# NTSB NYC98FA117: Morelli Rans S9, N1189Z, Taunton, MA, May 26, 1998 - Type: NTSB accident investigation - Classification: Accident · Fatal · Field investigation · Final report - Date: May 26, 1998, 18:45 local (22:45 UTC) - Place: Taunton, MA - Location: 41.8706° N, 70.9964° W: Placed by OpenAirDocs from NTSB’s distance and direction from TAUNTON MUNI/KING FLD (TAN), within about a mile (OpenAirDocs) - Nearby events: https://openairdocs.org/map.md?lat=41.8706&lon=-70.9964&mi=10 - Phase of flight: [Maneuvering](https://openairdocs.org/ntsb-phases/450) (OpenAirDocs' grouping) - Highest injury: Fatal - Injuries: 1 fatal - Status: Completed, report June 21, 2000 - Report: Approved by Office Director - NTSB case key (mKey): 46076 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=NYC98FA117 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/46076/pdf - Page: https://openairdocs.org/ntsb/NYC98FA117 ## Probable cause The pilot's operation of the aircraft in an unapproved configuration contrary to procedures resulting in diminished aircraft control, and his failure to maintain control of the aircraft resulting in a stall/spin event. Contributing factors were the non-installation of the canopy and engine cowling during flight. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of control - in flight, maneuvering - window,canopy - not installed (contributing factor) - nacelle/pylon,fairing - not installed (contributing factor) - procedures/directives - not followed, pilot in command (cause) - aircraft control - diminished - stall/spin - aircraft control - not maintained, pilot in command (cause) - In flight collision with terrain/water, descent - uncontrolled ## Analysis The pilot had been making adjustments to the carburetors on the 2 cycle, non-certificated engine. He was flying the homebuilt airplane without the engine cowling or canopy in place. While circling near the airport, the airplane was observed to enter a spin and it disappeared from view in a near vertical nose down attitude. No evidence of a mechanical failure or malfunction was found with the airplane or engine. The Chief Engineer for the kit manufacturer reported, '...The flying qualities would have been altered due to the large increase in drag and disruption of the airflow over the fuselage and tail surfaces. The aircraft stall and spin characteristics could have been dramatically changed from previously tested configurations. The assembly manual and flight operations manuals clearly indicate that the cowl and canopy should be in place before flying the aircraft and that operation of the aircraft in any other configuration is not approved.' ## Factual narrative HISTORY OF FLIGHT On May 26, 1998, about 1845 eastern daylight time, a homebuilt Rans S9, N1189Z, was destroyed when it struck a tree in Massasoit State Park, Taunton, Massachusetts. The certificated private pilot was fatally injured. Visual meteorological conditions prevailed for the local post maintenance flight, which had departed from Taunton, Massachusetts. No flight plan had been filed for the flight that was conducted under 14 CFR Part 91. According to an inspector from the Federal Aviation Administration (FAA), the pilot was observed to adjust the carburetors and fuel metering jets on the engine after two preceding flights. He then departed on the third flight which terminated in the accident. One witness reported: "Small homebuilt aircraft passed over my home at about 1000 feet altitude from west to east. Aircraft attracted my attention due to high pitch of engine. Aircraft made an oval out over Massasoit State Park and back over my neighborhood. Watched aircraft make a 720 degree turn out over Massasoit State Park...Direction was counterclockwise, appx. angle of bank 30-45 degrees. As aircraft came around I noticed it drop abruptly 50-100 feet as it stalled. It then seemed to enter a spin and it disappeared from view in a near vertical nose down attitude. Spin rotation was to the left. Very loud impact sound soon followed. Altitude as [airplane] disappeared from view appx. 500 - 600 feet AGL." In a follow-up telephone interview, the witness reported that he could hear the engine of the airplane when it passed over him, but that due to distance from the airplane when it entered the spin, he could not hear if the airplane engine was operating. He said the spin entry was abrupt, and not preceded by a change in airplane attitude. Another witness saw the airplane circling overhead and also heard the engine. He reported that the engine stopped and a few seconds later he heard an impact noise. The local police were notified, and the airplane was found after a few minutes in a densely wooded area, about 1/2 mile from the approach end of runway 30. The accident occurred during the hours of daylight at 41 degrees, 52.21 minutes north latitude and 70 degrees, 59.94 minutes west longitude. PERSONNEL INFORMATION The pilot held a private pilot certificate with an airplane single engine land rating. The pilot's logbook was not recovered. According