# NTSB FTW01FA151: Ercoupe 415-CD, N3962H, McAlester, OK, June 24, 2001 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: June 24, 2001, 15:00 local (20:00 UTC) - Place: McAlester, OK - Coordinates: 34.872501, -95.781112 - Nearby events: https://openairdocs.org/map.md?lat=34.8725&lon=-95.7811&mi=10 - Phase of flight: [Unknown](https://openairdocs.org/ntsb-phases/990) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 1 fatal - Status: Completed, report February 20, 2002 - Report: Approved by Office Director - Parties: Federal Aviation Administration, Teledyne Continental Motors - NTSB case key (mKey): 52554 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=FTW01FA151 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/52554/pdf - Page: https://openairdocs.org/ntsb/FTW01FA151 ## Probable cause the inadvertent stall by the pilot-in-command. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of control - in flight, unknown - stall - inadvertent, pilot in command (cause) - In flight collision with terrain/water, descent - uncontrolled - terrain condition - rough/uneven ## Analysis The airplane's fuel tanks were topped off and the flight departed. The following day the airplane was found 1/4 mile from the departure end of the runway by a helicopter that departed on an unrelated business flight. The helicopter crew maneuvered the helicopter near the airplane and observed the accident site among rough and uneven terrain. There were no witnesses to the accident and no distress calls were received. The damage to the airplane and signatures at the accident site, including ground scars, were consistent with a stall. Examination of the airframe did not reveal any anomalies that would preclude normal operation of the airplane. Examination of the engine revealed several anomalies, including ferrous debris in the cylinders and main oil screen; however, there was no evidence of catastrophic engine failure. ## Factual narrative HISTORY OF FLIGHT On June 24, 2001, approximately 1500 central daylight time, an Ercoupe (Eng & Research Corp.) 415-CD airplane, N3962H, was destroyed when it impacted terrain under unknown circumstances near the McAlester Regional Airport (MLC), McAlester, Oklahoma. The airplane was registered to and operated by the pilot. The private pilot, sole occupant of the airplane, sustained fatal injuries. Visual meteorological conditions prevailed and no flight plan was filed for the 14 Code of Federal Regulations Part 91 personal flight. The cross-country flight was originating at the time of the accident and was destined for Ozawkie, Kansas. According to personnel at the Terrell Aviation fixed base operator (FBO), located at the Terrell Municipal Airport, Terrell, Texas, on June 23, 2001, approximately 0700, the pilot was seen at an Ercoupe airplane convention. Approximately 1400, the pilot was driven back to his hotel by a courtesy van driver with the following symptoms: "red faced, flushed, kinda hot." The pilot had stated that he "didn't feel well." Airport personnel reported that some of the hangars that were being used for the convention were air conditioned, and some were not. On June 24, 2001, the pilot had Terrell Aviation FBO personnel top off the airplane's fuel tanks. Subsequently, he departed approximately 1100. According to personnel from BrenAir Aviation Services FBO, located at MLC, approximately 1430, the airplane's fuel tanks were topped off with 7.9 gallons of 100LL fuel. Personnel asked the pilot if he needed oil and the pilot responded that he would be adding "some," but that he had his own oil and did not need to purchase any. There was no further contact with the pilot, there were no witnesses to the accident, and no distress calls were received. On June 25, 2001, at 0930, the airplane, which had not been reported missing, was spotted by a helicopter that departed MLC on an unrelated business flight. The helicopter crew maneuvered the helicopter near the airplane and observed the accident site approximately .25 miles southeast of the airport among trees and rolling terrain. PERSONNEL INFORMATION On August 6, 1993, the pilot was issued a private pilot certificate (single-engine land). On the pilot's last FAA medical certificate application, which was dated April 15, 2000, he reported that he had accumulated a total of 275 flight hours. He held an FAA third class medical certificate dated April 15, 2000, which contained the following stipulation; "holder shall possess correcting glasses for near vision while exercising the privileges of his airman certificate." AIRCRAFT INFORMATION The 1947-model airplane was equipped with a 75-horsepower Teledyne Continental C-75-12 engine and a 2-bladed McCauley fixed pitch propeller. On June 10, 1990, the engine underwent its most recent overhaul. On September 20, 2000, the airframe and engine underwent their most recent inspections. The final maintenance entry in the engine logbook, dated November 20, 2000, stated "replaced rocker box gaskets with new silicon gaskets, replace oil tank & generator gaskets also replace generator drive rubber bushing as per 49-50-00." At the time of the accident, the airframe had accumulated 1,864.2 total hours and the engine had accumulated 132.5 hours since major overhaul. The pilot took possession of the airplane on March 17, 2001. Starting on that date he kept an additional flight/maintenance log on a pad. Multiple entries revealed consistent engine oil consumption of approximately 1 quart per flight hour. The final entry on June 21, 2001, indicated that the engine had "used 1 qt. [of oil] in 2.5 hrs." He added "1qt to bring back to 4.5 qts." The Ercoupe was originally designed with a rudder system that was interconnected to the ailerons. However, the accident airplane was equipped with