# NTSB FTW02LA129: Beech F35, N4257B, Amarillo, TX, March 25, 2002 - Type: NTSB accident investigation - Classification: Accident · No injuries · Limited investigation · Final report - Date: March 24, 2002, 19:30 local (Mar 25, 2002, 01:30 UTC) - Place: Amarillo, TX - Coordinates: 35.219165, -101.705833 - Nearby events: https://openairdocs.org/map.md?lat=35.2192&lon=-101.7058&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Highest injury: No injuries - Injuries: 1 uninjured - Status: Completed, report May 13, 2003 - Report: Approved by Office Director - Parties: Raytheon Aircraft Company, Federal Aviation Administration - ADs cited in the narratives: [AD 94-20-04](https://openairdocs.org/ad/94-20-04) (OpenAirDocs) - NTSB case key (mKey): 54581 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=FTW02LA129 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/54581/pdf - NTSB docket: https://data.ntsb.gov/Docket?ProjectID=54581 - Page: https://openairdocs.org/ntsb/FTW02LA129 ## Probable cause Flutter due to the improper balance of the ruddervator, which resulted in structural damage to the aft fuselage. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Airframe/component/system failure/malfunction, cruise - empennage - flutter (cause) - flight control,ruddervator - out of balance (cause) - fuselage,skin - buckled ## Analysis The pilot reported that while in level cruise flight at 140 knots indicated airspeed, at an altitude of 5,500 feet mean sea level (msl), the airplane encountered "clear air turbulence." The pilot stated that at the time of the accident, the airplane autopilot system was engaged, and his hands were not on the cockpit controls. During the accident, the airplane "was suddenly thrust nose high and vertical." The pilot then "pushed the nose [of the airplane] over," and recovered control of the airplane from the unusual attitude. The pilot continued the flight to his intended destination and landed without incident. Examination of the airplane revealed that the aft fuselage exhibited extensive skin wrinkling and tearing between the fuselage station (FS) 233.5 and FS 256.9 bulkheads. The left fuselage side exhibited a compression wrinkle extending from the bottom of the FS 256.9 bulkhead diagonally up and forward toward the top of the FS 233.5 bulkhead. The right fuselage side exhibited a compression wrinkle extending from the top of the FS 256.9 bulkhead diagonally down and forward toward the bottom of the FS 233.5 bulkhead. The bottom skin exhibited a compression wrinkle that extended from the middle of the FS 256.9 bulkhead forward and outward toward FS 233.5 bulkhead. The right ruddervator was 20.98 inch-pounds static underbalanced. According to the manufacturer, the static underbalance weight range is 16.8 to 19.8 inch pounds. ## Factual narrative HISTORY OF FLIGHT On March 24, 2002, approximately 1930 central standard time, a Beech F35 single-engine airplane, N4257B, was substantially damaged following a structural failure of the airframe during cruise flight near Amarillo, Texas. The instrument-rated private pilot, who was the sole occupant of the airplane, was not injured. The airplane was registered to the Ron McMurray Family Limited Partnership and operated by the pilot. Visual meteorological conditions prevailed, and a flight plan was not filed for the Title 14 Code of Federal Regulations Part 91 personal flight. The flight departed Clovis, New Mexico, approximately 1830, and was destined for Borger, Texas. The 2,500-hour pilot reported that while in level cruise flight at 140 knots indicated airspeed, at an altitude of 5,500 feet mean sea level (msl), the airplane encountered "clear air turbulence" approximately 20 nautical miles south-southwest of Amarillo. The pilot stated that at the time of the accident, the airplane autopilot system was engaged, and his hands were not on the cockpit controls. During the accident, the airplane "was suddenly thrust nose high and vertical." The pilot then "pushed the nose [of the airplane] over," and recovered control of the airplane from the unusual attitude. The pilot continued the flight to his intended destination; however, the autopilot system would not reengage, and the trim setting had to be readjusted to maintain level flight. The airplane landed uneventfully on runway 35 at the Borger Hutchinson County Airport (BGD). While tying down the airplane on the ramp in Borger, the pilot noticed damage to the empennage section. The pilot reported that at the time of the accident, the visibility was clear with no clouds and a weather front may have been developing near Amarillo. The NTSB was notified of the damage to the airplane on April 23, 2002, approximately one month after the accident. PERSONNEL INFORMATION The pilot held a private pilot certificate with an instrument rating. The pilot was issued a third class medical certificate on April 26, 2001, with the restriction, "Must