# NTSB IAD03FA058: Piper PA-30, N8162Y, NewPhiladelphia, OH, June 16, 2003 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: June 16, 2003, 15:42 local (19:42 UTC) - Place: NewPhiladelphia, OH - Coordinates: 40.480823, -81.440368 (estimated) - Nearby events: https://openairdocs.org/map.md?lat=40.4808&lon=-81.4404&mi=10 - Phase of flight: [Maneuvering](https://openairdocs.org/ntsb-phases/450) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 2 fatal - Status: Completed, report September 1, 2004 - Report: Approved by Office Director - Parties: Textron Lycoming, FAA/FSDO - NTSB case key (mKey): 57237 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=IAD03FA058 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/57237/pdf - Page: https://openairdocs.org/ntsb/IAD03FA058 ## Probable cause The pilot's mismanagement of the fuel, and his failure to maintain minimum controllable airspeed with one engine inoperative. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power(total) - nonmechanical, maneuvering - fuel management - improper, pilot in command (cause) - fluid,fuel - exhaustion (cause) - 1 engine - Loss of control - in flight, maneuvering - airspeed(vmc) - not maintained, pilot in command (cause) - In flight collision with terrain/water, descent - uncontrolled - terrain condition - ground ## Analysis While on a long cross country flight, the left engine shut down in-flight and had to be restarted. The pilot then landed and refueled the airplane. While the airplane was being refueled, he asked the lineman if the left outboard tank was empty, and the fueler confirmed that it was. The pilot also stated that he thought that he had run the tank dry, and that the engine was burning more fuel than anticipated. He purchased 55 gallons of fuel and departed. About 2 hours later, while maneuvering near New Philadelphia, Ohio, a review of the last 4 minutes of recorded GPS data revealed the airplane had decelerated from 110 miles per hour (mph) to 84.9 mph, and descended from 1,699 feet to 923 feet, before the data ended. Witnesses heard the airplane having engine trouble, and observed the airplane make a left turn, then roll upside down, before it hit the ground. Examination of each of the four fuel-bladder tanks revealed that the left outboard tank was intact and empty, and the left inboard tank was empty, but breached at the engine nacelle. The right inboard tank was intact and about 1/4-full of fuel. The right outboard tank was intact, and a small amount of fuel was in the tank, but fuel was observed draining from the tank at the accident site. The fuel selector handles were set to the outboard tanks. According to the Piper Comanche Owner's Manual, "Vmc is the calibrated airspeed, determined by FAA test pilots, below which a twin engine aircraft cannot be controlled in flight with one engine operating at take-off power and the other engine wind milling." The Vmc, which the FAA had determined for this airplane, was 90 mph. ## Factual narrative HISTORY OF FLIGHT On June 16, 2003, at 1542 eastern daylight time, a Piper PA-30, N8162Y, was substantially damaged when it collided with terrain near New Philadelphia, Ohio. The certificated private pilot, and the passenger were fatally injured. No flight plan was filed for the flight that originated at Crawfordsville Airport (CFJ), Crawfordsville, Indiana, about 1332, destined for Butler County/K.W. Scholter Field (BTP), Butler, Pennsylvania. Visual meteorological conditions prevailed for the personal flight conducted under 14 CFR Part 91. The pilot departed Lee's Summit Municipal Airport (LXT), Lee's Summit, Missouri, at 1116, on a visual flight rules (VFR) flight plan, destined for New Castle-Henry County Municipal Airport (UWL), New Castle, Indiana. Instead, he landed at Crawfordsville Airport, at 1301, without closing his flight plan, and purchased 55.36 gallons of 100 LL fuel for the airplane. According to a fueler at Crawfordsville Airport, he first filled the left outboard tank, and noticed that it looked dry. He then proceeded to fill the left inboard tank, when the pilot approached him, and asked if the left outboard tank had looked empty to him. The fueler replied that it had looked empty. The pilot told the fueler that he thought he had run the left outboard tank dry while en route, because the left