# NTSB IAD97FA043: Piper PA-28-236, N8263Y, Alton, NH, January 17, 1997 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: January 17, 1997, 13:35 local (18:35 UTC) - Place: Alton, NH - Location: 43.4564° N, 71.2223° W: Placed by OpenAirDocs: center of Alton, NH, within about 6 miles (OpenAirDocs) - Nearby events: https://openairdocs.org/map.md?lat=43.4564&lon=-71.2223&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 2 fatal - Status: Completed, report February 29, 2000 - Report: Approved by Office Director - NTSB case key (mKey): 28128 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=IAD97FA043 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/28128/pdf - NTSB docket: https://data.ntsb.gov/Docket?ProjectID=28128 - Page: https://openairdocs.org/ntsb/IAD97FA043 ## Probable cause An exhaust gas leak, due to inadequate maintenance, which resulted in carbon monoxide poisoning, and incapacitation of the pilot. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of control - in flight, cruise - exhaust system,muffler - cracked (cause) - maintenance - inadequate (cause) - incapacitation(carbon monoxide), pilot in command (cause) - exhaust system,muffler - leak (cause) - In flight collision with object, descent - uncontrolled - object - tree(s) ## Analysis The pilot and pilot rated passenger (PRP) were on a cross country flight, when 25 minutes into the flight the PRP radioed ATC that the pilot was sick. ATC and the pilot of another airplane attempted to talk the PRP down, but after about 20 minutes the PRP reported being tired and nauseated. No further transmissions were received from the airplane, and it flew an additional 1 1/2 hours before it descended into a heavily wooded area. Examination of the wreckage revealed cracks and heavy pitting corrosion of the muffler case which allowed exhaust gases to enter the space between the muffler and the shroud, and to enter the cabin area. Toxicological tests showed that the pilot and the PRP had carbon monoxide levels of 43% and 69%. The airplane had an annual inspection completed 1 year prior to the accident, and had accumulated over 88 hours since the inspection. ## Factual narrative HISTORY OF FLIGHT On January 17, 1997, at 1335 eastern standard time, a Piper PA-28-236, N8263Y, was destroyed when it collided with trees near Alton, New Hampshire. The pilot and one passenger were fatally injured. Visual meteorological conditions prevailed and a flight plan was not filed. The personal flight was conducted under 14 CFR Part 91. The flight originated from Farmingdale (FRG), New York, at approximately 1115. The intended destination was Saranac Lake, New York. According to Air Traffic Control (ATC) records, at 1117, the pilot radioed New York ATC, and advised the controller that he was 4 1/2 miles north of FRG at 3,000 feet, and requested flight following. The flight then proceeded uneventful for the next 25 minutes. At 1139, the controller radioed the pilot and instructed him to contact the Boston Air Route Traffic Control Center (ARTCC), but there was no response. At 1141, the pilot rated passenger (PRP) transmitted that they were in trouble, and that the pilot was not responding. She told the controller that she was the co-pilot, and only had pilot experience in a Cessna 172. At 1142, the controller advised the PRP that they were basically the same aircraft, and that they just land a little differently. He instructed her to do a shallow left turn southbound, and he would keep her VFR to help talk her down to an airport. He also advised her to descend if she could, and to stay clear of the clouds. At 1143, the PRP advised the controller that she could see the ground while making the turn, and that the pilot was throwing up. The controller informed the PRP that she was over the Danbury Airport, Danbury, Connecticut. During the next 16 minutes, the controller and the pilot of another airplane (POAA) provided directions and instructions to the PRP. At 1156, the PRP radioed that she was getting tired, and she was nauseated. At 1158, the POAA asked the PRP to lower the nose of the airplane and to start descending, and the PRP responded that she was trying to "activate" the pilot. At 1200, she repeated she was very tired. The POAA told the PRP where the control wheel was, and that she should trim the airplane. At 1204, the controller advised the POAA that the airplane had turned northbound, and that it was slowly climbing. The controller told the POAA that the PRP was responding with idents. At 1207, the controller advised the POAA that the airplane was at 8,200 feet, and that there were no further idents from the PRP. At 1209, the controller advised the POAA that the airplane was holding it's heading and altitude of 8,800 feet. At 1210, the controller radioed the PRP and told her to open a vent on the airplane and get some fresh air as there might be carbon monoxide in the cockpit. At 1212, the controller radioed the PRP and told her to lower the nose because the airplane was probably trimmed to climb. The transmission was not acknowledged. At 1217, the controller radioed the PRP, and told her that maybe the autopilot was on, and that was probably why it was difficult to descend. Shortly thereafter, the controller advised the POAA that the PRP's airplane was descending rapidly. At 1221, the controller advised the POAA that the airplane was at 7,800 feet, and that the bases of the clouds were around 5,000 feet. The POAA advised the controller that he was at 5,000 feet, and that