# NTSB NYC08FA023: Daniel R. Lloyd Trish's Ride Home, N289DT, Greenville, PA, November 2, 2007 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: November 2, 2007, 08:32 local (12:32 UTC) - Place: Greenville, PA - Coordinates: 41.457778, -80.373611 - Nearby events: https://openairdocs.org/map.md?lat=41.4578&lon=-80.3736&mi=10 - Phase of flight: [Maneuvering](https://openairdocs.org/ntsb-phases/450) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 1 fatal - Status: Completed, report September 30, 2009 - Report: Approved by Office Director - Parties: Eggenfellner Aircraft inc., SteinAir Inc., Quinti Avio S.R.L., Sensenich Propeller Manufacturing Company, Inc., FAA/FSDO - NTSB case key (mKey): 67003 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=NYC08FA023 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/67003/pdf - NTSB docket: https://data.ntsb.gov/Docket?ProjectID=67003 - Page: https://openairdocs.org/ntsb/NYC08FA023 ## Probable cause The pilot/builder's improper installation of the electrical system. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power(total) - nonmechanical, maneuvering - maintenance,calibration - not performed, owner/builder - flight/nav instruments - inaccurate - maintenance,installation - improper, owner/builder (cause) - electrical system,electric wiring - disconnected - Forced landing, descent - emergency - In flight collision with terrain/water, descent - emergency - terrain condition - ground ## Analysis Prior to a planned trip in the homebuilt airplane, the pilot/builder flew the airplane to assure that it was functioning properly. The airplane was observed to fly north on the east side of a state highway, and to make a circle to the left, approximately 500 feet above ground level (agl). The airplane then flew in a westerly direction, flew across the highway, then turned to the left while losing altitude. When it reached approximately 50 feet agl, while heading east, the airplane rolled wings level, impacted a cornfield, and a postimpact fire ensued. Examination of the wreckage revealed that the engine was not producing power at impact. Both the non-certificated 220 horsepower engine, and the propeller, required a source of electricity to operate. On the night before the accident, the pilot moved the airplane's batteries from behind the baggage compartment to the forward cabin to change the center of gravity and re-wired the batteries into the electrical system. Examination of the electrical system revealed that a cable had become disconnected from an improperly crimped terminal. ## Factual narrative HISTORY OF FLIGHT On November 2, 2007, at 0832 eastern daylight time, an experimental amateur-built Vans RV-10, N289DT, was substantially damaged when it impacted terrain near Greenville, Pennsylvania. The private pilot/builder was fatally injured. Day visual meteorological conditions prevailed for the local flight that departed Greenville Municipal Airport (4G1), Greenville, Pennsylvania. No flight plan was filed for the personal flight conducted under 14 Code of Federal Regulations (CFR) Part 91. According to a family member, the pilot had driven to the airport to practice "touch and go's" and to make sure everything was functioning properly, prior to a planned afternoon trip in the airplane with his family to Boston, Massachusetts. Witness interviews were conducted by the Federal Aviation Administration (FAA) and the Safety Board, and while no one saw the airplane depart 4G1, the airplane was observed by a witness at approximately 0800 traveling in a northwesterly direction at low altitude, moving "fast" and sounding like it was "running strong like a Ford Mustang (turbocharged) Cobra that the witness once owned." At approximately 0825, the airplane was again observed; this time by multiple witnesses. Descriptions varied between witness statements as to the altitude, direction of flight, and velocity of the airplane; however, the preponderance of witness statements were that the airplane was flying north on the east side of Pennsylvania State Route 58, and seemed to make a circle to the left at approximately 500 feet above ground level (agl). It was next observed to travel in a westerly direction, fly across Route 58 and make another turn to the left with the engine "revving up and down" and losing altitude. When it reached approximately 50-feet agl, heading east, the airplane