# NTSB FTW02LA108: Mooney M20F, N9530M, Grapeland, TX, March 30, 2002 - Type: NTSB accident investigation - Classification: Accident · No injuries · Limited investigation · Final report - Date: March 30, 2002, 15:25 local (21:25 UTC) - Place: Grapeland, TX - Coordinates: 32.936389, -97.135276 - Nearby events: https://openairdocs.org/map.md?lat=32.9364&lon=-97.1353&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Highest injury: No injuries - Injuries: 2 uninjured - Status: Completed, report September 30, 2003 - Report: Approved by Office Director - Parties: FAA FSDO, National Transportation Safety Board - NTSB case key (mKey): 54440 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=FTW02LA108 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/54440/pdf - NTSB docket: https://data.ntsb.gov/Docket?ProjectID=54440 - Page: https://openairdocs.org/ntsb/FTW02LA108 ## Probable cause The loss of engine power due to the #2 connecting rod cap separating from the connecting rod. A contributing factor was the limited forward visibility due to oil on the windscreen. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power(total) - mech failure/malf, cruise - engine assembly,connecting rod cap - separation (cause) - Forced landing, emergency descent/landing - Hard landing, landing - flare/touchdown - visual lookout - restricted, pilot in command (contributing factor) - fluid,oil ## Analysis Approximately 25 minutes after departure, while in cruise flight at 1,500 feet msl a sudden vibration shook the airplane. The pilot scanned the engine instruments and everything "appeared to be normal." Subsequently, oil covered the windscreen, which severely limited forward visibility. The pilot initiated a forced landing to a grass field with the landing gear in the retracted position. During the landing, the airplane bounced, and the left wing "skimmed" across the top of a metal cattle feeder before impacting the ground, and the airplane spun around approximately 450 degrees before coming to rest upright. Examination of the engine revealed two holes on the top and bottom of the engine case between the #1 and #2 cylinders. The #2 connecting rod was found sticking out of the top hole and was not attached to the crankshaft. The #2 connecting rod cap was found separated from the connecting rod. The #2 connecting rod cap attachment bolts, nut, and both bearings were missing and not located. The other attachment bolt was found lodged inside the crankcase next to the #3 cylinder opening. The camshaft exhibited impact damage and was fractured in half at the point where the #2 connecting rod was found positioned. Review of the maintenance records revealed the engine had accumulated 997.75 hours since major overhaul at the time of the last annual inspection. Further review indicated that the last entry in the engine logbook was an oil change, with 1097.4 hours since major overhaul. ## Factual narrative On March 30, 2002, at 1525 central standard time, a Mooney M20F single-engine airplane, N9530M, was substantially damaged during a forced landing following a loss of engine power while in cruise flight near Grapeland, Texas. The airplane was registered to and operated by the pilot. The private pilot and his passenger were not injured. Visual meteorological conditions prevailed, and an instrument flight rules flight plan was filed, but not activated for the 14 Code of Federal Regulations Part 91 personal flight. The cross-country flight originated from Livingston, Texas, at 1500, and was destined for Addison, Texas. The pilot reported in the Pilot/Operator Aircraft Accident Report (NTSB Form 6120.1/2) that approximately 25 minutes after departure, the airplane was in cruise flight at 1,500 feet msl when a "sudden heavy" vibration shook the airplane. He then scanned the engine instruments and everything "appeared to be normal." Subsequently, oil covered the windscreen, which severely limited forward visibility. He then initiated a forced landing to a grass field with the landing gear in the retracted position. During the landing, the airplane bounced, and the left wing "skimmed" across the top of a metal cattle feeder before impacting the ground, and the airplane spun around approximately 450 degrees before coming to rest upright. Examination of the airplane by the FAA inspector, who responded to the accident site, revealed that the left wing spar was bent and there were two holes in the engine's #2 cylinder. Further examination of the Lycoming IO-360-A1A engine, serial number L-14690-51A, on July 31, 2002 and August 1, 2002 at Textron Lycoming's facility in Williamsport, Pennsylvania, conducted under the supervision of the NTSB, revealed two holes on the top and bottom of the