engine had shut down in flight and had to be restarted. The pilot also mentioned that he thought the left engine must have been burning more fuel than he had anticipated. The pilot paid for the fuel and departed. Several witnesses observed and heard the airplane. A witness, a retired Trooper from the Ohio State Highway Patrol, was standing in an auto salvage yard, when she heard the sound of an airplane having engine trouble. She looked up and saw the airplane flying slow and low (about 1,500 above ground level), headed south-southeast toward Harry Clever Field (NPH), New Philadelphia, Ohio. She only heard the sound of one engine, and it was "sputtering" as if it were struggling for fuel. The witness saw no signs of debris or smoke trailing the airplane. A second witness, who was in his shop at Harry Clever Field, said that the airplane passed just south of the airport in a west-northwest direction, at about 100 feet. The airplane was level with the landing gear up, and the engines were "sputtering." The airplane held its altitude until it crossed a tree line, then started a shallow left turn, and descended out of sight. A third witness, who was refueling a loader at a sand and gravel quarry, heard an airplane that "didn't sound right." He looked up and saw the airplane coming from the east, then turn south. The witness said it looked like the airplane was trying to "turn and overturned and came straight down inverted." A fourth witness, who was talking to the witness refueling the loader, saw the airplane turn left, then upside down, and hit the ground. He said it didn't sound like the airplane was having engine trouble. A hand-held Garmin 295 Global Positioning System (GPS) receiver was located near the main wreckage. Information downloaded from the receiver revealed that the entire flight was recorded, in addition to a stored route from Lee's Summit, Missouri, to Butler, Pennsylvania. When the airplane's flight track data was downloaded and compared to the stored route of flight, it paralleled a majority of the stored route of flight. A review of the recorded data revealed that when the airplane was east of the Port Columbus Airport (CMH), Columbus, Ohio, it turned northeast, off of the stored route of flight. After flying northeast for several minutes, the airplane made a right turn and flew on a southeasterly heading for several more minutes, before it made a left, approximately 360-degree turn, and headed northwest towards Harry Clever Field. Examination of the last 4 minutes of recorded data revealed that the airplane decelerated from 110 miles per hour (mph) to 84.9 mph, changed heading from 199 degrees to 215 degrees, and descended from 1,699 feet to 923 feet, before the data ended at 1542. The last position recorded by the GPS was 40 degrees, 27 minutes north latitude, and 81 degrees, 26 minutes west longitude. The accident occurred during the hours of daylight approximately 40 degrees, 28 minutes north latitude, and 81 degrees, 26 minutes west longitude. PERSONNEL INFORMATION The pilot held a private pilot certificate with ratings for airplane single engine land, multiengine land, and instrument airplane. His most recent Federal Aviation Administration (FAA) third class medical was issued on July 16, 2002. Examination of the pilot's logbook revealed that he had accrued a total of 956.7 flight hours, of which, 159.3 hours were in make and model. On June 13, 2003, the pilot flew for one hour with a certified flight instructor, who was also a Federal Aviation Administration (FAA) Designated Pilot Examiner, and practiced left engine restart procedures, single-engine stalls, Vmc (velocity minimum control) demonstrations, aborted take-offs, go around procedures, and single-engine landings. According to the instructor, the pilot's flying skills were "excellent," but he was "vague" on fuel cross-feeding procedures. METEORLOGICAL INFORMATION Weather reported at the airport, at 1553, included winds from 120 degrees at 7 knots, temperature 75 degrees F, dew point 64 degrees F, and barometric pressure setting of 30.13 inches Hg. The visibility was 9 statute miles and clear. WRECKAGE AND IMPACT INFORMATION The airplane was examined at the site on June 17-18, 2003. All major components were accounted for at the scene. The airplane came to rest inverted on the