rolled wings level and impacted a cornfield and a fireball erupted. PERSONNEL INFORMATION The pilot held a private pilot certificate, with a rating for airplane single engine land. His most recent FAA third class medical certificate was issued on March 14, 2006. According to his pilot logbook, he had accrued 221.4 total hours of flight experience. AIRCRAFT INFORMATION The experimental amateur-built airplane, was a four place, low wing monoplane. It was equipped with a non-certificated Eggenfellner E6T/220, water cooled, fuel injected, turbo-charged, 220 horsepower, six cylinder engine. The airplane's special airworthiness certificate was issued on July 10, 2007. METEOROLOGICAL INFORMATION A weather observation taken about 23 minutes after the accident at Port Meadville Airport (GKJ), Meadville, Pennsylvania, located about 14 nautical miles northeast of the accident site, recorded the winds as 090 degrees at 4 knots, visibility 10 miles, sky clear, temperature 1 degree Celsius, dew point -2 degrees Celsius, and an altimeter setting of 30.36 inches of mercury. WRECKAGE AND IMPACT INFORMATION Examination of the accident site by an FAA inspector revealed that a post impact fire had ensued. The airplane had come to rest inverted on route 58. Further examination of the accident site revealed that the airplane had impacted in a 35 to 60 degree nose down attitude. An approximately 100-foot debris path extended from the point of impact in the cornfield to the shoulder of Route 58. The left wing was bent aft at the root with evidence of aft bending along the length of the wing panel. The right wing exhibited compression damage in an aft direction from the wingtip inboard, for approximately one third of its length. The empennage was intact but was partially separated from the fuselage just aft of the rear window location, lying forward of the left wing tip, and was found inverted from its normal mounting position. The engine and firewall were separated from the fuselage and the majority of the hoses and belts had been consumed or were heavily fire damaged. Three of the four composite propeller blades were found at the initial impact point and one was found under the main wreckage. Post recovery examination of the wreckage by the National Transportation Safety Board revealed no evidence of any preimpact failures of the airframe. The doors were closed and latched during the impact sequence, the structure had experienced heavy impact damage and tumbling, and the upper and lower baggage bulkheads were missing. Engine Examination Examination of the engine, and propeller speed reduction unit (PSRU), revealed no evidence of any preimpact mechanical malfunctions. Both engine timing chains were intact, the crankshaft was rotated by hand, and drive train continuity was confirmed. The PSRU contained oil, and rotated freely. Compression was obtained on all cylinders. Oil was present throughout the lubrication system. The intake and exhaust systems were compromised and exhibited breaks in the tubing. The turbocharger waste gate was closed and the turbocharger could be rotated by hand. All of the sparkplugs were intact. Propeller System Examination The airplane was equipped with a 4-blade, in-flight adjustable, constant speed propeller. It consisted of an electric variable pitch hub manufactured by Quinti Avio, which was mated to the composite propeller blades manufactured by Sensenich. Examination of the propeller hub and the remains of the propeller blades revealed no evidence of preimpact mechanical malfunction. Further examination of the propeller assembly revealed that the four composite propeller blades were separated at the 4-inch blade radius station, which corresponded to the positions of the hub barrel clamps. Examinations of the blade surfaces indicated that the blades were not in rotation at time of impact. The electric pitch control motor end bell and exterior nylon slide exhibited severe melting. The blade retention nuts were also found tightened approximately 1/4 inch tighter than the index marks scribed on the hub. This however, did not appear to affect the pitch rotation friction. Disassembly of the propeller hub revealed that the pitch motor gearbox was intact and immobile, (as designed) and held the last pitch angle selected when under no electrical load. Examination of the blade shank assemblies, bearings, and pitch slide assembly