it was VFR. The controller that had coordinated the two airplanes, contacted Bradley Approach Control, and coordinated the handover of the two airplanes to their airspace. The airplanes were then handed off to the Boston ARTCC at 1249. At 1313, the POAA reported that he had the airplane in sight. At 1318, the POAA reported that he saw smoke coming out of the engine, and at 1320, the POAA reported that nobody was sitting up, and it appeared the entire cabin was full of smoke and that the engine was smoking. At 1324, the POAA reported that the airplane was descending rapidly. At 1326, the POAA reported that the PRP had crashed into trees. The airplane impacted trees in a heavily wooded area during the hours of daylight about 43 degrees 32 minutes North latitude, and 71 degrees, 12 minutes West longitude. PERSONNEL INFORMATION The pilot held a Private Pilot Certificate with ratings for airplane single engine land, and instrument airplane. The pilot had recorded a total flight experience of approximately 352 hours, upon the completion of his instrument flight test on January 13, 1991. From January 13, 1991, until the last log book entry dated January 4, 1996, the pilot only logged events such as adverse weather, actual instrument time, and the tach time at each refueling. On his application for a third class medical that was issued on August 1, 1995, he reported over 700 hours of total flight experience. The pilot rated passenger held a private pilot certificate with a single engine land rating. According to her application for a third class medical certificate dated December 28, 1993, she reported 165 hours of total flight experience. METEOROLOGICAL INFORMATION At 1251, Concord Municipal Airport, Concord, New Hampshire, located about 26 miles south of the accident site, reported the following observation: Sky condition, ceiling 7000 broken; visibility, 10 miles; temperature, 9 degrees Fahrenheit (F); dew point, -14 degrees F; winds from 290 at 14 knots with wind gusts up to 33 knots; and altimeter, 29.74 inches Hg. WRECKAGE AND IMPACT INFORMATION The airplane wreckage was examined at the accident site on January 18 and 19, 1997. Examination of the accident site revealed impact scars at the tops of trees. The airplane wreckage was distributed over an area approximately 150 feet long by 25 feet wide, oriented on a magnetic heading of 060 degrees. All major components of the airplane were accounted for at the scene. The main wreckage, which consisted of the empennage, top of the fuselage and remainder of the right wing were found about 130 feet beyond the initial impact point (IIP). The engine was separated from the fuselage and located about 150 feet beyond the IIP. The lower forward section of the fuselage was destroyed. The cockpit section along with the right front seat, cabin door, and a section of the right side fuselage skin were located adjacent to the main wreckage against a tree. This area contained the rear fresh air vents, which were in the closed position. The front fresh air vents were separated, and found near the main wreckage. One vent was closed while the other vent was partially opened. The overhead vent knob and the overhead vent were in the open position. The panel mounted fan switch was in the high position. The heater control box remained attached to the fuselage and was in the open position. The two forward floor heat vents were also in the open position. The stabilizers and rudder remained attached to the main wreckage. The vertical stabilizer was crushed aft at the top. The rudder was crushed down and aft from the top to the top hinge. The rudder was compressed below the hinge from the leading edge to the trailing edge. The left side and right side horizontal stabilizer were damaged and were not functional. The elevator trim measured 3 threads. According to the Piper representative, this corresponded to 1.8 degrees tab up. The propeller hub and propeller separated from the engine. One blade was bent aft while the other blade was straight. The blades displayed some chordwise scratches and gouges at the tips. The engine was removed from the wooded area and examined in a hangar at the Lakes Region Airport, Wolfeboro, New Hampshire, on January 19, 1997, under the supervision of the National Transportation Safety Board (NTSB). When the muffler shroud was removed, it revealed a large hole in the muffler that, was shared by the #5 and #6 cylinder exhaust stacks. The hole was near the left end (#6side), and measured approx ## Aircraft - Registration: [N8263Y](https://openairdocs.org/deregistered/N8263Y-1999-10-28), registration cancelled 1999-10-28, S/N 28-8111001 (OpenAirDocs) - Reported make and model: Piper PA-28-236 - Registry model: [Piper PA-28-236](https://openairdocs.org/model/piper-pa-28-236) (registry code 7102815) (OpenAirDocs) - Category: Airplane - Serial number: 28-8111001 - Airframe hours: 1626 - Engines: Lycoming O-540-J3A5D 235 horsepower reciprocating - Damage: Destroyed - Flight: Personal, Part 91 - Registered owner: David A Riach - Airworthiness certificate: Standard, Normal - Last inspection: Annual, January 17, 1996, 88 hours before - Departed: FRG, FARMINGDALE, NY - Destination: SLK, SARANAC LAKE, NY ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 46; private; airplane ratings: single-engine land; instrument ratings: airplane; medical: class 3, valid medical--no waivers/lim.; seat: left; toxicology performed; flight hours: 870 total, 686 in this make and model, 758 as pilot in command, 30 in the last 90 days, 8 in the last 30 days, 2 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Wind: 290° at 14 knots, gusting 33 - Visibility: 10 statute miles - Lowest ceiling: 7,000 ft broken - Temperature: 9 °F, dew point -0 °F - Altimeter: 29.00 inHg - Observed at: CON, 26 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 19970117000529A](https://openairdocs.org/incident/19970117000529A), Jan 17, 1997: Piper PA28236, Alton, NH, Destroyed, 2 fatal. Pilot collapsed. Prp right seat vectored coached to land also collapsed. Muffler had large hol. CO2 monoxide factor ## Docket (23 files) The files NTSB released with the investigation on April 16, 1999, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=28128. 