# NTSB LAX02FA188: Fisher Celebrity, N8205H, Chandler, AZ, June 8, 2002 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: June 8, 2002, 07:30 local (14:30 UTC) - Place: Chandler, AZ - Coordinates: 33.205276, -111.752502 - Nearby events: https://openairdocs.org/map.md?lat=33.2053&lon=-111.7525&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 2 fatal - Status: Completed, report September 13, 2005 - Report: Approved by Office Director - Parties: Federal Aviation Administration - NTSB case key (mKey): 54899 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=LAX02FA188 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/54899/pdf - NTSB docket: https://data.ntsb.gov/Docket?ProjectID=54899 - Page: https://openairdocs.org/ntsb/LAX02FA188 ## Probable cause failure of the wing spars and the in-flight separation of the aircraft wing due to the builder's inadequate manufacture of this experimental aircraft. Also causal was the current owner/pilot's continued flight with known mechanical discrepancies. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Airframe/component/system failure/malfunction, cruise - aircraft/equipment inadequate, owner/builder (cause) - wing,spar - inadequate (cause) - wing,skin - loose - operation with known deficiencies in equipment - continued, pilot in command (cause) - wing - failure - In flight collision with terrain/water, descent - uncontrolled - terrain condition - ground ## Analysis During cruise flight, both of the left wings of the amateur built experimental biplane separated in flight. The airplane fuselage was a metal frame, and the empennage and wings were fabric covered wood. The pilot had contacted a friend, who was also constructing a Celebrity, a few weeks before the accident concerning loose fabric on the airplane's wings. The friend told the pilot not to fly the airplane until the loose fabric issue had been addressed. According to the friend, the pilot washed the airplane, let it dry in the sun, and noted that the loose fabric tightened up. The pilot believed that the loose fabric issue had been resolved. Various wing components were examined and compared with the building instructions and plan drawings. The examination revealed fracture features indicating that the wings failed in a positive overload event. No evidence of preexisting cracks or deteriorated wood was found. However, the comparison with the design revealed that the construction of the spars did not comply with their design drawings. In particular, the spars did not contain stiffener blocks adjacent to the upper and lower caps, and the filler blocks ended abruptly in a vertical line instead of tapering to the upper and lower caps. The filler blocks were thinner than specified in the plans and occupied 50 percent of the space between the spar caps instead of all the void. The filler blocks were also shorter than plan specification and did not taper according to the plan. Both of these conditions would reduce the load carrying capacity of the wing, especially in compression. The failure location was primarily at the outboard end of the filler blocks. No material defects were found during the examination. ## Factual narrative HISTORY OF FLIGHT On June 8, 2002, about 0730 mountain standard time, a single engine experimental Fisher Celebrity biplane, N8205H, impacted flat desert terrain after the left wings separated from the fuselage near Chandler, Arizona. The airplane, owned and operated by the pilot under the provisions of 14 CFR Part 91, was destroyed. The private pilot and one passenger were fatally injured. Visual meteorological conditions prevailed for the local area flight that departed the Stellar Airpark Airport (P19), Chandler, at an unknown time. No flight plan had been filed. The flight was scheduled to terminate at P19. Witnesses in the area indicated that they heard a "pop" and sputtering of an engine. When they looked up into the air, they saw the accident airplane with the left wings folded back. Witness also stated that the airplane was disintegrating in the air. According to a witness, who was outside her house, the airplane was flying in a southerly direction. She looked up because she heard the airplane fly overhead and it sounded like it was really close to the ground. She saw the airplane in a nose high attitude, with one of the wings parallel to the airplane. The witness stated that she saw the nose drop; the wings folded, and then she watched the airplane spiral to the ground. PERSONNEL INFORMATION A review of Federal Aviation Administration (FAA) airman records revealed the pilot held a private pilot certificate with an airplane single engine land rating. The pilot received his private pilot certificate on June 5, 2002. The pilot held a third-class medical certificate issued on December 26, 2001. It had no limitations or waivers. No personal flight records were located for the pilot. The aeronautical experience listed was obtained from a review of the airmen FAA records on file in the Airman and Medical Records Center, Oklahoma City, Oklahoma. On his Airman Certificate and/or Rating Application (FAA Form 8710), dated June 5, 2002, the pilot reported a total