have available glasses for near vision." The pilot had accumulated approximately 500 flight hours in the accident airplane. His most recent biennial flight review (BFR) was completed on January 2, 2002, in the accident airplane. AIRCRAFT INFORMATION The 1955 Beech F35 Bonanza, serial number D-4234, is a four place, low-wing, V-tail airplane with retractable landing gear. A review of the airplane's logbooks disclosed that an annual inspection was completed on July 8, 2001. At the time of the accident, the airplane had accumulated 418.7 total hours since the annual inspection and the airframe had accumulated 5,515.3 total hours. The airplane was equipped with a 225-horsepower Continental E-225-8 engine, serial number 36017-D-4-8-R, which was installed on May 25, 2000, and was equipped with a Beechcraft 215-208 propeller, serial number 3204. A review of the engine logbooks disclosed an annual inspection was completed on July 8, 2001. The total time on the engine at the time of the accident was unknown. According to the propeller logbook, the propeller was repaired and reinstalled on February 15, 2002, with no anomalies noted during the ground functional test. A review of the airplane's logbooks disclosed that on October 12, 1988, at a total time of 3,294 hours, the aircraft's empennage had a stabilizer leading edge cuff modification kit, Beech part number 35-4016-3, serial number 1590, installed in accordance with Beech drawing No. 35-4016. On June 29, 1995, Airworthiness Directive (AD) 94-20-04 (effective November 28, 1994), was completed. The AD required a one-time compliance within the next 100 hours time-in-service. On October 16, 1997, both ruddervators were removed, repainted, and reinstalled after a repair was completed. METEOROLOGICAL INFORMATION At 1853, the reported weather conditions at the Amarillo International Airport (AMA), Amarillo, located approximately 20 miles northeast of the occurrence site, were wind from 030 degrees at 22 knots, gusting to 27 knots, visibility 10 statute miles, sky clear, temperature 45 degrees Fahrenheit, dew point 28 degrees Fahrenheit, and an altimeter setting of 29.77 inches of Mercury. At 1911, the reported weather conditions at BGD, located approximately 50 miles northeast of the accident site, were wind from 010 degrees at 16 knots, visibility 10 statute miles, ceiling broken at 1,800 msl, temperature 37 degrees Fahrenheit, dew point 28 degrees Fahrenheit, and an altimeter setting of 29.86 inches of Mercury. At 1953, AMA reported wind from 020 degrees at 20 knots, gusting to 24 knots, visibility 10 statute miles, sky clear, temperature 36 degrees Fahrenheit, dew point 27 degrees Fahrenheit, and an altimeter setting of 29.82 inches of Mercury. A review of the AIRMETs and SIGMETs for the area revealed that AIRMET Tango was issued for the accident area and valid from 1445 until 2045. AIRMET Tango reported occasional moderate turbulence below 10,000 feet msl. No significant PIREPs were noted. WRECKAGE AND IMPACT INFORMATION On April 30, 2002, the airplane damage was examined in a hangar at the Borger Hutchinson County Airport by a Federal Aviation Administration (FAA) aviation safety inspector, FAA Wichita Aircraft Certification Office (ACO) representatives, and a representative from Raytheon Aircraft Company (RAC). The examination revealed that the aft fuselage damage was concentrated between the fuselage station (FS) 233.5 and 256.9 bulkheads. The aft fuselage exhibited extensive skin wrinkling and tearing between the FS 233.5 bulkhead and the FS 256.9 (front spar attachment). The rest of the aft fuselage exhibited no apparent deformation or cracks. The following damage to the fuselage was noted: 1. The left side of the fuselage exhibited a compression wrinkle extending from the bottom of the FS 256.9 bulkhead diagonally up and forward toward the top of the FS 233.5 bulkhead. The left side inspection panel was wrinkled and remained attached to the airplane. 2. There was fuselage skin wrinkling under the left stabilizer cuff. 3. The right side of the fuselage exhibited a compression wrinkle extending from the top of the FS 256.9 bulkhead diagonally down and forward toward the bottom of the FS 233.5 bulkhead. In addition, a compression wrinkle ran from the bottom of the FS 256.9 bulkhead diagonally up and forward until it met the other compression wrinkle that extended down and forward. 4. The aft end of the bottom fuselage skin was separated from the bottom of the FS 256.9 bulkhead. 5. The two L-stringers that extend along the bottom fuselage skin and attach to the bottom of the FS 256.9 bulkhead were separated from the bottom skin an average of 7 rivets each. 6. The bottom skin exhibited a compression wrinkle that extended from the middle of the FS 256.9 bulkhead forward and outward toward FS 233.5 bulkhead. 