# NTSB CHI06LA051: Piper PA-31-350, N711HG, Marshall, MN, December 27, 2005 - Type: NTSB accident investigation - Classification: Accident · Minor injuries · Limited investigation · Final report - Date: December 26, 2005, 20:30 local (Dec 27, 2005, 02:30 UTC) - Place: Marshall, MN - Coordinates: 44.116664, -95.822219 - Nearby events: https://openairdocs.org/map.md?lat=44.1167&lon=-95.8222&mi=10 - Phase of flight: [Approach](https://openairdocs.org/ntsb-phases/500) (OpenAirDocs' grouping) - Highest injury: Minor injuries - Injuries: 1 minor - Status: Completed, report October 3, 2006 - Report: Approved by Office Director - Parties: Federal Aviation Administration - NTSB case key (mKey): 62999 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=CHI06LA051 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/62999/pdf - Page: https://openairdocs.org/ntsb/CHI06LA051 ## Probable cause A loss of engine power in both engines while on approach due to fuel exhaustion and the pilot's inaccurate fuel consumption calculations leading to him refueling the outboard tanks only. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power(total) - nonmechanical, approach - fluid,fuel - exhaustion (cause) - fuel consumption calculations - inaccurate, pilot in command (cause) - Forced landing, emergency descent/landing - In flight collision with terrain/water, emergency landing - terrain condition - ground - terrain condition - snow covered ## Analysis The twin-engine airplane on a non-scheduled domestic passenger repositioning flight, sustained substantial damage on impact with snow covered terrain during a forced landing following an in-flight loss of engine power from both engines on approach. The outboards tanks were the only tanks requested by the pilot to be refuled prior to departure. An on-scene examination revealed that the airplane's tanks exhibited no fuel. No pre-impact anomalies were detected with the airplane. ## Factual narrative HISTORY OF FLIGHT On December 26, 2005, about 2030 central standard time, a twin-engine Piper PA-31-350, N711HG, operated by Midwest Aviation, sustained substantial damage on impact with terrain while approaching the Southwest Minnesota Regional Airport - Marshall/Ryan Field (MML), near Marshall, Minnesota, during a forced landing following an in-flight loss of engine power from both engines. The non-scheduled domestic passenger repositioning flight was operating under 14 Code of Federal Regulations Part 91. Night instrument meteorological conditions prevailed at the time of the accident. The flight was conducted on an activated flight plan. The pilot sustained minor injuries and was hospitalized for observation. The flight originated from the Guymon Municipal Airport, near Guymon, Oklahoma, about 1730. The pilot's accident report, in part, stated: Checked weather in Guymon OK (KGUY) for Marshall MN (KMML) and Sioux Falls SD (KFSD) prior to launching Part 91 reposition flight. Metar for KMML indicated at or above ILS [instrument landing system] minimums at KMML. Services at KGUY were for fuel and no oil. Launched VFR from KGUY, filed airborne and received amended IFR clearance, which included direct to Hill City KS VOR (HLC) then direct KMML. Had tailwind at altitude and 15 [percent] higher ground speed on repositioning leg than on previous leg. Leaned to Peak EGT [exhaust gas temperature]. Approximately 100 nm [nautical miles] S of KMML, noticed both fuel gauges indicated a faster fuel burn than expected at peak EGT. In my previous flights in the aircraft make/model, I had not seen the fuel gauges move that quickly at any given power setting. Checked weather at KFSD and was below minimums for ILS. Checked weather at KMML and was above ILS minimum. Fuel gauges indicated would have enough to continue flight to KMML, shoot ILS and land. 20 nm SW KMML, right fuel boost pump annunciator lighted and the right engine began to sputter. Switched right tank from main to aux tank and restarted engine. However, it did not run smoothly and cycled from high power to almost off. Right and Left fuel gauges indicated approximately 19 gallons remaining in each aux tank and 20 gallons remaining in each main tank. Contacted approach and requested ILS 12 KMML, indicating Bingo fuel and received several vectors outside the LOM [locator outer marker] at KMML. The right engine failed again, cycled the right fuel selector back to the right main tank and kept both right/left boost pumps on. I attempted this cycling once more (right main tank to aux) along with rocking the wings in order to slosh any remaining fuel into the feed system or dislodge an obstruction which may be preventing the engine from getting the fuel remaining in the tank(s). Approximately 30 seconds later, the left fuel boost pump annunciator lighted and left engine failed. Switched left fuel selector to left aux tank and was able to restart the left engine momentarily. I did not feather the engines as they both were cycling from full power to idle and as yet still able to produce some power. Approximately 1 minute later, both engines failed and the aircraft began to lose airspeed and altitude quickly as I was attempting to make it clear to ATC [air traffic control] that the vectors outside the LOM were too far and did not have the time or altitude to begin the approach several miles outside the LOM. I again, switched both tanks from aux to main and attempted restart. Shortly thereafter I heard a radio call; "Good luck Hotel Golf". Noticed airspeed and altitude were low and could not see the airport or anything on ground due to night and overcast