# NTSB NYC93FA145: Curtiss-Wright Travel AIR 4000, Marlboro, NJ, August 7, 1993 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: August 7, 1993, 18:50 local (22:50 UTC) - Place: Marlboro, NJ - Location: 39.4871° N, 75.3246° W: Placed by OpenAirDocs: center of Marlboro, NJ, within about 6 miles (OpenAirDocs) - Nearby events: https://openairdocs.org/map.md?lat=39.4871&lon=-75.3246&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 2 fatal, 1 serious - Status: Completed, report September 13, 1994 - Report: Approved by Office Director - NTSB case key (mKey): 38587 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=NYC93FA145 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/38587/pdf - Page: https://openairdocs.org/ntsb/NYC93FA145 ## Probable cause The loss of engine power for undetermined reasons, and the pilot's failure to maintain adequate airspeed, which resulted in an inadvertent stall and inflight collision with the terrain. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power, climb - reason for occurrence undetermined (cause) - Forced landing, descent - emergency - Loss of control - in flight, maneuvering - turn to landing area (emergency) - airspeed - not maintained, pilot in command (cause) - stall - inadvertent, pilot in command (contributing factor) - In flight collision with terrain/water, descent - emergency ## Analysis THIS FLIGHT WAS THE NINTH SIGHTSEEING FLIGHT OF THE DAY FOR THIS AIRPLANE AND PILOT. NO PROBLEMS HAD BEEN REPORTED ON THE EARLIER FLIGHTS. AFTER TAKEOFF AND AT AN ALTITUDE OF APPROXIMATELY 150 FEET, THE ENGINE LOST POWER AND IT BEGAN TO SPUTTER. THE PILOT INITIATED A LEFT TURN TO LAND ON A FIELD NORTH OF THE AIRPORT. DURING THIS TURN, THE PILOT LOST CONTROL OF THE AIRPLANE, AND IT IMPACTED THE GROUND IN ANOSE LOW ATTITUDE. A POST-IMPACT FIRE DESTROYED THE AIRPLANE AND SEVERELY BURNED THE ENGINE. AN EXAMINATION OF THE ENGINE REVEALED NO DISCREPANCIES. ## Factual narrative HISTORY OF FLIGHT On Saturday, August 7, 1993, at 1850 eastern daylight time, a Curtis-Wright Travel Air 4000, NC365M, operated by Biplane Adventure Tours, Ltd., and piloted by Michael E. Flakker, was destroyed by a post-impact fire, after a forced landing near the Marlboro Airport, Marlboro, New Jersey. The pilot was seriously injured, and the two passengers were fatally injured. Visual meteorological conditions prevailed, and no flight plan was filed. The flight was being conducted under 14 CFR 91. This was a sightseeing flight, with the pilot occupying the rear cockpit, and the two passengers sharing an oversized seat in the front cockpit. The pilot stated in his report: I completed my pre-takeoff check....I began rolling eastbound [runway 09]....The main wheels lifted off at what felt to be the normal speed and I began climbing out at 70 mph. Still at full power, I reached approximately 100 to 150 feet. There was no indication of impending problem. Then suddenly, without warning, the engine quit. The silence was deafening....I thought immediately of the clearing to the left. In front of me was a house, multiple trees, a highway and electrical wires along the highway. I turned left in an attempt to make an emergency landing in the clearing in the soybean field. In his report he continued: In the turn, I explicitly remember closing the throttle and reopening it, in an attempt to make something happen....I attempted to flare....the airplane did not respond to my pulling the stick all the way back. The pilot was interviewed on August 11, 1993. He said that he had flown about eight sightseeing flights that day. This was the last one and was scheduled for about 15 minutes duration. The passengers boarded the airplane with the engine running. He taxied down the runway for the run-up. He said that he had experienced no difficulties with the engine on the previous flights. He performed the run-up, and everything was "normal." After becoming airborne, the engine just quit, with no sputter. He thought the propeller might have been windmilling. He said that he pushed the throttle and mixture full forward, but no change occurred. Mr. Edward Del Rosso, the owner of the airplane, was a witness to the accident. He stated: I watched it go past my hangar and out over the field...It was about 200' or more when I heard the engine sputter for a second or two and come back on. For about 3 seconds it remained on heading and in level flight. The it abruptly pulled up into a tight...climbing turn to the left....About halfway through the 180 degree turn, the nose dropped through the horizon still turning to the left, over the trees and out of sight. Ms. Kathryn Volk witnessed the accident, and she stated: I saw a biplane taking off from the runway. It was almost above the trees when I heard a pop and the engine stalled. The engine was not running any more and the plane began to drop and go to the left sharply. Another witness, Mr. David Krug, a pilot for Biplane Adventures, Ltd., stated, "[The] airplane took off...got to 50 to 100 feet and [the] engine sputtered and quit..." Brian W. Mulqueen stated: I am a flight instructor at Marlboro Airport... I