# NTSB IAD01LA022: Learjet 35, N435JL, Schenectady, NY, January 4, 2001 - Type: NTSB accident investigation - Classification: Accident · No injuries · Limited investigation · Final report - Date: January 4, 2001, 15:47 local (20:47 UTC) - Place: Schenectady, NY - Coordinates: 42.852222, -73.928611 - Nearby events: https://openairdocs.org/map.md?lat=42.8522&lon=-73.9286&mi=10 - Phase of flight: [Takeoff](https://openairdocs.org/ntsb-phases/300) (OpenAirDocs' grouping) - Highest injury: No injuries - Injuries: 3 uninjured - Status: Completed, report September 10, 2002 - Report: Approved by Office Director - Parties: FAA/Albany FSDO, Learjet - NTSB case key (mKey): 50901 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=IAD01LA022 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/50901/pdf - Page: https://openairdocs.org/ntsb/IAD01LA022 ## Probable cause The pilot's improper trim setting, which resulted in a runway overrun and impact with a fence. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Overrun, takeoff - aborted - trim setting - improper, pilot in command (cause) - abort above v1 - performed, pilot in command - On ground/water collision with object, takeoff - aborted - object - fence ## Analysis The captain stated that prior to departure the flight controls were tested, with no abnormalities noted, and the takeoff trim was set to the "middle of the takeoff range," without referring to any available pitch trim charts. During the takeoff roll, the pilot attempted to rotate the airplane twice, and then aborted the takeoff halfway down the 4,840 foot long runway, because the controls "didn't feel right." The airplane traveled off the departure end of the runway and through a fence, and came to rest near a road. The pilot reported no particular malfunction with the airplane. Examination of the airplane revealed that the horizontal stabilizer was positioned at -4.6 degrees, the maximum nose down limit within the takeoff range. The horizontal stabilizer trim and elevator controls were checked, and moved freely through their full ranges of travel. According to the AFM TAKEOFF TRIM C.G. FUNCTION chart, a horizontal stabilizer trim setting of -7.2 was appropriate with the calculated C.G. of 20% MAC. Additionally, Learjet certification testing data stated that the pull force required at a trim setting of -6.0 degrees, the "middle of the takeoff range", was 33 pounds. With the trim set at the full nose down position (-1.7 degrees), 132 pounds of force was required. ## Factual narrative HISTORY OF FLIGHT On January 4, 2001, at 1547 eastern standard time, a Learjet 35, N435JL, was substantially damaged during an aborted takeoff at the Schenectady County Airport (SCH), Schenectady, New York. The certificated airline transport pilot, commercial pilot, and passenger were not injured. Visual meteorological conditions prevailed, and an IFR flight plan was filed for the air response medical flight conducted under 14 CFR Part 91. In a statement, the captain wrote: "After completing all required checklist items and a takeoff briefing, we proceeded onto the active runway. A standing start was performed. After takeoff power was set, the brakes were released and a routine takeoff roll followed. As the Learjet 35 accelerated down the runway all speed callouts were made. At the V1 call my hand was removed from the thrust levers and placed on the control yolk. When the ROTATE call was made, I verified the airspeed and began to ease back on the control yolk. The nose of the airplane did not rise. I released the back pressure and pulled again. There was no response. The decision to abort the take off was made. The aborted takeoff procedure commenced and max braking was used to try to stop the aircraft on the remaining runway. The aircraft rolled off the end of the runway and dropped off a small embankment. The aircraft continued to slide into a chain link fence where it came to rest near a road. The crew then shut down the engines and batteries and evacuated the aircraft. Emergency vehicles arrived within minutes." In a telephone interview, the captain reported the flight was destined for LaGuardia Airport (LGA), New York, to pick up a medical patient. He stated that "everything seemed normal" during taxi, and when the flight controls were tested, no abnormalities were noted. The captain stated that he attempted to rotate the airplane at 125 knots; however, it did not respond to the control inputs. The captain released the back pressure, and attempted to rotate again with no success. When the airplane was about half-way down the runway, the captain decided to abort the takeoff, and he applied maximum braking. The airplane departed the end of the runway, impacted a snow bank, and went through a fence before coming to rest near a road. The captain estimated that the airplane reached a maximum speed of 140 knots before the takeoff was aborted. He reported that the flaps and pitch trim were both set to their respective "takeoff positions," prior to departure. Additionally, the captain stated that during the attempted rotation, he was able to move the control yoke to its full aft position; however, the yoke did not have its "normal resistance." The captain did not report any particular mechanical malfunction of the airplane. In subsequent interviews, the captain stated that the flight crew did not perform any weight and balance calculations for the airplane. He reported that they knew the airplane was loaded within CG and weight limits "just by looking at it," without any reference to specific charts. Additionally, the flight crew did not compute any takeoff or landing distances. When asked where the pitch trim was selected to prior to takeoff, the captain stated, "in the middle of the takeoff range." He reported that the available pitch trim chart was not referred to. The captain then refused to answer any further questions. In a statement, the first officer wrote: "After starting engines, we contacted ground and were assigned RW 28. After double-checking the performance figures, RW 28 was found to be more than adequate. During the taxi, we executed the appropriate checklists and found all items to check out good. We were asked to hold short of RW 28 and performed a standing start. The brakes