# NTSB ERA14TA326: Cessna 336, N3804U, Mobile, AL, July 3, 2014

- Type: NTSB accident investigation
- Classification: Accident · Serious injuries · Final report
- Date: July 3, 2014, 18:46 local (23:46 UTC)
- Place: Mobile, AL
- Coordinates: 30.664167, -88.03833
- Nearby events: https://openairdocs.org/map.md?lat=30.6642&lon=-88.0383&mi=10
- Phase of flight: [Maneuvering](https://openairdocs.org/ntsb-phases/450) (OpenAirDocs' grouping)
- Defining event: [Maneuvering-low-alt flying: Loss of engine power (partial)](https://openairdocs.org/ntsb-events/342)
- Highest injury: Serious injuries
- Injuries: 1 serious
- Status: Completed, report April 27, 2015
- Report: Approved by Office Director
- NTSB office: Eastern Region Aviation
- Parties: Textron Aviation, FAA/FSDO, Continental Motors
- NTSB case key (mKey): 89604
- NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=ERA14TA326
- NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/89604/pdf
- NTSB docket: https://data.ntsb.gov/Docket?ProjectID=89604
- Page: https://openairdocs.org/ntsb/ERA14TA326

## Probable cause

The pilot’s inadequate preflight fuel planning during which he did not ensure that there was adequate fuel in the main tanks for the flight, which resulted in a loss of engine power.

## Findings

NTSB's coded findings; those marked are part of the probable cause.

- [Fluids: fuel](https://openairdocs.org/ntsb-findings/01071010): Aircraft › Fluids/misc hardware · Fluid management (probable cause); cases with it: [Cessna 336, 1 case](https://openairdocs.org/ntsb-findings/01071010/cases.md?model=2075602), [All aircraft, 1,695 cases](https://openairdocs.org/ntsb-findings/01071010/cases.md)
- [Planning/preparation: fuel planning](https://openairdocs.org/ntsb-findings/02061030): Personnel issues › Task performance · Pilot (probable cause); cases with it: [Cessna 336, 1 case](https://openairdocs.org/ntsb-findings/02061030/cases.md?model=2075602), [All aircraft, 719 cases](https://openairdocs.org/ntsb-findings/02061030/cases.md)
- [Fluids: fuel](https://openairdocs.org/ntsb-findings/01071010): Aircraft › Fluids/misc hardware · Fluid condition; cases with it: [Cessna 336, 1 case](https://openairdocs.org/ntsb-findings/01071010/cases.md?model=2075602), [All aircraft, 1,695 cases](https://openairdocs.org/ntsb-findings/01071010/cases.md)
- [Runway/land/takeoff/taxi surface: soft surface](https://openairdocs.org/ntsb-findings/03023020): Environmental issues › Physical environment · Contributed to outcome; cases with it: [Cessna 336, 1 case](https://openairdocs.org/ntsb-findings/03023020/cases.md?model=2075602), [All aircraft, 264 cases](https://openairdocs.org/ntsb-findings/03023020/cases.md)

## Sequence of events

The events NTSB coded, in order, by phase of flight. The defining event best describes what happened.

- [Maneuvering-low-alt flying: Loss of engine power (partial)](https://openairdocs.org/ntsb-events/342) (defining event); cases with it: [Cessna 336, 1 case](https://openairdocs.org/ntsb-events/342/sequence.md?model=2075602), [All aircraft, 1,858 cases](https://openairdocs.org/ntsb-events/342/sequence.md)
- [Emergency descent: Collision with terr/obj (non-CFIT) ](https://openairdocs.org/ntsb-events/470); cases with it: [Cessna 336, 3 cases](https://openairdocs.org/ntsb-events/470/sequence.md?model=2075602), [All aircraft, 10,189 cases](https://openairdocs.org/ntsb-events/470/sequence.md)

## Analysis

The pilot reported that he was performing mosquito control spraying operations at 100 ft above ground level (agl) when the rear engine began to sputter and lose power. He switched to the auxiliary fuel tank; however, this did not remedy the situation. He then climbed the airplane to 500 ft agl and continued to troubleshoot the problem by again switching fuel tanks and turning the electric boost pumps on. Shortly thereafter, the front engine began to lose power. Unable to regain full power on both engines, the pilot chose to perform a forced landing in an open field. The airplane touched down on soft soil and stopped abruptly, which resulted in extensive damage to the airplane. Both fuel selectors were found in the right main fuel tank positions. An examination of the fuel system revealed that the main fuel tanks contained only residual fuel and that the auxiliary tanks contained an adequate amount of fuel. Examination of the fuel lines revealed that both supply lines from the gascolators to the engine-driven fuel pumps were contaminated and obstructed with a granular, powder-like substance. The engines ran normally when operated in a test cell after the accident. The auxiliary fuel tanks were designed for level, cruise flight only. The auxiliary tanks fed directly to the fuel selector and had no boost pumps available. It is likely that, due to the fuel system's design, adequate fuel pressure could not be regained once the main tanks were depleted and the pilot switched to the auxiliary tanks. The contamination in the fuel lines might have further restricted fuel flow to the engines. The loss of engine power might have been prevented if the pilot had maintained an adequate amount of fuel in the main tanks.