conditions. Switched on taxi lights in an attempt to illuminate landing area. Saw what appeared in the windscreen to be a large bush come up out of the pitch black darkness and surmised that ground impact was imminent. Pulled aft elevator in order to use remaining airspeed to establish a nose-high landing pitch attitude. The aircraft struck in a belly-first attitude, rolling forward toward the nose, turning slightly to the left, and then bouncing airborne. I pulled hard aft on elevator in an attempt to prevent the nose from hitting first and the aircraft bounced again on the belly then rolling forward for a second time. Prior to the third impact, I released the control wheel so as not to break my wrists should the aircraft strike the ground in such a manner as to jar the control wheel. The aircraft settled after the third bounce and slid along ground to a stop while yawing to the left. To minimize the potential for fire, I switched off fuel, electrical and magnetos. PERSONNEL INFORMATION The pilot held a commercial pilot certificate with ratings for single and multi-engine land airplane, single engine seaplane, and instrument airplane. The pilot also held a flight instructor certificate with a rating for single engine airplane and instrument airplane. The pilot reported that he had accumulated 1,868 hours of total flight time and 42 hours of flight time in the same make and model as the accident airplane. He reported that he had accumulated 453 hours in night conditions and 152 hours in actual instrument conditions. The pilot's first class medical certificate was issued on July 11, 2005, with a limitation for corrective lenses. The pilot reported that his last flight review was on April 1, 2005. AIRCRAFT INFORMATION N711HG, a 1981-model Piper PA-31-350, Chieftain, serial number 31-8052110, was a low cantilever wing, twin-engine semimonocoque design airplane, with a retractable landing gear. The airplane was powered by two, turbocharged, direct-drive, air-cooled, horizontally-opposed, fuel-injected, six-cylinder engines. The left engine was a Lycoming TIO-540-J2BD engine (serial number RL-11149-51A) and the right engine was a Lycoming LTIO-540-J2BD engine (serial number L-1811-68A), both rated at 350 horsepower. Billing receipts showed that 65.9 gallons was purchased for the airplane at GUY. The pilot's fueling request was that the outboard tanks were to be refueled. The airplane's pilot operating handbook and airplane flight manual, in part, stated: The fuel system consists of fuel cells, engine-driven and emergency fuel pumps, fuel boost pumps, control valves, fuel filters, fuel pressure and fuel flow gauges, fuel drains and non-icing NACA fuel tank vents ... . ... Fuel is stored in four flexible fuel cells, two in each wing panel. The outboard cells hold 40 U.S. gallons each, and the inboard cells hold 56 U.S. gallons each, giving a total of 192 gallons, of which 182 gallons are usable. Fuel is routed from the fuel cells to the selector valve, the fuel filter, the fuel boost pump, the emergency fuel pump, the firewall shutoff, the engine-driven fuel pump, to the injector, then to the cylinders. The fuel selector, filter, fuel boost pump, emergency fuel pump and firewall shutoff are located on the butt-rib of each wing panel. The emergency fuel pumps are installed for emergency use in case of an engine-driven fuel pump failure. They are also used for takeoff and landing and, when necessary, to prime the engines. Control switches for the emergency fuel pumps are located in the overhead switch panel to the right of the fuel gauges. Two electric fuel-quantity gauges are mounted in the overhead switch panel. The right fuel-quantity gauge indicates the quantity of fuel in the selected right fuel system tank (right inboard or right outboard), and the left fuel-quantity gauge indicates the quantity of fuel in the selected left fuel system tank (left inboard or left outboard). The fuel gauges are connected electrically to micro switches ## Aircraft - Registration: [N711HG](https://openairdocs.org/deregistered/N711HG-2008-06-19), registration cancelled 2008-06-19, S/N 31-8052110, built 1980 (OpenAirDocs) - Reported make and model: Piper PA-31-350 - Registry model: [Piper PA-31-350](https://openairdocs.org/model/piper-pa-31-350) (registry code 7103110) (OpenAirDocs) - Registry engine: [Lycoming TI0-540 series](https://openairdocs.org/engine/lycoming-ti0-540-series) (registry code 41533, turbo-prop) (OpenAirDocs) - Category: Airplane - Serial number: 31-8052110 - Airframe hours: 8993 - Engines: Lycoming TIO-540-J2BD 350 horsepower reciprocating; Lycoming LTIO-540-J2BD 350 horsepower reciprocating - Damage: Substantial damage - Flight: Positioning, Part 91 - Operator: Midwest Aviation, doing business as Midwest Aviation Div Of Southwest A - Registered owner: Darair - Airworthiness certificate: Standard, Normal - Last inspection: Annual, October 1, 2005 - Departed: GUY, GUYMON, OK - Destination: MML, Marshall, MN - Flight plan: IFR ## Weather - Conditions: Instrument (IMC), Night - Wind: 260° at 4 knots - Visibility: 3 statute miles - Lowest ceiling: 200 ft overcast - Temperature: 30 °F, dew point 28 °F - Altimeter: 29.68 inHg - Observed at: MML, 5 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20051226032349A](https://openairdocs.org/incident/20051226032349A), Dec 26, 2005: Piper PA31350, Marshall, MN, Destroyed. (-23) Aircraft was on a part 91 repositioning flight when accident occurred. Aircraft departed guymon, OK, bound for Marshall, MN. Approximately 30 miles out… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.