was watching the airplane take off...About 50 feet above the tree top level, I heard a noise from the engine and a substantial loss of RPM. The aircraft pitched up and turned rapidly to the left... Mr. Russell Potoski also witnessed NC365M take off, and he said in a telephone interview: After becoming airborne and at approximately one hundred to two hundred feet, the engine became quiet, then a bang occurred, followed by a pop and sputter. Mr. Robert Chesnowitz stated that he did not see NC365M take off, but he did hear the engine "sputter and miss." He then looked at the airplane....He saw the airplane turn left...it looked like a "stall or spin" before hitting the ground. He did not think the airplane could have glided to the field straight ahead. Mr. Dennis Heucke and his wife were passengers on the flight prior to the accident. They both stated that on their flight, the engine sounded "normal." Mr. Heucke said that they also witnessed the takeoff of NC365M on the accident flight. He said that the engine began to "sputter and kept sputtering throughout the left turn." The accident occurred during the hours of daylight, at about 40 degrees, 22 minutes North; 74 degrees, 15 minutes West. AIRCRAFT INFORMATION NC365M was a vintage biplane produced in 1929. The last maintenance inspection of this airplane was a 100 hour inspection performed on July 19, 1993. The airplane had accumulated approximately 70 hours since that inspection. The airplane was approved for the use of autogas under a Supplemental Type Certificate (STC). The Petersen Aviation, Inc., specifications stated that a mixture of 25%, 100 low lead aviation gas and 75% unleaded autogas should be used in this radial engine to comply with this STC. Company records showed that the airplane had been refueled four times that day, with the last refueling four flight prior to the accident flight. The airplane's single fuel tank had a capacity of 42 gallons, and the company's policy was to fill the tank at each refueling. It was estimated that at the time of the accident, the fuel tank contained approximately 15 gallons of fuel. Fuel samples were obtained from the tender from which NC365M was refueled, and in which the mixture described above was blended by the operator. Also obtained was a sample of fuel from the service station from which the autogas was obtained. These samples revealed no evidence of contamination. Also, other airplanes had used the same fuel tender during that day without any reported problems. PERSONNEL INFORMATION Mr. Michael E. Flakker held a Commercial Pilot Certificate, with single and multi-engine land, instrument airplane ratings. He also held a current Flight Instructor Certificate. His most recent First Class Airman Medical Certificate was issued on July 26, 1993. He reported his total flight time as 2636 hours, which was broken down as follows: Total time in the Travel Air 336 hours Total time in last 90 days 385 hours Total time in last 30 days 134 hours WRECKAGE The wreckage was examined at the accident site on August 8, 1993. The examination revealed an impact mark on the ground approximately 18 feet from the main wreckage, which came to rest on a magnetic heading of 190 degrees. The left wing tips of the bi-plane were crushed and burned. The fuselage was destroyed by post-impact fire. The empennage was intact. All flight controls were accounted for and continuity was established to the rudder and elevator. The aileron control tubes were destroyed by impact and fire and continuity could not be established. The single fuel tank, which was located in front of the forward cockpit instrument panel, was ruptured and empty. The reserve tank baffle had been displaced. All cockpit instruments and switches were destroyed by post- impact fire. The engine was attached to the firewall, and there was a visible fracture of the case in the bottom of the engine. The engine was subjected to fire damage, particularly to the accessory section. The carburetor was broken from ## Aircraft - Registration: NC365M (not matched to a registry record) - Reported make and model: Curtiss-Wright TRAVEL AIR 4000 (TRAVEL AIR) - Category: Airplane - Serial number: 1297 - Airframe hours: 6276 - Engines: CONTINENTAL W670-6A 220 horsepower reciprocating - Damage: Destroyed - Fire: On-Ground - Flight: Part 91 - Operator: Biplane Adventure Tours, Ltd. - Registered owner: Edward Del Rosso - Airworthiness certificate: Standard, Normal - Last inspection: Annual, July 19, 1993, 70 hours before - Departed: 2N8 - Airport: 2N8, Marlboro, runway 9, 2,156 × 40 ft, macadam ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 31; commercial, flight instructor; airplane ratings: multi-engine land, single-engine land; instrument ratings: airplane; medical: class 1, valid medical--no waivers/lim.; seat: rear; flight hours: 2,636 total, 336 in this make and model, 2,516 as pilot in command, 385 in the last 90 days, 134 in the last 30 days, 5 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 79 °F, dew point 63 °F - Altimeter: 30.00 inHg From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.