## Factual narrative

On July 3, 2014, about 1846 central daylight time, a Cessna 336, N3804U, force landed following a partial loss of engine power at Mobile, Alabama. The airline transport pilot was seriously injured, and the airplane was substantially damaged. The airplane was operated by the Mobile County Health Department. Day, visual meteorological conditions prevailed for the local, public use, aerial application flight, and no flight plan was filed. The local flight originated at St. Elmo, Alabama (2R5) about 1829.The pilot reported in a written statement to the NTSB that he was assigned to mosquito control spraying operations in the Mobile area. He departed 2R5 with about 48 gallons of fuel, including 36 gallons in the auxiliary tanks. While established on the southbound leg of a spray pattern, he transferred the engines, one at a time, to the full, 18 gallon auxiliary tanks. Shortly after, the engines began to "sputter" and would not maintain rpm. He aborted the spray run, "zoom climbed" to about 600 feet above the ground (agl), and turned to a heading of about 210, in the direction of Mobile Downtown Airport (BFM), about 4 to 5 nautical miles away. The available power was intermittent with rpm surges on both engines, and power available appeared insufficient to reach BFM. He set up for a forced landing on an island between a container terminal and a coal terminal. The airplane touched down on soft soil and came to a stop abruptly, resulting in extensive damage to the airplane. An inspector with the Federal Aviation Administration responded to the accident site and examined the wreckage. Structural damage to the fuselage was confirmed. An examination of the fuel system revealed that the fuel selector handle for the front engine was in the right main tank position. The fuel selector handle for the rear engine was broken off from impact forces. It was later determined that the rear engine fuel selector was also in the right main tank position. The left and right main fuel tanks were empty of fuel and only residual fuel (about 2 ounces) was drained from the left and right main sump tanks. The tanks were not breached. The design of main fuel tanks allows them to completely drain into their respective sump tanks. The left and right auxiliary tanks contained sufficient fuel; however, it was not quantified. The FAA inspector interviewed the pilot on July 9, 2014. He stated in the interview that he had been flying at 100 feet agl when the rear engine began "sputtering and coughing." He switched to the auxiliary fuel tank; however, this did not remedy the situation. He climbed the airplane to 500 feet agl and continued to troubleshoot by switching tanks and turning the boost pumps on. The front engine then began to lose power. He continued to troubleshoot the loss of power and realized that he could not maintain altitude and needed to perform an emergency landing short of the airport. The engines were removed from the airframe and sent to the manufacturer's facilityfor examination. The engines were test run during the week of July 21 through 25, 2014. After repair of impact-related damage, the engines ran normally in a test cell. The test runs did not reveal any abnormalities that would have prevented normal operation and production of rated horsepower. On January 16, 2015, the aircraft fuel system was re-examined under the supervision of the NTSB investigator-in-charge. The both engine fuel selectors were confirmed to be in the right main tank positions. Flaky, rust-colored debris was observed inside the right sump tank. The left sump tank was relatively clean. The left and right wing auxiliary fuel pumps, which operate the left and right main tank fuel sources only, were found to be functional when energized with a dc electrical source. The fuel lines from the fuel selector valves to the main and auxiliary tanks were unobstructed. The rear engine fuel strainer was opened for examination. It contained about 1/8 teaspoon of light gray, powder-like debris in the bowl. The screen was unobstructed. The supply line from the strainer to the engine-driven fuel pump was obstructed; no air could be blown through it by mouth. The obstruction was removed with a clean piece of wire; about one teaspoon of light gray, powder-like debris was removed. The front engine fuel strainer was opened for examination. The bottom of the bowl was corroded with a rust-like substance. The screen was unobstructed. The supply line from the strainer to the engine-driven fuel pump was obstructed; no air could be blown through it by mouth. The obstruction was removed with a clean piece of wire; about one half teaspoon of rust-colored, granular debris was removed. According to the aircraft manufacturer, the auxiliary fuel tanks are intended for level, cruise flight. The auxiliary fuel tanks gravity feed directly to the fuel strainer; no boost pumps are available. The Cessna 336 pilot's operating handbook (POH) states that, in the pre-flight exterior inspection and the before landing checklist, the main tanks are to be selected. Also, the POH states that, in the event of an engine out situation during flight, the main tanks are to be selected if the auxiliary tanks are in use.

