# NTSB NYC06IA207: Boeing 737-524, N14655, Newark, NJ, August 21, 2006 - Type: NTSB incident investigation - Classification: Incident · No injuries · Incident investigation · Final report - Date: August 21, 2006, 06:30 local (10:30 UTC) - Place: Newark, NJ - Coordinates: 40.692501, -74.168609 - Nearby events: https://openairdocs.org/map.md?lat=40.6925&lon=-74.1686&mi=10 - Phase of flight: [Pushback/towing](https://openairdocs.org/ntsb-phases/200) (OpenAirDocs' grouping) - Highest injury: No injuries - Injuries: 1 uninjured - Status: Completed, report March 31, 2008 - Report: Approved by Office Director - Parties: Continental Airlines, FAA AAI-100, Boeing - NTSB case key (mKey): 64374 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=NYC06IA207 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/64374/pdf - Page: https://openairdocs.org/ntsb/NYC06IA207 ## Probable cause An overload failure of the airplane's nose landing gear while being towed for repositioning. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Nose gear collapsed, taxi - pushback/tow - landing gear,nose gear assembly - collapsed - landing gear,nose gear assembly - overload (cause) ## Analysis The Boeing 737 was being towed for repositioning by maintenance personnel, when the nose landing gear collapsed forward into the wheel well. The nose landing gear remained attached to the airplane by its primary trunnion support and upper drag brace. Metallurgical examination of the nose landing gear lower and upper drag braces, and lock brace, revealed no evidence of preexisting cracking, and that they failed due to overstress. Examination and testing of the nose landing gear steering components did not reveal any pre-incident malfunctions. The maintenance technician in the cockpit reported that he was "riding the brakes" at the time of the incident. The airplane maintenance manual stated that at a minimum, applying airplane brakes while towing the airplane could shear the towbar shear pins; however, there was no visible evidence on the ground that the airplane's brakes had been applied during the tow. After the incident, Boeing issued a service letter that discussed six previous reports of 737 nose landing gear collapse that occurred between 2004 to 2006 during pushback or towing. It also addressed current towbar design, and provided recommendations for operators intended to minimize the likelihood of nose gear damage or collapse during towing\pushback operations. ## Factual narrative On August 21, 2006, about 0630 eastern daylight time, a Boeing 737-524, N14655, operated by Continental Airlines Inc., experienced a nose landing gear collapse while being towed by maintenance personnel at the Newark Liberty International Airport (EWR), Newark, New Jersey. The airplane sustained minor damage. The maintenance technician seated in the cockpit, and two ground crew members were not injured. Visual meteorological conditions prevailed for the ground repositioning operation conducted by the 14 Code of Federal Regulations Part 121 certificated airline. According to the maintenance technician seated in the cockpit, he was "riding the brakes" while the airplane was being towed at walking speed, when he felt a bump, which was followed by the collapse of the nose landing gear. According to Continental Airlines representatives, the nose landing gear collapsed forward into the wheel well. The nose landing gear remained attached to the airplane by its primary trunnion support and upper drag brace. The lock brace assembly fractured in close proximity to the lock link. The lower drag brace was fractured near the center of its length. The tow bar shear pin was also fractured during the incident. The nose landing gear lock actuator, upper drag brace, lower drag brace, lock brace, and retract actuator were forwarded to the National Transportation Safety Board's Materials Laboratory, Washington, D.C., for further examination. All fractures were consistent with overstress separation and no evidence of fatigue cracking or any other preexisting conditions were found. The fracture on the lower drag brace exhibited deformation consistent with the fracture location moving downward relative to the ends. The bending deformation was consistent with the collapse of the gear following buckling of the lower drag brace. Examination and testing of the nose landing gear actuator assembly, lock actuator, left hand nose gear steering actuator, depressurization steering valve, and steering metering valve, which was supervised by a Safety Board investigator, did not reveal any pre-incident discrepancies. The 737-300/-400/-500 airplane maintenance manual, page 213, alerted operators, that at a minimum, applying airplane brakes while towing the airplane could shear the towbar shear pins. Examination of the ground surrounding the airplane after the incident did not reveal any main landing gear tire skid marks. After the incident, Boeing issued Service Letter 737-SL-09-003. The service letter discussed six previous reports of 737 nose landing gear collapse that occurred between 2004 to 2006 during pushback or towing. It also addressed current towbar design, and provided recommendations for operators intended to minimize the likelihood of nose gear damage or collapse during towing and pushback operations. ## Aircraft - Registration: [N14655](https://openairdocs.org/deregistered/N14655-2011-11-30), registration cancelled 2011-11-30, S/N 28916, built 1998 (OpenAirDocs) - Reported make and model: Boeing 737-524 - Registry model: [Boeing 737-524](https://openairdocs.org/model/boeing-737-524) (registry code 1384721) (OpenAirDocs) - Registry engine: [CFM International CFM56 series](https://openairdocs.org/engine/cfm-international-cfm56-series) (registry code 13802, turbo-fan) (OpenAirDocs) - Category: Airplane - Serial number: 28916 - Airframe hours: 22644 - Engines: CFM International CFM56-3 20100 lbs thrust turbo fan; CFM International CFM56-3 20100 lbs thrust turbo fan - Damage: Minor damage - Flight: Part 121 - Operator: Continental Airlines Inc - Registered owner: Continental Airlines Inc - Airworthiness certificate: Standard, Transport - Last inspection: Continuous airworthiness, July 1, 2006 - Airport: EWR, Newark Liberty ## Weather - Conditions: Visual (VMC), Day - Wind: 330° at 7 knots - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 70 °F, dew point 57 °F - Altimeter: 29.94 inHg - Observed at: EWR From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.