allison/Rolls-Royce 250-C28C 500 horsepower turbo shaft - Damage: Substantial damage - Flight: Flight test, Part 91 - Operator: County Rescue Services, Inc. - Registered owner: Wells Fargo Bank Northwest NA Trustee - Airworthiness certificate: Standard, Normal - Last inspection: AAIP, March 1, 2006 - Departed: 4WN7, Green Bay, WI - Destination: 4WN7 - Flight plan: Company VFR - Airport: 4WN7, County Rescue Services Helipor, runway H1, 107 × 75 ft, concrete ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 46; injuries: fatal; commercial; airplane ratings: single-engine land; instrument ratings: helicopter, airplane; medical: class 2, with waivers/limitations; last flight review March 1, 2006; seat: right; toxicology performed; flight hours: 3,074 total, 85 in this make and model, 2,030 as pilot in command, 48 in the last 90 days, 16 in the last 30 days, 0 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Wind: 230° at 3 knots - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 64 °F, dew point 41 °F - Altimeter: 30.04 inHg - Observed at: 4WN7 ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20060413005539A](https://openairdocs.org/incident/20060413005539A), Apr 13, 2006: Bolkms BO105LSA3, Green Bay, WI, Destroyed, 1 fatal. (-23) During the crash investigation it was found that the forward bolts that attach the tail rotor drive shaft to the input side of the thomas coupling at the… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.