to FAA records, the pilot's total flight time was in excess of 900 hours. He was issued a restricted third class FAA airman medical certificate on February 4, 1998, that was valid for 12 months. He was also required to wear corrective lenses. He was also issued a repairman certificate for his homebuilt airplane. The repairman certificate allowed him to perform maintenance on the airplane that would normally have required a mechanics certificate. WRECKAGE AND IMPACT INFORMATION On-site examination of the wreckage revealed impact marks on the east side of a 75 foot high tree, and debris to the west of the tree on the ground. The engine was separated from the firewall and remained attached to the airplane with the starter pull chord. Both wings had separated from the fuselage, and both fiberglass fuel tanks were ejected from their wings. About 1 quart of gasoline was observed in one fuel tank. No evidence of the engine cowling or canopy was found at the accident site. The airplane was moved to the pilot's hangar at Taunton Airport for further examination. The engine cowling and canopy for the airplane were found there. The engine was rotated by hand and compression was found in both cylinders. No evidence of scoring was visible on the sides of the pistons, as viewed through the exhaust ports. The spark plugs had oil on the electrodes, and produced spark when placed in a spark plug tester. Fuel was found in the fuel line leading to the engine driven fuel pump. The fuel selector had been turned off by emergency personnel at the accident site. The pilot had installed a ground adjustable wooden propeller. Both blades were broken off flush with the hub. Flight control continuity was verified to the rudder and elevator. The aileron control cables were intact at the fuselage and separated from the wings. The airplane had accumulated a total time of 11.3 hours at the time of the accident. MEDICAL AND PATHOLOGICAL INFORMATION Toxicological testing was conducted by the FAA Toxicology Accident Research Laboratory, Oklahoma City, Oklahoma. An autopsy was conducted at the Massachusetts Regional Medical Examiner's Office in Pocasset, Massachusetts, on May 27, 1998. TESTS AND RESEARCH One carburetor remained on the engine and the other was recovered at the accident site. Examination of the carburetors at LEADING EDGE AIR FOILS, INC. revealed no deficiencies. The carburetor synchronization could not be determined due to the separation of one carburetor from the engine. ADDITIONAL INFORMATION The airplane was mid-wing design with conventional landing gear. It was fitted with a two cylinder, air-cooled Bombardier Rotax 503 UL DCDI, two stroke, non-certificated engine. According to a letter from the Chief Engineer of RANS, the kit designer: "The Rans S-9 constructed by...[the pilot] was operated in a configuration untested by the kit manufacturer." "The aircraft was flown without the engine cowling and canopy in place. The flying qualities would have been altered due to the large increase in drag and disruption of the airflow over the fuselage and tail surfaces. The aircraft stall and spin characteristics could have been dramatically changed from previously tested configurations." "The assembly manual and flight operations manuals clearly indicate that the cowl and canopy should be in place before flying the aircraft and that operation of the aircraft in any other configuration is not approved." The airplane was released to the next of kin on May 28, 1998. ## Aircraft - Registration: [N1189Z](https://openairdocs.org/deregistered/N1189Z-2000-03-31), registration cancelled 2000-03-31, S/N 1291103 (OpenAirDocs) - Reported make and model: MORELLI RANS S9 - Registry model: [Morelli Dennis S RANS S-9 CHAOS](https://openairdocs.org/model/morelli-dennis-s-rans-s-9-chaos) (registry code 05604LR) (OpenAirDocs) - Category: Airplane, amateur-built - Serial number: 1291103 - Airframe hours: 11 - Engines: Rotax 503 47 horsepower reciprocating - Damage: Destroyed - Flight: Part 91 - Registered owner: Dennis S. Morelli - Airworthiness certificate: Special, Experimental (Special) - Last inspection: Annual, November 1, 1997, 11 hours before - Departed: TAN - Airport: TAN, Taunton ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 50; private; airplane ratings: single-engine land; medical: class 3, valid medical--w/ waivers/lim; seat: center; toxicology performed; flight hours: 900 total, 11 in this make and model ## Weather - Conditions: Visual (VMC), Day - Wind: calm - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 75 °F, dew point 50 °F - Altimeter: 29.00 inHg - Observed at: TAN, 1 nm away ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 19980526010789A](https://openairdocs.org/incident/19980526010789A), May 26, 1998: Amtr RANSS9, Taunton, MA, Destroyed, 1 fatal. Acft struck trees and crashed in the massasoit state park, pilot suffered fatal inj, acft was destroyed. (-23) Mr. Morelli was observed to have been performing… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.