## Aircraft

- Registration: [N3804U](https://openairdocs.org/deregistered/N3804U-2018-02-13), registration cancelled 2018-02-13, S/N 336-0104, built 1964 (OpenAirDocs)
- Reported make and model: CESSNA 336
- Registry model: [Cessna 336](https://openairdocs.org/model/cessna-336) (registry code 2075602) (OpenAirDocs)
- Registry engine: [Continental IO-360 series](https://openairdocs.org/engine/continental-io-360-series) (registry code 17025, reciprocating) (OpenAirDocs)
- Category: Airplane
- Serial number: 336-0104
- Year built: 1964
- Airframe hours: 3151
- Engines: CONT MOTOR IO-360 SER 210 horsepower reciprocating; CONT MOTOR IO-360 SER 210 horsepower reciprocating
- Damage: Substantial damage
- Flight: Aerial application, Public use
- Operator: Mobile County Health Department
- Registered owner: Mobile County Health Department
- Airworthiness certificate: Special, Restricted (Special)
- Last inspection: Annual, April 2, 2014
- Departed: 2R5, St. Elmo, AL
- Destination: 2R5, St. Elmo, AL
- Flight plan: Company VFR

## Flight crew

As NTSB recorded them. NTSB leaves out names.

- Pilot; age 67; injuries: serious; flight instructor, airline transport, flight engineer; airplane ratings: single-engine sea, single-engine land, multi-engine land; instrument ratings: airplane; medical: class 2, with waivers/limitations; last flight review June 7, 2013; seat: left; restraint: lap only; flight hours: 19,000 total, 16 in this make and model, 10,000 as pilot in command

## Weather

- Conditions: Visual (VMC), Day
- Wind: 320° at 5 knots
- Visibility: 10 statute miles
- Lowest ceiling: 25,000 ft broken
- Temperature: 82 °F, dew point 72 °F
- Altimeter: 30.04 inHg
- Observed at: MOB, 11 nm away

## FAA reports on this event (1)

The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs).

- [Accident 20140703013629A](https://openairdocs.org/incident/20140703013629A), Jul 3, 2014: Cessna 336, Mobile, AL, Substantial damage. While conducting a mosquito spray mission at an altitude of 100 feet AGL, the rear engine began to run rough and sputter. Pilot switched from the main fuel…

## Docket (24 files)

The files NTSB released with the investigation on March 31, 2015, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=89604. 27.7 MB in all.

- Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1 (item 1, .PDF, 1.4 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424315&FileExtension=.PDF&FileName=Pilot%2FOperator%20Aircraft%20Accident%20Report,%20NTSB%20Form%206120.1-Redacted.PDF
- FAA Inspector Statement (item 2, .PDF, 16 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424316&FileExtension=.PDF&FileName=FAA%20Inspector%20Statement-Redacted.PDF
- Excerpts – Airframe Logbook (item 3, .PDF, 1.1 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424317&FileExtension=.PDF&FileName=Excerpts%20%E2%80%93%20Airframe%20Logbook-Redacted.PDF
- Excerpts – Forward Engine Logbook (item 4, .PDF, 458 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424318&FileExtension=.PDF&FileName=Excerpts%20%E2%80%93%20Forward%20Engine%20Logbook-Redacted.PDF
- Excerpts – Rear Engine Logbook (item 5, .PDF, 357 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424319&FileExtension=.PDF&FileName=Excerpts%20%E2%80%93%20Rear%20Engine%20Logbook-Redacted.PDF
- Documentation of Annual Inspection (item 6, .PDF, 1.5 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424320&FileExtension=.PDF&FileName=Documentation%20of%20Annual%20Inspection-Redacted.PDF
- NTSB Memorandum of Record MOB Weather (item 7, .PDF, 122 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424321&FileExtension=.PDF&FileName=NTSB%20Memorandum%20of%20Record%20MOB%20Weather-Master.PDF
- Continental Motors Front and Rear Engine Run Reports (item 8, .PDF, 3.6 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424322&FileExtension=.PDF&FileName=Continental%20Motors%20Front%20and%20Rear%20Engine%20Run%20Reports-Master.PDF
- Statement of Party Representatives to NTSB Investigation (item 9, .PDF, 496 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424323&FileExtension=.PDF&FileName=Statement%20of%20Party%20Representatives%20to%20NTSB%20Investigation-Redacted.PDF
- Evidence Control (item 10, .PDF, 183 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424324&FileExtension=.PDF&FileName=Evidence%20Control-Redacted.PDF
- Photo 1 – View of Aircraft Wreckage from Left Side (Photo Courtesy of FAA) (item 11, .PDF, 2.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424325&FileExtension=.PDF&FileName=Photo%201%20%E2%80%93%20View%20of%20Aircraft%20Wreckage%20from%20Left%20Side%20%20(Photo%20Courtesy%20of%20FAA)%0D%0A-Master.PDF
- Photo 2 – View of Aircraft Wreckage from Aft (Photo Courtesy of FAA) (item 12, .PDF, 1.8 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424326&FileExtension=.PDF&FileName=Photo%202%20%E2%80%93%20View%20of%20Aircraft%20Wreckage%20from%20Aft%20%20(Photo%20Courtesy%20of%20FAA)%0D%0A-Master.PDF
- Photo 3 – View of Aircraft Wreckage from Right Side (Photo Courtesy of FAA) (item 13, .PDF, 1.5 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424327&FileExtension=.PDF&FileName=Photo%203%20%E2%80%93%20View%20of%20Aircraft%20Wreckage%20from%20Right%20Side%20(Photo%20Courtesy%20of%20FAA)-Master.PDF
- Photo 4 – View of Aircraft Wreckage from Front (Photo Courtesy of FAA) (item 14, .PDF, 2.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424328&FileExtension=.PDF&FileName=Photo%204%20%E2%80%93%20View%20of%20Aircraft%20Wreckage%20from%20Front%20%20(Photo%20Courtesy%20of%20FAA)-Master.PDF
- Photo 5 – View of Forward Fuselage and Front Engine (Photo Courtesy of FAA) (item 15, .PDF, 2.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424329&FileExtension=.PDF&FileName=Photo%205%20%E2%80%93%20View%20of%20Forward%20Fuselage%20and%20Front%20Engine%20(Photo%20Courtesy%20of%20FAA)-Master.PDF
- Photo 6 – View of Aft Fuselage and Rear Engine (Photo Courtesy of FAA) (item 16, .PDF, 1.4 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424330&FileExtension=.PDF&FileName=Photo%206%20%E2%80%93%20View%20of%20Aft%20Fuselage%20and%20Rear%20Engine%20(Photo%20Courtesy%20of%20FAA)-Master.PDF
- Photo 7 – Cockpit Engine Controls (Photo Courtesy of FAA) (item 17, .PDF, 1.7 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424331&FileExtension=.PDF&FileName=Photo%207%20%E2%80%93%20Cockpit%20Engine%20Controls%20(Photo%20Courtesy%20of%20FAA)-Master.PDF
- Photo 8 – Cockpit Fuel Selector Handles (Photo Courtesy of FAA) (item 18, .PDF, 1.7 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424332&FileExtension=.PDF&FileName=Photo%208%20%E2%80%93%20Cockpit%20Fuel%20Selector%20Handles%20(Photo%20Courtesy%20of%20FAA)-Master.PDF
- Photo 9 – Rear Engine Fuel Supply Line Debris (item 19, .PDF, 854 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424333&FileExtension=.PDF&FileName=Photo%209%20%E2%80%93%20Rear%20Engine%20Fuel%20Supply%20Line%20Debris-Master.PDF
- Photo 10 – Rear Engine Fuel Strainer Bowl (item 20, .PDF, 516 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424334&FileExtension=.PDF&FileName=Photo%2010%20%E2%80%93%20Rear%20Engine%20Fuel%20Strainer%20Bowl-Master.PDF
- Photo 11 – Debris Found Inside Rear Engine Fuel Strainer Bowl (item 21, .PDF, 891 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424335&FileExtension=.PDF&FileName=Photo%2011%20%E2%80%93%20Debris%20Found%20Inside%20Rear%20Engine%20Fuel%20Strainer%20Bowl-Master.PDF
- Photo 12 – Debris Inside Right Main Sump Tank (item 22, .PDF, 483 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424336&FileExtension=.PDF&FileName=Photo%2012%20%E2%80%93%20Debris%20Inside%20Right%20Main%20Sump%20Tank-Master.PDF
- Photo 13 – Front Engine Fuel Supply Line Debris (item 23, .PDF, 607 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424337&FileExtension=.PDF&FileName=Photo%2013%20%E2%80%93%20Front%20Engine%20Fuel%20Supply%20Line%20Debris-Master.PDF
- Photo 14 – Front Engine Fuel Strainer Corrosion (item 24, .PDF, 552 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40424338&FileExtension=.PDF&FileName=Photo%2014%20%E2%80%93%20Front%20Engine%20Fuel%20Strainer%20Corrosion-Master.PDF

From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model.

---
OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.