# NTSB LAX05LA134: Newell Thomas RV6-A, N16TN, Hayward, CA, April 12, 2005 - Type: NTSB accident investigation - Classification: Accident · Minor injuries · Limited investigation · Final report - Date: April 12, 2005, 08:55 local (15:55 UTC) - Place: Hayward, CA - Coordinates: 37.659168, -122.122222 - Nearby events: https://openairdocs.org/map.md?lat=37.6592&lon=-122.1222&mi=10 - Phase of flight: [Initial climb](https://openairdocs.org/ntsb-phases/350) (OpenAirDocs' grouping) - Highest injury: Minor injuries - Injuries: 1 minor - Status: Completed, report June 28, 2006 - Report: Approved by Office Director - Parties: Federal Aviation Administration - NTSB case key (mKey): 61292 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=LAX05LA134 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/61292/pdf - Page: https://openairdocs.org/ntsb/LAX05LA134 ## Probable cause A loss of engine power due to fuel system contamination. A factor in the accident was the fuel system not being flushed out after it was involved in a previous accident where the fuel tanks were damaged. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power(total) - nonmechanical, takeoff - initial climb - fuel system - contamination,other than water (cause) - maintenance,major repair - improper, owner/builder (cause) - fuel system,filter - foreign material/substance (cause) - fuel system,filter - flow restricted (cause) - fuel system,line - blocked(partial) (cause) - fluid,fuel - starvation (cause) - Forced landing, descent - emergency - In flight collision with object, emergency landing - object - vehicle ## Analysis The airplane collided with an unoccupied truck short of the runway, following a total loss of engine power. Shortly after departure, and during the initial climb, the engine experienced a total loss of power. The pilot was unable to make it to the runway surface and the airplane collided with a truck located in a city maintenance yard. The airplane had undergone repairs from a previous accident 9 months prior to this accident. The airplane had flown a total of 1.6 hours since being returned to service. The repairs included the airplane being outfitted with new aluminum fuel tanks (supplied by the pilot), as the previous tanks had been damaged. There was no evidence that the mechanic who installed the fuel tanks or the pilot ever flushed the fuel system. At the accident site the glass fuel filters were removed from the airplane for examination and dark debris lining both filters was observed. Examination of the right fuel filter disclosed that fuel would not flow from the outlet side, but was able to flow from the inlet side, due to debris contamination. The fuel filters were automobile specific and visible to the pilot from the cockpit. Trace amounts of fuel were found throughout various points in the fuel system, including the fuel pumps and carburetor bowl. An examination of the carburetor's brass float found scrape marks, or chaffing on each side. The fuel lines were contaminated with a foreign particulate matter and flow tests using air found that the contaminants hindered air flow through the lines. The fuel filters were sent to the Safety Board Material Laboratory for analysis of the contaminants. An energy dispersive spectroscopy (EDS) was used to identify the material inside the filters as corroded iron or steel particles and dirt. Several larger pieces of a white material were identified as either plastic or paint. The quantity and size of the debris could have significantly impeded the flow of fuel through the filter. ## Factual narrative HISTORY OF FLIGHT On April 12, 2005, about 0855 Pacific daylight time, a Newell Thomas RV-6A, N16TN, collided with a truck in a city maintenance yard short of the runway at the Hayward Executive Airport, Hayward, California. The pilot/owner was operating the airplane under the provisions of 14 CFR Part 91. The private pilot, the sole occupant, sustained minor injuries; the airplane sustained substantial damage. The personal flight was originating from Hayward with a planned destination of Livermore Municipal Airport, Livermore, California. Visual meteorological conditions prevailed, and a flight plan had not been filed. Shortly after departure, and during the initial climb, the pilot reported to an air traffic controller that his engine was running rough. He made a request to return back to the airport and maneuvered the airplane in that direction. The engine experienced a total loss of power and the pilot declared that he would be unable to make it to the runway surface. During the forced