shoreline of a lake located inside a sand and gravel quarry. It was on a heading of 168 degrees magnetic, at a ground elevation of approximately 900 feet, about 1 nautical southwest of Harry Clever Field. The initial impact point was a large hill of piled dirt located directly behind where the airplane came to rest. Examination of the top of the dirt pile revealed a 4-foot-long ground scar consistent with the dimensions of the airplane's wing. To the right of the ground scar, was another impact mark, where a 12-inch-long section of a propeller blade was embedded. Also located around these impact marks were pieces of Plexiglas and broken landing light. The cockpit area exhibited impact damage. The empennage was buckled around the area of the "N" numbers, and there was no damage to any of the tail control surfaces. The tip of the vertical stabilizer came to rest in the dirt. A section of the outboard right wing was separated, and came to rest about 15 feet to the right of the main wreckage, and exhibited impact damage. The wing tip was located behind the main wreckage settled in brush on the dirt hillside. The inboard section of the wing was intact and attached at the wing root. The outboard section of the flap was pushed aft, and the aileron was attached to the inboard hinge and exhibited impact damage. The left wing was intact and exhibited leading edge impact damage along the entire length of the wing. The wing tip, aileron, and were intact. The flap was in the retracted position. The throttles, mixture, and propeller controls were found in the full forward position. The main landing gear were retracted. The fuel selector handles were found selected to the outboard tanks. Flight control continuity was established for each flight control surface to the cockpit. Examination of each of the four fuel-bladder tanks revealed that the left outboard tank was intact and empty, and the left inboard tank was empty, but breached at the engine nacelle. The right inboard tank was intact and about 1/4-full of fuel. The right outboard tank was intact, and a small amount of fuel was in the tank. Fuel was observed draining from the tank at the accident site. Both ## Aircraft - Registration: [N8162Y](https://openairdocs.org/deregistered/N8162Y-2009-12-23), registration cancelled 2009-12-23, S/N 30-1275, built 1966 (OpenAirDocs) - Reported make and model: Piper PA-30 - Registry model: [Piper PA-30](https://openairdocs.org/model/piper-pa-30) (registry code 7103002) (OpenAirDocs) - Registry engine: [Lycoming IO-320 series](https://openairdocs.org/engine/lycoming-io-320-series) (registry code 41509, reciprocating) (OpenAirDocs) - Category: Airplane - Serial number: 30-1275 - Airframe hours: 3009 - Engines: Lycoming IO-320-B1A 150 horsepower reciprocating; Lycoming IO-320-B1A reciprocating - Damage: Destroyed - Flight: Personal, Part 91 - Registered owner: Kenneth Stremming & Woodrow Williams - Airworthiness certificate: Standard, Normal - Last inspection: Annual, September 5, 2002, 36.8 hours before - Departed: CFJ, Crawfordsville, IN - Destination: PHD, New Philadelphi, OH - Airport: PHD, Harry Clever Field ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 67; injuries: fatal; private; airplane ratings: multi-engine land, single-engine land; instrument ratings: airplane; medical: class 3, valid medical--w/ waivers/lim; seat: left; toxicology performed; flight hours: 956 total, 159 in this make and model, 12 in the last 90 days, 11 in the last 30 days ## Weather - Conditions: Visual (VMC), Day - Wind: 120° at 7 knots - Visibility: 9 statute miles - Lowest ceiling: none - Temperature: 75 °F, dew point 64 °F - Altimeter: 30.12 inHg - Observed at: PHD, 1 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20030616018889A](https://openairdocs.org/incident/20030616018889A), Jun 16, 2003: Piper PA30, New Philadelphi, OH, Destroyed, 2 fatal. (-23) On 6-16-03 N8162Y a Piper 30-30, piloted by woodrow e. williams, crashed one mile south of new philadelphia (phd). There were two fatalities Mr. Williams… ## Other investigations on N8162Y (1) From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. - [NTSB CHI67A0077](https://openairdocs.org/ntsb/CHI67A0077), Dec 16, 1966: Piper PA-30B (N8162Y), Bloomington, IL, substantial damage From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.