time of 65 hours. AIRCRAFT INFORMATION The airplane was a Fisher Celebrity, serial number AVI001, and was first issued an experimental airworthiness certificate in 1989. A Teledyne Continental Motors A & C65 Series engine was installed on the airplane. The airplane logbooks were not available for review. A witness submitted a written statement indicating that the pilot had purchased the airplane around October 2001. The witness was in the process of building the same airplane. The pilot did not receive original construction plans with the airplane, so he would call the witness, and ask him questions about the airplane. About 3 weeks prior to the accident the witness received a call from the pilot. The pilot wanted to know what guidance the new kit owners (Fisher Flying Products) provided with regards to rib stitching of the wing fabric. The witness stated that the pilot informed him that the wing fabric was delaminating. The witness told the pilot that Fisher Flying Products only required that the fabric be glued to the wing ribs. The witness also gave him the telephone number to Fisher Flying Products technical support, and recommended that he ground the airplane until he had the matter resolved. About 4 days later the witness contacted the pilot to ask if he had spoken to anyone at the factory. The pilot replied that he had washed the airplane and "it looked a lot better." The witness told him that washing the airplane would not tighten the fabric. The witness also told him that he had left over fabric from his kit and could help him [the pilot] recover the wings and help him rib stitch the fabric. The witness reported that the accident occurred a week later. Another witness reported that he felt the fabric covering was not as tight as it could have been near the front horizontal stabilizer. He also indicated that he was not comfortable flying it, but did not believe that the "cover presented a danger." WRECKAGE AND IMPACT INFORMATION The airplane impacted terrain in an open field. An FAA inspector examined the airplane on-scene. He noted paint chips and leading edge rib pieces from one of the wings were located 1/4-mile north of the accident site. A portion of a wing spar came to rest about 30 feet from the accident site. Pieces of the airplane were also found on the rooftops of houses that were along the airplane's route of flight. The FAA inspector noted that both of the left wings separated from the airplane and from each other. Both of the right wings remained connected to the fuselage as well as to each other. The flight control cables for the right wings, rudder, and elevator remained connected to the cockpit controls. MEDICAL AND PATHOLOGICAL INFORMATION The Pima County Coroner conducted an autopsy on the pilot on June 10, 2002. The FAA Toxicology and Accident Research Laboratory, Oklahoma City, performed a toxicological analysis from samples obtained during the autopsy. The results of the analysis of the specimens were negative for carbon monoxide, cyanide, volatiles, and tested drugs. TESTS AND RESEARCH The Safety Board investigator-in-charge (IIC) inspected the airplane at Air Transport on June 13, 2002. Flight control continuity was established from the cabin to the rudder and elevator. The fuselage structure was constructed of metal, while the empennage, tail section, and wings were predominately comprised of wood. During the inspection the IIC noted that the paint on the fabric of the upper and lower left and right wings was chipped. The inner fabric of the wings was painted with a silver dope. The silver dope is utilized to protect the wings from ultra violet rays and strengthens the fabric. The upper and lower left wings, connected together via an interplane strut, had separated, and both wings separated from the fuselage. The fabric for both of the upper and lower left wings separated in numerous places. A majority of the wing ribs and wing spar was not present in the upper left wing. The leading edge spar of the lower left wing remained attached to the fabric; however, wing ribs and portions of the wing spar were missing. The interplane strut for the upper and lower right wings remained connected. Both wings remained attached to their respective fuselage attachment struts. The bottom portion of the upper right wing was split open at the trailing edge. The upper right wing also split open at the leading edge and retained its spar as well as pieces of the rib. Some of the ribs were detached and lying on the inside of the wing; other ribs remained attached to the wing skin. A portion of one of the propeller blades remained attached to the propeller hub. The blade was broken in several places with jagged and splintered breaks. The other propeller blade was missing; however, there were splintered pieces of the blade still attached to the propeller hub. The propeller assembly remained connected to the crankshaft. The engine remained attached to the engine mounts. Inboard pieces of the four wooden spars, a portion of an upper wing, portions of the upper wing attachment framework, and a portion of wing tip with attached fabric were sent to the National Transportation Safety Board