# NTSB FTW00LA081: Piper PA-24-250, N7878P, College Station, TX, February 13, 2000 - Type: NTSB accident investigation - Classification: Accident · Serious injuries · Limited investigation · Final report - Date: February 13, 2000, 16:30 local (22:30 UTC) - Place: College Station, TX - Coordinates: 30.599802, -96.309356 (estimated) - Nearby events: https://openairdocs.org/map.md?lat=30.5998&lon=-96.3094&mi=10 - Phase of flight: [Approach](https://openairdocs.org/ntsb-phases/500) (OpenAirDocs' grouping) - Highest injury: Serious injuries - Injuries: 2 serious - Status: Completed, report March 2, 2001 - Report: Approved by Office Director - NTSB case key (mKey): 48629 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=FTW00LA081 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/48629/pdf - Page: https://openairdocs.org/ntsb/FTW00LA081 ## Probable cause The loss of engine power due to fuel system contamination. A factor was the lack of suitable terrain for the forced landing. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power, approach - vfr pattern - final approach - fluid,fuel - contamination (cause) - In flight collision with terrain/water, emergency descent/landing - terrain condition - none suitable (contributing factor) - object - tree(s) ## Analysis On final approach at the destination airport, the airplane's engine 'stopped.' The pilot switched fuel tanks and turned on the fuel pump. Engine power was not restored. Upon realizing that the approach glidepath would put the airplane into trees, the pilot elected to land in a field short of the trees. Continuity of the fuel system was confirmed. Physical evidence of contamination (ferrous and nonferrous) was found throughout the fuel system (fuel strainer, selector valve, electric fuel pump, left wing fuel cavity, and carburetor) indicating that water had been present at some time and was allowed to remain in the system. During the preflight, it is necessary for the pilot to select each tank with the fuel selector valve then individually drain it, from the cockpit, prior to flight, using the drain valve on the fuel selector. The individual tanks are not equipped with drain sumps. If a fuel tank, that was not drained properly, was selected during flight, water and/or contaminants could be introduced into the engine causing a partial loss of power or engine stoppage. The engine was removed from the airframe, and during an engine run, no apparent anomalies were found. ## Factual narrative On February 13, 2000, at 1630 central standard time, a Piper PA-24-250, single-engine airplane, N7878P, sustained substantial damage when it impacted the terrain short of the runway following a loss of engine power. The private pilot, who owned and operated the airplane under 14 Code of Federal Regulations Part 91, and his passenger received serious injuries. Visual meteorological conditions prevailed for the personal cross-country flight, which departed Conroe, Texas, at 1600. A flight plan was not filed. During personal telephone interviews, conducted by the NTSB investigator-in-charge (IIC), with local authorities, air traffic control personnel, the FAA inspector, and the pilot, the following information was revealed. The airplane cruised en route from Conroe, Texas, to College Station, Texas, at 4,500 feet msl. Approximately 15 miles from the Easterwood Field Airport, near College Station, the pilot was cleared to land the airplane on runway 28. On a 1.4 nautical mile final approach the engine "stopped." The pilot "immediately switched [the] fuel tank [and] checked fuel pump on." There was "no response from the engine." Upon realizing that the current glidepath would put the airplane into trees, the pilot decided to land in a field short of the trees. Once the airplane was on the ground, the pilot secured the cockpit, released his seat belt, exited the airplane through the cockpit door, and awaited assistance from local authorities. A review of the pilot records revealed that the private pilot held airplane single-engine land and instrument ratings. He was issued a third class medical certificate on February 24, 1999. On the Pilot/Operator Aircraft Accident Report (NTSB Form 6120.1/2) the pilot reported a total accumulated flight time of 510.7 hours of which 260.7 hours were in the make and model of the accident aircraft. The FAA inspector responding to the site, which was approximately 1 mile east of the approach end of runway 28, found structural damage to the right wing spar, firewall, and engine mounts. The main landing gear and propeller sustained damage. On April 25, 