an independent rudder system that was not interconnected to the aileron system. An emergency locator transmitter (ELT) was not located at the accident site. Additionally, the airplane was not equipped with shoulder harnesses. METEOROLOGICAL INFORMATION At 1453, the weather observation facility at MLC reported the wind from 200 degrees at 9 knots gusting to 14 knots, visibility 10 miles, clear skies, temperature 90 degrees Fahrenheit, dew point 62 degrees Fahrenheit, and an altimeter setting of 30.10 inches of Mercury. The density altitude was calculated to be 2,802 feet. WRECKAGE AND IMPACT INFORMATION Examination of the accident site revealed that the airplane was on a private ranch approximately 0.25 miles southeast of the departure end of runway 19 at MLC. A global positioning system (GPS) recorded the accident location at latitude north 034 degrees 52.349 minutes and longitude west 095 degrees 46.868 minutes. The airplane came to rest on a heading of 210 degrees magnetic. The initial impact scar consisted of a crater and two linear scars that emanated outward from the crater. The linear scars were consistent with the leading edge dimensions of each wing. The leading edges of both wings were compressed rearward. Examination of the trees surrounding the accident site revealed that the only trees with freshly severed limbs were located directly above the airplane. Both wings were partially separated at the wing root. The tailcone, which was buckled, and the tail section remained attached to each other. Flight control continuity was established for the rudder, elevator, elevator trim, and aileron control systems. The elevator trim tab was found in the tab up position. The cockpit was examined. The airspeed indicator needle indicated 100 mph, the tachometer's needle indicated 1,400 rpm, the turn coordinator indicated needle to the right and ball to the left, and the vertical speed indicator indicated a 4,500 feet per minute descent. The throttle was found in the midrange position, the mixture was in the full rich position and the carburetor heat control was in the cold position. The primer was in-and-locked and the fuel selector was in the "on" position. The propeller assembly remained attached to the engine and the engine remained attached to the airframe; however, the engine was displaced rearward through the cockpit instrument panel. One propeller blade was bent rearward 90 degrees at midspan and the second propeller blade was bent rearward 45 degrees at midspan. The propeller's spinner did not display evidence of rotation. The engine was examined at the accident site. The crankshaft could not be rotated. All of the cylinders were undamaged, except for the number 4 cylinder and cylinder head which sustained impact damage. Furthermore, both of the number four valve stems were bent. The carburetor was separated from the engine, the alternator sustained damage and the oil sump was crushed upwards. Both magnetos and the fuel pump remained attached to the engine. The engine was removed from the accident site and examined at the BrenAir Aviation Services FBO at MLC. MEDICAL AND PATHOLOGICAL INFORMATION An autopsy was performed by the Office of the Chief Medical Examiner, Tulsa, Oklahoma. The probable cause of death was "multiple blunt trauma." Toxicological test results, provided by the FAA's Civil Aeromedical Institute of Oklahoma City, Oklahoma, were negative for cyanide and drugs. The following was reported: 51 (mg/dL, mg/hg) Ethanol detected in blood 17 (mg/dL, mg/hg) Ethanol detected in brain 59 (mg/dL, mg/hg) Ethanol detected in kidney 1 (mg/dL, mg/hg) Methanol detected in blood 17 (mg/dL, mg/hg) Acetaldehyde detected in blood 1 (mg/dL, mg/hg) Acetaldehyde detected in brain 10 (mg/dL, mg/hg) Acetaldehyde detected in kidney 6 (mg/dL, mg/hg) N-Propanol detected in blood 5 (mg/dL, mg/hg) N-Propanol detected in brain 4 (mg/dL, mg/hg) N-Propanol detected in kidney The levels of ethanol, methanol, acetaldehyde and n-propanol detected are consis ## Aircraft - Registration: [N3962H](https://openairdocs.org/deregistered/N3962H-2002-01-08), registration cancelled 2002-01-08, S/N 4663, built 1947 (OpenAirDocs) - Reported make and model: Ercoupe (Eng & Research Corp.) 415-CD - Registry model: [Ercoupe 415-CD](https://openairdocs.org/model/ercoupe-415-cd) (registry code 0420324) (OpenAirDocs) - Registry engine: [Continental A&C75 series](https://openairdocs.org/engine/continental-a-c75-series) (registry code 17005, reciprocating) (OpenAirDocs) - Category: Airplane - Serial number: 4663 - Airframe hours: 1864.2 - Engines: Continental C-75-12 75 horsepower reciprocating - Damage: Destroyed - Flight: Personal, Part 91 - Registered owner: Jack E. McCall - Airworthiness certificate: Standard, Normal - Last inspection: Annual, September 20, 2000, 34.9 hours before - Departed: MLC, McAlester, OK - Destination: NONE, Ozawkie, KS - Airport: MLC, McAlester Regional Airport, runway 19, 5,602 × 100 ft, concrete ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 56; injuries: fatal; private; airplane ratings: single-engine land; medical: class 3, valid medical--w/ waivers/lim; seat: left; toxicology performed; flight hours: 275 total ## Weather - Conditions: Visual (VMC), Day - Wind: 200° at 9 knots, gusting 14 - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 90 °F, dew point 63 °F - Altimeter: 30.10 inHg - Observed at: MLC ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20010624016409A](https://openairdocs.org/incident/20010624016409A), Jun 24, 2001: Univar 415CD, Mcalester, OK, Destroyed, 1 fatal. (.19) On June 24, 2001, approximately 1500 central daylight time, a Ercoupe (eng & research corp.) 415-CD airplane, N3962H, was destroyed when it impacted… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.