landing, the airplane collided with a truck located in the Hayward City Maintenance Center. In a telephone conversation with a National Transportation Safety Board investigator, the pilot stated that prior to departure he preformed a preflight inspection. During the inspection he strained fuel samples from both fuel tanks, noting no anomalies. He estimated that the left tank was about half full and the right tank was about 3/4 full. After takeoff, the airplane climbed to about 1,200 feet mean sea level (msl). The pilot maneuvered the airplane into a level attitude in an effort to remain below the 1,500-foot base of Oakland's class "C" airspace. The flight continued normally as the airplane approached the Hayward Hills, an area of high terrain separating Hayward from Livermore. Shortly thereafter, the engine quit. The pilot maneuvered the airplane back toward the Hayward airport and began troubleshooting the loss of power by switching fuel tanks with the boost pump remaining in the "on" position. The pilot further stated that despite his troubleshooting efforts, he could not restart the engine. With populated areas below, he opted to glide towards the airport and maintained an attitude to obtain the best glide speed of 85-90 knots. As the airplane approached the airport he realized that due to his low altitude, he would be unable to make it to the runway surface. He directed the airplane toward the only unpopulated area that he could discern, a vacant lot. The airplane collided with an unoccupied truck and he egressed. In a written statement, the Federal Aviation Administration (FAA) inspector, who responded to the accident, stated that he obtained copies of the air traffic control tapes. The tapes revealed that during the initial climb, the pilot reported to the air traffic controller that the airplane's canopy lock had become unlatched and he wanted to return to the airport. Shortly after the transmission he reported that the engine had quit. PERSONNEL INFORMATION According to the FAA airman and medical records, the pilot held a private pilot certificate with airplane ratings for single engine land and instrument flight. The pilot was issued a third-class medical certificate on November 25, 2003, with the limitation that corrective lenses be worn. A review of the pilot's personal flight records disclosed that the pilot's total flight time was about 1,724.5 hours, of which 4 hours were flown in the 90-day period preceding the accident. In a written report submitted to the Safety Board, the pilot indicated that his total hours flown in a Vans RV-6 were about 80 hours. AIRCRAFT INFORMATION A Safety Board investigator reviewed the airplane's Aircraft and Registry files which were maintained by the FAA. The experimental Vans RV-6 airplane, serial number 22305, was certificated by the builder in 1998. Both Phase 1 and Phase 2 limitations were issued on May 4, 1998. The accident pilot purchased the airplane from the builder on September 5, 2003. The engine logbooks revealed that the engine had undergone a major overhaul on January 17, 2005. A review of the airframe logbook disclosed that on November 1, 2004, at the engine tachometer time of 598.4 hours, the airplane was fitted with new fuel tanks (supplied by the pilot). Additional repair work was completed on the wings including replacement of leading edge skin. According to the mechanic who installed the fuel tanks, he delivered the wings to the pilot with the fuel tanks still open and did not flush out the fuel system. The repairs were made about 1.6 flight hours prior to the accident flight. The airplane's fuel system consists of two aluminum tanks located in the inboard section of both the left and right wing along the leading edge; both tanks have a capacity of 19 gallons. Fuel from the selected tank egresses via a 3/8-inch aluminum tube. The system is designed for the fuel to progresses down the fuel line, through a fuel filter, and continue into the fuel selector valve (located in the cockpit, enabling the pilot to select the "left", "right" or "off" position). The fuel continues from the selector through a single fuel line, passing through the electric auxiliary fuel pump, which is attached to the left sidewall of the cockpit near the pilot's rudder pedals. The fuel continues to the engine driven fuel pump and then onto the carburetor. The airplane was not equipped with a gascolator. The FAA records disclosed that the airplane was involved in a previous accident on July 16, 2004, at Reid Hillview Airport of Santa Clara County, San Jose, California. During the