engine case between the #1 and #2 cylinders. The #2 connecting rod was found sticking out of the top hole and was not attached to the crankshaft. The #2 connecting rod cap was found separated from the connecting rod. The #2 connecting rod cap attachment bolt, nut, and both bearings were missing and not located. The other attachment bolt was found lodged inside the crankcase next to the #3 cylinder opening. The camshaft exhibited impact damage and was fractured in half at the point where the #2 connecting rod was found positioned. Testing of the #2 connecting rod, bolt and nut was preformed on August 1, 2002 at the Lycoming Materials Laboratory. The bolt and nut fragments were checked for conformance to the engineering drawing criteria related to material and fabrication. There were no material nonconformities found with the connecting rod bolt or the nut. The lab concluded that "the connecting rod had been damaged secondarily. " Review of the maintenance records revealed the last major engine overhaul was performed on May 18, 1993. On April 21, 2001, at the time of the last annual inspection, the engine had accumulated 997.75 hours since the last major overhaul. Further review indicated that the last entry in the engine logbook was an oil change performed on July 21, 2002, with 1097.4 hours accumulated since the last major overhaul. ## Aircraft - Registration: [N9530M](https://openairdocs.org/deregistered/N9530M-2013-03-20), registration cancelled 2013-03-20, S/N 670107 (OpenAirDocs) - Reported make and model: Mooney M20F - Registry model: [Mooney M20F](https://openairdocs.org/model/mooney-m20f) (registry code 5870214) (OpenAirDocs) - Registry engine: [Lycoming I0360 SER A&C](https://openairdocs.org/engine/lycoming-i0360-ser-a-c) (registry code 41511, reciprocating) (OpenAirDocs) - Category: Airplane - Serial number: 670107 - Airframe hours: 3756 - Engines: Lycoming IO-360-A1A 200 horsepower reciprocating - Damage: Substantial damage - Flight: Personal, Part 91 - Registered owner: Dale A. Simpson - Airworthiness certificate: Standard, Normal - Last inspection: Annual, April 21, 2001, 108 hours before - Departed: 00R, Livingston, TX - Destination: ADS, Addison, TX - Flight plan: IFR ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 46; injuries: none; private; airplane ratings: single-engine land; instrument ratings: airplane; medical: class 3, valid medical--w/ waivers/lim; last flight review November 3, 2001; seat: left; flight hours: 1,190 total, 992 in this make and model, 1,096 as pilot in command, 14 in the last 90 days, 13 in the last 30 days, 2 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Wind: 180° at 10 knots - Visibility: 10 statute miles - Lowest ceiling: 2,500 ft broken - Temperature: 70 °F ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20020330006029A](https://openairdocs.org/incident/20020330006029A), Mar 30, 2002: Mooney M20F, Palestine, TX, No damage. (.19) On March 30, 2002, at 1524 central standard time, a Mooney M20F single engine airplane, N9530M, was substantially damaged during a forced landing… ## Docket (7 files) The files NTSB released with the investigation on July 7, 2003, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=54440. 2.4 MB in all. - Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1 (item 1, .PDF, 1.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40396030&FileExtension=.PDF&FileName=Pilot%2FOperator%20Aircraft%20Accident%20Report,%20NTSB%20Form%206120.1-Redacted.PDF - Engine Examination Memo (item 2, .PDF, 56 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40396031&FileExtension=.PDF&FileName=Engine%20Examination%20Memo-Redacted.PDF - Lycoming Materials Laboratory Report (item 3, .PDF, 128 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40396032&FileExtension=.PDF&FileName=Lycoming%20Materials%20Laboratory%20Report-Redacted.PDF - Engine Log Books (item 4, .PDF, 324 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40396033&FileExtension=.PDF&FileName=Engine%20Log%20Books-Redacted.PDF - Photo 01: Overall view of the damage to the crankcase. (item 5, .PDF, 251 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40186378&FileExtension=.PDF&FileName=Photo%2001%3A%20Overall%20view%20of%20the%20damage%20to%20the%20crankcase.-Master.PDF - Photo 02: Cylinder #2 rod damage (item 6, .PDF, 216 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40186380&FileExtension=.PDF&FileName=Photo%2002%3A%20Cylinder%20%232%20rod%20damage-Master.PDF - Photo 03: Camshaft fracture (item 7, .PDF, 210 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40186382&FileExtension=.PDF&FileName=Photo%2003%3A%20Camshaft%20fracture-Master.PDF From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.