revealed no anomalies, and measurements of the propeller pitch setting corresponded to a high pitch (cruise) setting. Examination of the propeller control Examination of the propeller controller revealed that it was not the propeller controller that was manufactured by the propeller manufacturer. Instead, a manual electric pitch change system had been installed that consisted of a double pole panel mounted switch that could change the polarity to the electric hub motor. The motor could either run clockwise or counterclockwise from fine to coarse pitch. It was incapable of monitoring propeller rpm, and could not maintain the propeller at a constant speed by automatically varying blade pitch angle. Fuel System Examination Examination of the fuel system revealed that all fuel filler caps were closed and latched and the fuel selector valve was in the right fuel tank position. Instrument Panel Examination Examination of the instrument panel revealed that the airplane was equipped with a dual screen Chelton Flight Systems Electronic Flight Information System (EFIS), A Dynon Avionics D10A backup EFIS, Dual Garmin SL-30 navigation and communication radios, a Garmin 496 Global Positioning System (GPS), and a Grand Rapids Technologies Engine Information System (EIS) monitor. Further examination revealed that the panel switches were positioned for flight. The "X-TIE" switch was in the off position, The "FUEL" switch was in the "ON" position, the "IGNITION" switch was in the "ON" position, the "FUEL SELECTOR" (electric fuel pumps) switch was in the "MAIN" position, and the "BUSS SELECTOR" switch was in the "ON/MAIN" position. Flight Control System Examin ## Aircraft - Registration: [N289DT](https://openairdocs.org/deregistered/N289DT-2009-12-18), registration cancelled 2009-12-18, S/N 40269, built 2007 (OpenAirDocs) - Reported make and model: Daniel R. Lloyd Trish's Ride Home - Registry model: [Lloyd Daniel R TRISH'S RIDE HOME](https://openairdocs.org/model/lloyd-daniel-r-trish-s-ride-home) (registry code 05622HF) (OpenAirDocs) - Registry engine: [Amateur-built UNKNOWN ENG](https://openairdocs.org/engine/amateur-built-unknown-eng) (registry code 99999) (OpenAirDocs) - Category: Airplane, amateur-built - Serial number: 40269 - Engines: Eggenfellner Aircraft Inc. E6T/220 220 horsepower reciprocating - Damage: Destroyed - Fire: On-Ground - Flight: Personal, Part 91 - Airworthiness certificate: Special, Experimental (Special) - Last inspection: Condition, July 10, 2007 - Departed: 4G1, Greenville, PA - Destination: 4G1, Greenville, PA - Airport: 4G1, Greenville Municipal Airport ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 37; injuries: fatal; private; airplane ratings: single-engine land; medical: class 3, without waivers/limitations; last flight review March 14, 2006; seat: left; toxicology performed; flight hours: 221 total ## Weather - Conditions: Visual (VMC), Day - Wind: 90° at 4 knots - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 34 °F, dew point 28 °F - Altimeter: 30.36 inHg - Observed at: GKJ, 14 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20071102827049A](https://openairdocs.org/incident/20071102827049A), Nov 2, 2007: Amtr TRISHSRIDE, Greenville, PA, Destroyed, 1 fatal. (-23) On November 2, 2007, at approximately 08:35, a vans RV-10 amateur built experimental aircraft, U.S. Registered N289DT, crashed onto route 58 in… ## Docket (24 files) The files NTSB released with the investigation on June 16, 2009, on NTSB's docket system: https://data.ntsb.gov/Docket?ProjectID=67003. 37.8 MB in all. - Witness Statements and Interview Summaries (item 1, .PDF, 769 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313075&FileExtension=.PDF&FileName=Witness%20Statements%20and%20Interview%20Summaries-Redacted.PDF - GPS Data (item 2, .PDF, 1.9 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313641&FileExtension=.PDF&FileName=GPS%20Data-Master.PDF - Weather Report (item 3, .PDF, 25 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313076&FileExtension=.PDF&FileName=Weather%20Report-Master.PDF - RV-10 Three View Drawing (item 4, .PDF, 19 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313077&FileExtension=.PDF&FileName=RV-10%20Three%20View%20Drawing-Master.PDF - Wiring Diagram (item 5, .PDF, 44 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313079&FileExtension=.PDF&FileName=Wiring%20Diagram-Master.PDF - Excerpts From Airplane Maintenance Logbook (item 6, .PDF, 13.4 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313081&FileExtension=.PDF&FileName=Excerpts%20From%20Airplane%20Maintenance%20Logbook-Redacted.PDF - Eggenfellner Aircraft Service Bulletin (item 7, .PDF, 251 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313082&FileExtension=.PDF&FileName=Eggenfellner%20Aircraft%20Service%20Bulletin-Master.PDF - Weight and Balance As Submitted to FAA (item 8, .PDF, 133 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313083&FileExtension=.PDF&FileName=Weight%20and%20Balance%20As%20Submitted%20to%20FAA-Master.PDF - Experimental Operating Limitations (item 9, .PDF, 194 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313084&FileExtension=.PDF&FileName=Experimental%20Operating%20Limitations-Redacted.PDF - Excerpts From Sensenich Propeller Examination Report (item 10, .PDF, 88 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313085&FileExtension=.PDF&FileName=Excerpts%20From%20Sensenich%20Propeller%20Examination%20Report-Redacted.PDF - Toxicological Report (item 11, .PDF, 58 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313088&FileExtension=.PDF&FileName=Toxicological%20Report-Redacted.PDF - Statement of Party Representatives to NTSB Investigation (item 12, .PDF, 126 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313086&FileExtension=.PDF&FileName=Statement%20of%20Party%20Representatives%20to%20NTSB%20Investigation-Redacted.PDF - Release of Aircraft Wreckage, NTSB Form 6120.15 (item 13, .PDF, 70 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313087&FileExtension=.PDF&FileName=Release%20of%20Aircraft%20Wreckage,%20NTSB%20Form%206120.15-Redacted.PDF - Excerpted Email From Van's Air Force Builders Website (item 14, .PDF, 297 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313089&FileExtension=.PDF&FileName=Excerpted%20Email%20From%20Van%27s%20Air%20Force%20Builders%20Website-Master.PDF - Photographs from First Flight - Matronics (item 15, .PDF, 4.7 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313090&FileExtension=.PDF&FileName=Photographs%20from%20First%20Flight%20-%20Matronics-Master.PDF - Photograph of Instrument Panel Prior to Delivery - SteinAir (item 16, .PDF, 1.8 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313091&FileExtension=.PDF&FileName=Photograph%20of%20Instrument%20Panel%20Prior%20to%20Delivery%20-%20SteinAir-Master.PDF - Photograph of Chelton EFIS (Display Warnings) - Matronics (item 17, .PDF, 3.1 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313092&FileExtension=.PDF&FileName=Photograph%20of%20Chelton%20EFIS%20(Display%20Warnings)%20-%20Matronics-Master.PDF - Photograph of Chelton EFIS Displaying 2340G - Matronics (item 18, .PDF, 2.6 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313093&FileExtension=.PDF&FileName=Photograph%20of%20Chelton%20EFIS%20Displaying%202340G%20-%20Matronics-Master.PDF - Photograph of Accident Airplane with Two of the Four Propeller Blades Removed - SteinAir (item 19, .PDF, 2.6 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313094&FileExtension=.PDF&FileName=Photograph%20of%20Accident%20Airplane%20with%20Two%20of%20the%20Four%20Propeller%20Blades%20Removed%20-%20SteinAir-Master.PDF - Photograph of Main Wreckage - FAA (item 20, .PDF, 855 KB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313642&FileExtension=.PDF&FileName=Photograph%20of%20Main%20Wreckage%20-%20FAA-Master.PDF - Photograph of Rudder Trim Tab - NTSB (item 21, .PDF, 1.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313643&FileExtension=.PDF&FileName=Photograph%20of%20Rudder%20Trim%20Tab%20-%20NTSB-Master.PDF - Photograph of Right Trim Tab Rod End - NTSB (item 22, .PDF, 1.3 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313644&FileExtension=.PDF&FileName=Photograph%20of%20Right%20Trim%20Tab%20Rod%20End%20-%20NTSB-Master.PDF - Photograph of Pitch Control System Lock Nuts - NTSB (item 23, .PDF, 1.2 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313645&FileExtension=.PDF&FileName=Photograph%20of%20Pitch%20Control%20System%20Lock%20Nuts%20-%20NTSB-Master.PDF - Photograph of Contactor Relay Terminal - NTSB (item 24, .PDF, 1.1 MB): https://data.ntsb.gov/Docket/Document/docBLOB?ID=40313646&FileExtension=.PDF&FileName=Photograph%20of%20Contactor%20Relay%20Terminal%20-%20NTSB-Master.PDF From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.