Materials Laboratory, Washington, D.C., for further examination. The examination and a review of the kit drawings revealed that the only common components were the spar cap, the web, and the attachment fittings. The kit drawing indicated that the spar cap stiffeners were to be rectangular in shape and run the full length of the spar. The accident airplane's spar cap stiffeners were triangular in shape and terminated at the outer end of the filler blocks. According to the drawing, the filler blocks were to fill all of the space between the spar cap stiffeners. The filler blocks on the accident aircraft were thinner and occupied approximately 50 percent of the space ## Aircraft - Registration: [N8205H](https://openairdocs.org/deregistered/N8205H-2003-02-25), registration cancelled 2003-02-25, S/N AVI001, built 1989 (OpenAirDocs) - Reported make and model: Fisher Celebrity - Registry model: [Fisher Michael E FISHER](https://openairdocs.org/model/fisher-michael-e-fisher) (registry code 05616PD) (OpenAirDocs) - Registry engine: [Continental A&C65 series](https://openairdocs.org/engine/continental-a-c65-series) (registry code 17003, reciprocating) (OpenAirDocs) - Category: Airplane, amateur-built - Serial number: AVI001 - Engines: Continental A&C65 Series 65 horsepower reciprocating - Damage: Destroyed - Flight: Personal, Part 91 - Registered owner: Joseph P. Carter - Airworthiness certificate: Special, Experimental (Special) - Departed: P19, Chandler, AZ ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 39; injuries: fatal; private; airplane ratings: single-engine land; medical: class 3, valid medical--no waivers/lim.; last flight review June 5, 2002; seat: rear; toxicology performed; flight hours: 65 total, 24 as pilot in command ## Weather - Conditions: Visual (VMC), Day - Wind: variable at 5 knots - Visibility: 35 statute miles - Lowest ceiling: none - Temperature: 84 °F, dew point 46 °F - Altimeter: 29.70 inHg - Observed at: CHD, 5 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20020608015189A](https://openairdocs.org/incident/20020608015189A), Jun 8, 2002: Amtr FISHER, Chandler, AZ, No damage, 2 fatal. (.19) On June 8, 2002, about 0730 hours mountain standard time, an experimental Fisher celebrity bi-plane, N8205H, impacted flat desert terrain after the wings… ## Docket (14 files) The files NTSB released with the investigation on May 31, 2005, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=54899. 8.6 MB in all. - Materials Laboratory 15 - Factual Report 03-105 (item 1, .PDF, 20 photos, 918 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40444271&FileExtension=.PDF&FileName=Materials%20Laboratory%2015%20-%20Factual%20Report%2003-105-Redacted.PDF - Witness Statement (item 2, .PDF, 128 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229992&FileExtension=.PDF&FileName=Witness%20Statement-Redacted.PDF - Wreckage Diagram (item 3, .PDF, 277 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229993&FileExtension=.PDF&FileName=Wreckage%20Diagram-Redacted.PDF - SDL FSDO Report (item 4, .PDF, 141 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40444272&FileExtension=.PDF&FileName=SDL%20FSDO%20Report-Redacted.PDF - Excerpt Maricopa County Sheriff's Department - Witness Statements (item 5, .PDF, 1.5 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40444273&FileExtension=.PDF&FileName=Excerpt%20Maricopa%20County%20Sheriff%27s%20Department%20-%20Witness%20Statements-Redacted.PDF - Toxicological Report (item 6, .PDF, 53 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40444274&FileExtension=.PDF&FileName=Toxicological%20Report-Redacted.PDF - Release of Aircraft Wreckage, NTSB Form 6120.15 (item 7, .PDF, 107 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40230004&FileExtension=.PDF&FileName=Release%20of%20Aircraft%20Wreckage,%20NTSB%20Form%206120.15-Redacted.PDF - Photo 1. Right Side (item 8, .PDF, 1.5 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229994&FileExtension=.PDF&FileName=Photo%201.%20%20Right%20Side-Master.PDF - Photo 2. Layout Right Wings (item 9, .PDF, 205 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229995&FileExtension=.PDF&FileName=Photo%202.%20%20Layout%20Right%20Wings-Master.PDF - Photo 3. Layout Right Upper Wing (item 10, .PDF, 206 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229996&FileExtension=.PDF&FileName=Photo%203.%20%20Layout%20Right%20Upper%20Wing-Master.PDF - Photo 4. Left Side (item 11, .PDF, 1.5 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229997&FileExtension=.PDF&FileName=Photo%204.%20%20Left%20Side-Master.PDF - Photo 5. Layout Left Wings (item 12, .PDF, 190 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229998&FileExtension=.PDF&FileName=Photo%205.%20%20Layout%20Left%20Wings-Master.PDF - Photo 6. Layout Left Upper Wing (item 13, .PDF, 178 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40229999&FileExtension=.PDF&FileName=Photo%206.%20%20Layout%20Left%20Upper%20Wing-Master.PDF - Photo 7. Nose (item 14, .PDF, 1.7 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40230000&FileExtension=.PDF&FileName=Photo%207.%20%20Nose-Master.PDF From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.