6.0 MB in all. - Supplement A- Wreckage Documentation (item 1, .PDF, 265 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104135&FileExtension=.PDF&FileName=Supplement%20A-%20Wreckage%20Documentation-Master.PDF - Supplement B- Cockpit Documentation (item 2, .PDF, 356 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104136&FileExtension=.PDF&FileName=Supplement%20B-%20Cockpit%20Documentation-Master.PDF - Supplement E - Second Pilot Information (item 3, .PDF, 163 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40468472&FileExtension=.PDF&FileName=Supplement%20E%20-%20Second%20Pilot%20Information-Master.PDF - Supplement K - Occupant, Survival and Injury Information (item 4, .PDF, 848 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104138&FileExtension=.PDF&FileName=Supplement%20K%20-%20Occupant,%20Survival%20and%20Injury%20Information-Master.PDF - Factual Report of Metallurgist's (item 5, .PDF, 188 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40468471&FileExtension=.PDF&FileName=Factual%20Report%20of%20Metallurgist%27s-Master.PDF - Recorded Radar Study Report (item 6, .PDF, 1.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40468473&FileExtension=.PDF&FileName=Recorded%20Radar%20Study%20Report-Master.PDF - Sectional Chart of Accident Area (item 7, .PDF, 443 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104141&FileExtension=.PDF&FileName=Sectional%20Chart%20of%20Accident%20Area-Master.PDF - Wreckage Diagram (item 8, .PDF, 151 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104142&FileExtension=.PDF&FileName=Wreckage%20Diagram-Master.PDF - Excerpts from Piper A/C Maintenance Manual (item 9, .PDF, 403 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104143&FileExtension=.PDF&FileName=Excerpts%20from%20Piper%20A%2FC%20Maintenance%20Manual-Master.PDF - Excerpts from ATC Package (item 10, .PDF, 741 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40468475&FileExtension=.PDF&FileName=Excerpts%20from%20ATC%20Package-Master.PDF - Excerpts from FAA Flight Training Handbook (item 11, .PDF, 188 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104145&FileExtension=.PDF&FileName=Excerpts%20from%20FAA%20Flight%20Training%20Handbook-Master.PDF - Excerpt from Army Aeromedical Training for Flight Personnel (item 12, .PDF, 353 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104146&FileExtension=.PDF&FileName=Excerpt%20from%20Army%20Aeromedical%20Training%20for%20Flight%20Personnel-Master.PDF - Statement of Party Representatives to NTSB Investigation (item 13, .PDF, 238 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40468474&FileExtension=.PDF&FileName=Statement%20of%20Party%20Representatives%20to%20NTSB%20Investigation-Master.PDF - Release of Aircraft Wreckage, NTSB Form 6120.15 (item 14, .PDF, 102 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40468477&FileExtension=.PDF&FileName=Release%20of%20Aircraft%20Wreckage,%20NTSB%20Form%206120.15-Master.PDF - Toxicological Report (item 15, .PDF, 105 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40468476&FileExtension=.PDF&FileName=Toxicological%20Report-Master.PDF - Photo #1 Main Wreckage (item 16, .PDF, 55 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104150&FileExtension=.PDF&FileName=Photo%20%231%20Main%20Wreckage%20-Master.PDF - Photo #2 Heater Fan Switch in the HIGH Position (item 17, .PDF, 50 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104151&FileExtension=.PDF&FileName=Photo%20%232%20Heater%20Fan%20Switch%20in%20the%20HIGH%20Position-Master.PDF - Photo #3 Engine at Accident Site (item 18, .PDF, 43 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104152&FileExtension=.PDF&FileName=Photo%20%233%20Engine%20at%20Accident%20Site-Master.PDF - Photo #4 Engine at Hangar at Lakes Region Airport (item 19, .PDF, 43 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104153&FileExtension=.PDF&FileName=Photo%20%234%20Engine%20at%20Hangar%20at%20Lakes%20Region%20Airport-Master.PDF - Photo #5 Muffler Shroud (item 20, .PDF, 39 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104154&FileExtension=.PDF&FileName=Photo%20%235%20Muffler%20Shroud-Master.PDF - Photo #6 Muffler from No. 5 and 6 Cylinders (item 21, .PDF, 34 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104155&FileExtension=.PDF&FileName=Photo%20%236%20Muffler%20from%20No.%205%20and%206%20Cylinders-Master.PDF - Photo #7 Hole in Muffler (item 22, .PDF, 27 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104156&FileExtension=.PDF&FileName=Photo%20%237%20Hole%20in%20Muffler%20-Master.PDF - Photo #8 Hole in Muffler (item 23, .PDF, 30 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40104157&FileExtension=.PDF&FileName=Photo%20%238%20Hole%20in%20Muffler-Master.PDF From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.