# NTSB IAD05LA099: Cessna 525, N13FH, Old Bridge, NJ, July 17, 2005 - Type: NTSB accident investigation - Classification: Accident · Minor injuries · Limited investigation · Final report - Date: July 17, 2005, 16:18 local (20:18 UTC) - Place: Old Bridge, NJ - Coordinates: 40.325832, -74.352218 - Nearby events: https://openairdocs.org/map.md?lat=40.3258&lon=-74.3522&mi=10 - Phase of flight: [Landing](https://openairdocs.org/ntsb-phases/550) (OpenAirDocs' grouping) - Highest injury: Minor injuries - Injuries: 1 minor, 2 uninjured - Status: Completed, report September 18, 2006 - Report: Approved by Office Director - Parties: Cessna Aircraft Company, FAA FSDO-25 - NTSB case key (mKey): 61985 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=IAD05LA099 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/61985/pdf - Page: https://openairdocs.org/ntsb/IAD05LA099 ## Probable cause The pilot's improper preflight planning, his failure to consult performance data, and his failure to obtain the proper touchdown point, which resulted in a runway overrun. Contributing factors to the accident were the excessive airspeed, overweight condition, and wet runway. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Overrun, landing - preflight planning/preparation - improper, pilot in command (cause) - performance data - not used, pilot in command (cause) - proper touchdown point - not obtained, pilot in command (cause) - airspeed - excessive, pilot in command (contributing factor) - airport facilities,runway/landing area condition - wet (contributing factor) - aircraft weight and balance - exceeded, pilot in command (contributing factor) - On ground/water collision with object, landing - object - fence ## Analysis The airplane departed with a full load of fuel, flew approximately 35 minutes, and upon touchdown, weighed approximately 9,500 pounds. According to data recovered from the Enhanced Ground Proximity Warning System, the approach became unstabilized 0.1 miles from the runway threshold, triggering an aural sink rate warning. The airplane touched down fast on the first 1/3 of the runway. The pilot realized the airplane would not stop in the remaining distance, so he aborted the landing; however, before becoming airborne, the airplane overran the runway, struck multiple objects, and was substantially damaged. According to performance information, at 9,500 pounds, on a wet runway, 3,550 feet was required, 306 feet greater than available. ## Factual narrative HISTORY OF FLIGHT On July 17, 2005, about 1618 eastern daylight time, a Cessna 525, N13FH, sustained substantial damage during a runway overrun while landing at Old Bridge Airport (3N6), Old Bridge, New Jersey. The certificated airline transport pilot received minor injuries, and the two passengers were not injured. Day visual meteorological conditions prevailed for the flight that departed Sussex County Airport (GED), Georgetown, Delaware. An instrument flight rules flight plan was filed for the flight conducted under 14 CFR Part 91. According to the pilot's written statement, during a visual approach for runway 24 at Old Bridge Airport, he lost sight of the runway due to clouds that had moved into the area. The clouds were associated with a thunderstorm that was about 1 to 2 miles north of the airport. The pilot notified McGuire Approach that he was executing a missed approach and requested the GPS 24 approach. He was then given a heading of 060 degrees, and told to climb to 2,000 feet msl. Approximately 3 miles from STENY intersection, which was the final approach fix, the pilot was cleared for the GPS Runway 24 approach, and proceeded directly to STENY. At approximately 1 mile from STENY, he extended the flaps to the approach position. Upon crossing STENY he then lowered the landing gear, and started his descent to the minimum descent altitude of 600 feet msl. Approximately 3 miles from the runway, the airplane's airspeed was 115 knots indicated, and he had sight of the entire airport. The visibility was better than 5 miles, and the ceiling was greater than 750 feet, with cloud to ground lightning in the area. About 2 miles from the runway he extended the flaps to the landing position, and slowed the airplane to 108 knots. He could see that the runway was wet, but was absent of standing water. He landed "on the numbers," extended the flaps to the ground position and applied full braking. After touchdown, the pilot believed that the braking action was "nil." He further stated, "I could feel no braking at all." Approximately 1/3 of the way down the runway, he decided that he did not have enough room to stop, so he applied full power and retracted the flaps to the takeoff position. The airspeed did not seem to accelerate at a normal rate, and the airplane failed to obtain flying speed. It then rolled off of the runway pavement. PERSONNEL INFORMATION The pilot held an airline transport pilot certificate, with multiple ratings including airplane multi-engine land, and type ratings for the Boeing 737, Cessna 500, and Cessna 525S. He reported a total flight time of 8,370 hours, with 6,293 hours in multi-engine airplanes and 795 hours in the Cessna 525. His most recent FAA first-class medical certificate was issued on December 6, 2004. AIRCRAFT INFORMATION The airplane was manufactured in 1997. The airplane's most recent annual inspection was completed on March 3, 2005. At the time of the inspection, the airplane had accrued 1,907.7 total hours of operation. METEOROLOGICAL INFORMATION The reported weather at The Monmouth Executive Airport (BLM), Farmingdale, New Jersey, 14 nautical miles southeast of the accident site, at 1615, included: winds from 160 degrees at 11 knots, gusting to 14 knots, visibility 10 miles, a broken ceiling at 1,500 feet, temperature 81 degrees Fahrenheit, dew point 75 degrees Fahrenheit, and an altimeter setting of 29.38 inches of mercury. AIRPORT INFORMATION Old Bridge Airport had one runway, oriented in a 06/24 configuration. The runway was asphalt, and in good condition. The runway was 3,594 feet long by 50 feet wide. Multiple obstructions existed at the approach end of runway 24, which displaced the threshold by 400 feet. A 24-foot tall tree was located 230 feet from the approach end of the runway pavement, and 20 feet left of the centerline. 