accident, the airplane impacted an airport perimeter fence after the pilot landed long during a precautionary landing. The airplane incurred damage to the wings. WRECKAGE AND IMPACT During a telephone conversation with a Safety Board investigator, the FAA inspector stated that he conducted an inspection of the airplane and engine. The inspector added that the fuel selector was set to the "off" position. His interview with a first responder revealed that the responder had turned to fuel selector to "off," but it was initially set to the "right" position when he arrived at the accident site. The responder also noted that about 38 gallons of fuel were removed from both wing tanks. The airplane came to rest on the main landing gear, with the nose gear bent back under the fuselage. The nose incurred impact damage and the propeller was bent aft. The inspector established fuel line continuity on the engine and noted that all the carburetor linkages were intact. The engine components were accounted for and appeared intact. The tachometer indicated a total time of 600 hours. The right wing was impact damaged, which appeared to have resulted from the leading edge striking a vacant truck. The right fuel tank was compromised. The left wing was intact and the fuel cap remained tightly sealed. The inspector did not find contamination in the left fuel tank. TESTS AND RESEARCH The FAA inspector preformed a detailed examination of the airplane and provided a written statement of his findings. He stated that while at the accident site, he removed the glass fuel filters from the airplane observing dark debris lining both filters. He thought that the contaminants appeared to block the outlet of the filters, prohibiting fuel to pass to the selector. An examination of the right filter revealed that it was remarkably covered with a thick debris layer. He manipulated the fuel selector's orientation in an effort to see if fuel could escape from either end. He noted that fuel could not egress from the outlet side (where fuel egresses from the filter to continue onto the fuel selector), but was able to pour from the inlet side (where the fuel normally enters the filter from the fuel tank). He performed the same test on the left filter and discovered that fuel could egr ## Aircraft - Registration: [N16TN](https://openairdocs.org/deregistered/N16TN-2005-09-29), registration cancelled 2005-09-29, S/N 22305, built 1998 (OpenAirDocs) - Reported make and model: Newell Thomas RV6-A - Registry model: [Newell Thomas J RV6A](https://openairdocs.org/model/newell-thomas-j-rv6a) (registry code 05605Z0) (OpenAirDocs) - Registry engine: [Lycoming 0-320 series](https://openairdocs.org/engine/lycoming-0-320-series) (registry code 41508, reciprocating) (OpenAirDocs) - Category: Airplane, amateur-built - Serial number: 22305 - Airframe hours: 600 - Engines: Lycoming O-360-A1D 180 horsepower reciprocating - Damage: Substantial damage - Flight: Personal, Part 91 - Airworthiness certificate: Special, Experimental (Special) - Last inspection: Condition, May 1, 2004, 19.2 hours before - Departed: HWD, Hayward, CA - Destination: LVK, Livermore, CA - Airport: HWD, Hayward Executive Airport, runway 28L, 5,024 × 150 ft, asphalt ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 70; injuries: serious; private; airplane ratings: single-engine land; instrument ratings: airplane; medical: class 3, valid medical--no waivers/lim.; last flight review April 1, 2004; flight hours: 1,724 total, 80 in this make and model, 1,566 as pilot in command, 4 in the last 90 days ## Weather - Conditions: Visual (VMC), Day - Wind: variable at 3 knots - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 52 °F, dew point 39 °F - Altimeter: 30.11 inHg - Observed at: HWD, 1 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20050412007259A](https://openairdocs.org/incident/20050412007259A), Apr 12, 2005: Amtr RV6A, Hayward, CA, Substantial damage. (-23) While investigating the cause of engine failure discovered the fuel flow to the engine was restricted. Found two inline fuel filters, installed between… ## Other investigations on N16TN (1) From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. - [NTSB LAX04LA269](https://openairdocs.org/ntsb/LAX04LA269), Jul 16, 2004: Newell RV-6A (N16TN), San Jose, CA, substantial damage. Probable cause: The pilot's misjudgment of the airplane's distance/speed during a precautionary landing, which resulted in the airplane overrunning the runway. Contributing factors were failure of an oil line, and… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.