7. The left side of the bottom fuselage skin remained attached to the left fuselage side. 8. The right side of the bottom fuselage skin separated from the right fuselage side for 8 rivets forward of the FS 256.9 bulkhead. 9. No damage was observed to the FS 272, 256.9, or 233.5 bulkheads. 10. No damage was observed to the top of the fuselage. The following damage to the empennage was noted: 1. Both stabilizers were securely attached to the FS 256.9 bulkhead. Both ruddervators were securely attached to the stabilizers, and no damage was observed to either the left or right empennage assemblies. 2. Both ruddervators were checked for balance using the force method per the Bonanza 35 Series Shop Manual. The required static underbalance weight range is 16.8 to 19.8 inch-pounds (in-lbs.). The left and right ruddervators exhibited 19.0575 in-lbs. and 20.98 in-lbs. static underbalanc ## Aircraft - Registration: [N4257B](https://openairdocs.org/aircraft/N4257B), registered now, S/N D-4234, built 1955 (OpenAirDocs) - Reported make and model: Beech F35 - Registry model: [Beech F35](https://openairdocs.org/model/beech-f35) (registry code 1151514) (OpenAirDocs) - Registry engine: [Continental E225 series](https://openairdocs.org/engine/continental-e225-series) (registry code 17015, reciprocating) (OpenAirDocs) - Category: Airplane - Serial number: D-4234 - Airframe hours: 5515.3 - Engines: Continental E-225 225 horsepower reciprocating - Damage: Substantial damage - Flight: Personal, Part 91 - Operator: Ronnie A. McMurray - Registered owner: Ron McMurray Family Limited Partnership - Airworthiness certificate: Standard, Normal - Last inspection: Annual, June 24, 2001, 418.7 hours before - Departed: CVN, Clovis, NM - Destination: BGD, Borger, TX ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 54; injuries: none; private; airplane ratings: single-engine land; instrument ratings: airplane; medical: class 3, valid medical--w/ waivers/lim; last flight review January 2, 2002; seat: left; flight hours: 2,500 total, 500 in this make and model, 2,400 as pilot in command, 75 in the last 90 days, 75 in the last 30 days ## Weather - Conditions: Visual (VMC), Dusk - Wind: 30° at 22 knots, gusting 27 - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 45 °F, dew point 28 °F - Altimeter: 29.77 inHg - Observed at: AMA, 20 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20020324006269A](https://openairdocs.org/incident/20020324006269A), Mar 24, 2002: Beech F35, Great Bend, KS, No damage. (-23) On March 24, 2002, approximately 1930 CST, a Beech F35 single-engine airplane, N4257B, was substantially damaged during an encounter with turbulence… ## Docket (11 files) The files NTSB released with the investigation on March 20, 2003, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=54581. 7.2 MB in all. - Pilot/Operator Aircraft Accident Report, NTSB Form 6120.1 (item 1, .PDF, 607 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398225&FileExtension=.PDF&FileName=Pilot%2FOperator%20Aircraft%20Accident%20Report,%20NTSB%20Form%206120.1-Redacted.PDF - NTSB Meteorological Information (item 2, .PDF, 517 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40178021&FileExtension=.PDF&FileName=NTSB%20Meteorological%20Information-Master.PDF - Raytheon Report (item 3, .PDF, 1.4 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398226&FileExtension=.PDF&FileName=Raytheon%20Report-Redacted.PDF - Excerpts of Raytheon IPC (item 4, .PDF, 680 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40178023&FileExtension=.PDF&FileName=Excerpts%20of%20Raytheon%20IPC-Master.PDF - FAA Airworthiness Directive 94-20-04 R1 (item 5, .PDF, 460 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40178024&FileExtension=.PDF&FileName=FAA%20Airworthiness%20Directive%2094-20-04%20R1-Master.PDF - Aircraft Logbook (Book 1) (item 6, .PDF, 357 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398227&FileExtension=.PDF&FileName=Aircraft%20Logbook%20(Book%201)-Redacted.PDF - Aircraft Logbook (Book 2) (item 7, .PDF, 2.6 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398228&FileExtension=.PDF&FileName=Aircraft%20Logbook%20(Book%202)-Redacted.PDF - Engine Logbook (item 8, .PDF, 129 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398230&FileExtension=.PDF&FileName=Engine%20Logbook-Redacted.PDF - Propeller Logbook (item 9, .PDF, 185 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398231&FileExtension=.PDF&FileName=Propeller%20Logbook-Redacted.PDF - Statement of Party Representatives to NTSB Investigation (item 10, .PDF, 80 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398232&FileExtension=.PDF&FileName=Statement%20of%20Party%20Representatives%20to%20NTSB%20Investigation-Redacted.PDF - Release of Aircraft Wreckage, NTSB Form 6120.15 (item 11, .PDF, 126 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40398233&FileExtension=.PDF&FileName=Release%20of%20Aircraft%20Wreckage,%20NTSB%20Form%206120.15-Redacted.PDF From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.