are held and the aircraft does not move until takeoff power is set. After brake release, the aircraft quickly accelerated down the runway. All standard call outs were made. At rotation speed, I called out, 'Rotate.' The captain pulled the control yoke back and the nose would not lift. He released pressure momentarily and then pulled back again even farther, as far as it would go. The nose still would not lift off the ground. He then quickly retarded both throttles, extended the spoilers, and applied maximum braking. We rolled off the end of the runway at approximately 20 knots and slid down the hill through the fence. After the aircraft came to rest, the flight nurse quickly opened the door and we exited the aircraft and assembled at a safe distance away from the aircraft." In a telephone interview with the first officer, he stated that he was the non-flying pilot during the accident, and did not touch the flight controls. He reported that during the takeoff roll, he heard the captain say that the takeoff "didn't feel right." The captain then aborted the takeoff about half-way down the runway, and the airplane continued off the departure end. AIR TRAFFIC CONTROL In a written statement, an air traffic ground controller on duty at the time of the accident stated that the crew was given instructions to taxi to runway 28. According to the controller, the crew appeared to be unfamiliar with the airport when they missed a left turn in the normal taxi route. The crew was then given progressive taxi instructions to runway 28. The tower controller observed the airplane during its takeoff roll. He stated that the airplane did not appear to rotate, and slowed slightly before going off the departure end of runway 28. FLIGHT CREW INFORMATION The captain held an airline transport pilot certificate with a rating for airplane multi-engine land, and commercial privileges for airplane single engine land. He also held a flight instructor certificate, with ratings for airplane single engine land and instrument airplane. Additionally, the captain received his Learjet type rating on November 9, 1999. The captain reported his total flight experience as 2,570 hours, 1,065 of which were in the Learjet 35. He also reported that he accumulated about 110 hours in the Learjet 35 in the last 90 days. The captain's most recent Federal Aviation Administration (FAA) first class medical certificate was issued on September 29, 2000, with no restrictions. The captain was hired by the company in August of 1998, as a first officer. He completed upgrade training in October 1999 at Flight Safety International. His most recent competency check was performed on May 23, 2000, during which he received a "satisfactory" for all maneuvers and procedures demonstrated. The first officer held a commercial pilot certificate with ratings for airplane single and multiengine land and instrument airplane. He also held a flight instructor certificate, with ratings for airplane single engine land, multiengine land, and instrument airplane. The first officer's most recent FAA first class medical certificate was issued on February 2, 2000, with a limitation to wear corrective lenses. The first officer reported 1,600 hours of total flight experience, and 497 hours in make and model. WRECKAGE AND IMPACT INFORMATION The airplane was examined at the accident site under the supervision of an FAA inspector. It was noted that both wings sustained substantial damage, and that the landing gear nose wheel was torn off the airplane. Examination of the wing flaps and flap indicator revealed the flaps were selected to 8 degrees. The spoilers were extended and no snow or ice contamination was observed on the airplane. Additionally, tire marks indicating "substantial braking" were observed on the runway, beginning 1,000 feet from the departure end of the 4,840-foot-long runway. A measurement of the horizontal stabilizer position indicated -4.6 degrees, which was the maximum nose down limit within the takeoff range. The horizontal stabilizer trim was checked and moved freely through ## Aircraft - Registration: [N435JL](https://openairdocs.org/deregistered/N435JL-2009-04-29), registration cancelled 2009-04-29, S/N 35-018 (OpenAirDocs) - Reported make and model: Learjet 35 - Registry model: [Learjet 35](https://openairdocs.org/model/learjet-35) (registry code 5170803) (OpenAirDocs) - Category: Airplane - Serial number: 35-018 - Airframe hours: 16302 - Engines: Garrett TFE 731 3500 lbs thrust turbo fan - Damage: Substantial damage - Flight: Positioning, Part 91 - Registered owner: Air Response North Inc. - Airworthiness certificate: Standard, Normal - Last inspection: AAIP, December 11, 2000, 11 hours before - Departed: SCH, Schenectady, NY - Destination: LGA, New York, NY - Flight plan: IFR - Airport: SCH, Schenectady County Airport, runway 28, 4,840 × 150 ft, asphalt ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 26; injuries: none; flight instructor, airline transport; airplane ratings: multi-engine land, single-engine land; instrument ratings: airplane; medical: class 1, valid medical--no waivers/lim.; last flight review November 29, 2000; seat: left; flight hours: 2,570 total, 1,065 in this make and model, 1,662 as pilot in command, 117 in the last 90 days, 36 in the last 30 days - Co-pilot; age 27; injuries: none; flight instructor, commercial; airplane ratings: multi-engine land, single-engine land; instrument ratings: airplane; medical: class 1, valid medical--w/ waivers/lim; last flight review December 9, 2000; seat: right; flight hours: 1,600 total, 497 in this make and model, 900 as pilot in command, 32 in the last 90 days, 0 in the last 30 days, 0 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Wind: 270° at 7 knots - Visibility: 10 statute miles - Lowest ceiling: 3,400 ft broken - Temperature: 28 °F, dew point 23 °F - Altimeter: 29.87 inHg - Observed at: ALB, 8 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20010104001139A](https://openairdocs.org/incident/20010104001139A), Jan 4, 2001: Lear 35LEAR, Scotia, NY, No damage. (-23) During the attempted takeoff, the a/c did not respond to flight control inputs to rotate attitude. At this point the a/c was significantly past the… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.