2000, the airplane was examined at Lancaster, Texas, under the supervision of a FAA inspector. Continuity of the fuel system was confirmed. The FAA inspector reported finding contamination (ferrous and nonferrous) in the fuel system. The fuel selector valve was examined and there was a "line of corrosion present that extended to the top of the bowl, and caused corrosion on the selector valve housing above the fuel strainer. This indicates that at one time a great deal of water had been present in the selector valve." The electric pumps were examined and there was "evidence of corrosion debris in the bowl of these pumps, indicating that there had been water present in the electric pumps." The fuel pump strainer was removed, and "there was a great deal of debris in the strainer, as well as external to the strainer housing." The inspector stated that "the presence of contamination beyond the strainer indicates that the strainer did not contain all the contaminants." There was a "great deal of corrosion [found] in the L/H [left hand] wing, outboard cavity." During an engine run at 2,450 rpm, the fuel pressure dropped to less than 1 PSI. However, the engine ran with "no apparent anomalies." Following the engine run, the carburetor was disassembled. There was debris in the float bowl "consistent with the contamination found throughout the fuel system." The FAA inspector stated "it is obvious from the inspection of the aircraft fuel system that this aircraft has had a water contamination and deterioration of the fuel system." The engine (Textron Lycoming) representative reported that the carburetor float valve was not attached to the float valve clip on the float and lever assembly. Therefore, the "float valve would not be opened by the float when the fuel lever in the carburetor bowl went down. The float valve would then have to be opened by fuel pressure and gravity." The airplane (The New Piper Aircraft) representative reported that "examination of the engine, airframe, and fuel system found no indication of mechanical deficiency. However, significant amounts of material contamination, corrosion and rust were found in the low areas of the fuel system indicating that water had been present at some time and was allowed to remain in the system." He added that "it is necessary for the pilot to select each tank with the fuel selector valve then individually drain it, from the cockpit, prior to flight, using the drain valve on the fuel selector. The individual tanks are not equipped with drain sumps." He further stated that "if a fuel tank, that was not drained properly, were switched on during flight, water and/or contaminants may be introduced into the engine causing a partial loss of power or engine stoppage." ## Aircraft - Registration: [N7878P](https://openairdocs.org/deregistered/N7878P-2009-04-29), registration cancelled 2009-04-29, S/N 24-3104, built 1962 (OpenAirDocs) - Reported make and model: Piper PA-24-250 - Registry model: [Piper PA-24-250](https://openairdocs.org/model/piper-pa-24-250) (registry code 7102404) (OpenAirDocs) - Registry engine: [Lycoming 0-540 series](https://openairdocs.org/engine/lycoming-0-540-series) (registry code 41532, reciprocating) (OpenAirDocs) - Category: Airplane - Serial number: 24-3104 - Airframe hours: 3453 - Engines: Lycoming O-540-A1D5 250 horsepower reciprocating - Damage: Substantial damage - Flight: Personal, Part 91 - Registered owner: Alan A. Moore - Airworthiness certificate: Standard, Normal - Last inspection: Annual, October 18, 1999, 35 hours before - Departed: CXO, CONROE, TX - Destination: CLL - Airport: CLL, College Station, runway 28, 5,159 × 150 ft, asphalt ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 49; private; airplane ratings: single-engine land; instrument ratings: airplane; medical: class 3, valid medical--w/ waivers/lim; seat: left; flight hours: 511 total, 261 in this make and model, 481 as pilot in command, 34 in the last 90 days, 8 in the last 30 days, 3 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Wind: 310° at 8 knots, gusting 17 - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 81 °F, dew point 37 °F - Altimeter: 29.00 inHg - Observed at: CLL ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20000213019179A](https://openairdocs.org/incident/20000213019179A), Feb 13, 2000: Piper PA24250, College Station, TX, Substantial damage. (.4)On final approach at the destination airport, the airplane's engine 'stopped.' The pilot switched fuel tanks and turned on the fuel pump. Engine power was… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.