19-foot high trees were located 125 feet from the approach end of the runway pavement, and 6 foot high vegetation was located 50 feet from the approach end of the runway pavement. A 26:1 approach slope to the displaced threshold was published for the runway, and the available landing length was 3,194 feet. The runway sloped downward 0.6%. A two light, 4.00 degree glide path, Precision Approach Path Indicator was installed on the right side of the runway. Airport Services were obtainable at the airport, however; no approved fuels for the Cessna 525 were available. WRECKAGE AND IMPACT INFORMATION The airplane came to rest on a magnetic heading of 310 degrees, approximately 400 feet beyond the departure end of runway 24, after traveling down sloping terrain where it impacted numerous objects. The upper and lower speedbrakes were in the retracted position. The wing flaps and the flap lever were in the takeoff position. Both main landing gear had collapsed, and the nose gear had separated from the airplane. Examination of the normal and emergency braking system revealed, that the brake fluid reservoir was full. When electrical power was applied to the airplane, the power brake hydraulic pump motor operated and accumulator pressure was observed to be within the normal operating range. The anti-skid switch was in the "ON" position. With the exception of a low-pressure indication in the emergency air bottle, no preimpact anomalies were noted to the brake or landing gear system. WEIGHT AND BALANCE INFORMATION The pilot stated that the accident flight time was approximately 35 to 40 minutes in length. The airplane had 3,250 pounds of fuel when he began to taxi, and at takeoff, was down to 3,050 pounds. He added that, this would have placed his gross weight at 10,200 to 10,300 pounds at takeoff. He also stated that the airplane's weight at landing was 9,500 pounds. A review of the fuel provider's records revealed that the aircraft was filled with 2,050 pounds of fuel, prior to the accident flight. According to the fueler, the fuel order he had received from the pilot was to "top it off." TESTS AND RESEARCH According to the FAA approved flight manual, the fuel system on the airplane holds approximately 3,220 pounds of usable fuel when filled to the bottom of the filler standpipe. It is also possible to exceed that amount by 220 more pounds of fuel, if the wing is filled to the top of the standpipe. ADDITIONAL INFORMATION Enhanced Ground Proximity Warning System The airplane was equipped with an Enhanced Ground Proximity Warning System (EGPWS). Information obtained from the EGPWS revealed that approximately 0.1 nautical miles prior to the runway threshold, the airplane's ground speed was 133 knots, and the descent rate was 1,522 feet per minute. At the same time, the unit announced an aural "sink rate" warning. The data also indicated that the airplane contacted the runway approximately 0.2 nautical miles (1,215 feet) beyond the runway threshold. Review of Available Performance Information A review of Section IV and VII of the FAA approved flight manual revealed that landing performance information was available to the pilot. Standard performance conditions were based on a landing preceded by a steady 3 degree angle approach, down to the 50 foot height point with airspeed at 1.3 times the stalling speed or the minimum steady flight speed in the landing configuration. Variable factors for wind, wet runway conditions and runway gradient was also available. According to published performance information, at 9,500 pounds, airspeed at the 50-foot height point should be 107 knots. In a no wind condition, with a dry and level runway, the airplane required a landing distance of approximately 2,770 feet. The Advisory Information Section VII corrections for a wet runway increased that distance to approximately 3,550 feet. During an interview conducted by the Safety Board on July 22, 2005 the pilot stated that he was "not sure if I looked at the wet runway stuff." On approach the E ## Aircraft - Registration: [N13FH](https://openairdocs.org/deregistered/N13FH-2009-05-29), registration cancelled 2009-05-29, S/N 525-0185, built 1997 (OpenAirDocs) - Reported make and model: Cessna 525 - Registry model: [Cessna 525](https://openairdocs.org/model/cessna-525) (registry code 2076601) (OpenAirDocs) - Registry engine: [Williams FJ44-1A](https://openairdocs.org/engine/williams-fj44-1a) (registry code 66002, turbo-fan) (OpenAirDocs) - Category: Airplane - Serial number: 525-0185 - Airframe hours: 1907.7 - Engines: Williams International FJ44-1A 1900 lbs thrust turbo fan; Williams International FJ44-1A 1900 lbs thrust turbo fan - Damage: Substantial damage - Flight: Executive/Corporate, Part 91 - Registered owner: Hertrich Aviation Inc. - Airworthiness certificate: Standard, Normal - Last inspection: Continuous airworthiness, March 1, 2005, 50 hours before - Departed: GED, Georgetown, DE - Destination: 3N6, Old Bridge, NJ - Flight plan: IFR - Airport: 3N6, Old Bridge Airport, runway 24, 3,594 × 50 ft, asphalt ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 45; injuries: minor; airline transport, commercial; airplane ratings: single-engine land, multi-engine land; instrument ratings: airplane; medical: class 1, with waivers/limitations; last flight review March 1, 2005; seat: left; flight hours: 8,370 total, 795 in this make and model, 8,020 as pilot in command, 32 in the last 90 days, 6 in the last 30 days, 1 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Wind: 160° at 11 knots, gusting 14 - Visibility: 10 statute miles - Lowest ceiling: 1,500 ft broken - Temperature: 81 °F, dew point 75 °F - Altimeter: 29.37 inHg - Observed at: BLM, 14 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20050717020809A](https://openairdocs.org/incident/20050717020809A), Jul 17, 2005: Cessna 525, Old Bridge, NJ, Destroyed. (-23) Pilot aborted a visual approach after losing visual reference to the airport due to thunderstorm over airport. He executed a missed approach and… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.