# NTSB SEA00LA119: Piper PA-28-140, N6887W, Kennewick, WA, June 30, 2000 - Type: NTSB accident investigation - Classification: Accident · Minor injuries · Limited investigation · Final report - Date: June 30, 2000, 11:44 local (18:44 UTC) - Place: Kennewick, WA - Coordinates: 46.21014, -119.160369 (estimated) - Nearby events: https://openairdocs.org/map.md?lat=46.2101&lon=-119.1604&mi=10 - Phase of flight: [Enroute](https://openairdocs.org/ntsb-phases/400) (OpenAirDocs' grouping) - Highest injury: Minor injuries - Injuries: 1 minor, 1 uninjured - Status: Completed, report July 2, 2001 - Report: Approved by Office Director - NTSB case key (mKey): 49571 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=SEA00LA119 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/49571/pdf - Page: https://openairdocs.org/ntsb/SEA00LA119 ## Probable cause A failure in the engine's number 1 piston, resulting in a total loss of engine power. Factors included the aircraft windshield being covered with oil (restricting forward visibility), a road sign, and a ditch beside the road on which the forced landing was performed. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of engine power(total) - mech failure/malf, cruise - engine assembly,piston - failure (cause) - Forced landing, emergency descent/landing - On ground/water collision with object, emergency landing - window,flight compartment window/windshield - foreign material/substance (contributing factor) - object - sign (contributing factor) - clearance - not maintained - directional control - not possible - terrain condition - ditch (contributing factor) ## Analysis About 30 minutes after takeoff, while cruising at 6,500 feet, the engine began to lose RPM and subsequently stopped. The pilot was able to restart the engine, but oil then started coming from under the cowling. The pilot shut the engine down and performed a forced landing on a road. As the windshield was covered with oil, the pilot's forward visibility was impaired during the forced landing. During the landing roll, the aircraft's left wing struck a road sign that the pilot could not see, causing the aircraft to leave the road. The aircraft came to rest in a ditch beside the road. A post-accident examination of the aircraft's engine revealed damage to the number 1 piston, with the wrist pin brass plug missing. A hole in the top of the engine crankcase was also observed at this location, which the examination report stated was 'probably caused by [the] brass plug being pushed out by [the] crank shaft lobe.' The engine, a Lycoming O-320-E2A, had 1,649 hours since overhaul at the time of the accident and had received an annual signoff 8 months and 27 flight hours before the accident. ## Factual narrative On June 30, 2000, approximately 1144 Pacific daylight time, a Piper PA-28-140 airplane, N6887W, was substantially damaged in a forced landing on interstate highway 82 (I-82) approximately 5 miles southwest of Kennewick, Washington. The private pilot-in-command received minor injuries in the accident; a passenger aboard the aircraft was uninjured. The 14 CFR 91 personal flight from Walla Walla, Washington, was en route to an intended destination of Hood River, Oregon at the time of the occurrence. Visual meteorological conditions prevailed, and the flight was on a visual flight rules (VFR) flight plan. The pilot reported that about 30 minutes after takeoff, while cruising at 6,500 feet above mean sea level, the engine started to lose RPM. He stated that he adjusted the mixture and checked fuel pressure, oil pressure and "engine heat" (stating that all were normal), but that the RPM continued to drop and the engine stopped. The pilot stated that he went through his emergency check and found everything normal, then tried to restart the engine. He stated that the engine did restart, but that oil started coming out of the cowling. He reported that to avoid the possibility of an engine fire, he then shut down the engine and turned the fuel pump off. He reported that he called the Walla Walla tower and told them that he had an engine failure, and that he was going to attempt a forced landing, passing his position and setting his transponder to 7700. He stated: I found a road that looked like my best option and began to set the plane up for an emergency landing. The oil was continuing to come out and was covering the windshield obscuring my vision. I was able to land the plane on the road, but had little or no visibility out the front. My left wing hit a road sign, which I could not see, causing the plane to leave the road and come to rest in a ditch beside the road. The pilot supplied copies of the engine logbook indicating that the engine, a Lycoming O-320-E2A, last received an annual inspection signoff on October 17, 1999, at 1,622 hours since overhaul. The pilot reported that the engine had flown 27 hours since this inspection. Textron Lycoming service instructions give the manufacturer's recommended time between overhauls (TBO) of this engine as 2,000 hours. A post-accident disassembly examination of the engine was conducted by Bergstrom Aircraft, Inc., Pasco, Washington, at the request of the NTSB. Bergstrom Aircraft's report of the examination findings (work order number 6424, July 3, 2000, attached) stated that upon removal of the engine's number 1 cylinder, they found piston damage, with the wrist pin brass plug missing. Bergstrom Aircraft also reported a hole in the top of the crankcase, which they stated was "probably caused by [the] brass plug being pushed out by [the] crank shaft lobe." ## Aircraft - Registration: [N6887W](https://openairdocs.org/deregistered/N6887W-2001-08-09), registration cancelled 2001-08-09, S/N 28-21043 (OpenAirDocs) - Reported make and model: Piper PA-28-140 - Registry model: [Piper PA-28-140](https://openairdocs.org/model/piper-pa-28-140) (registry code 7102802) (OpenAirDocs) - Category: Airplane - Serial number: 28-21043 - Airframe hours: 4147 - Engines: Lycoming O-320-E2A 150 horsepower reciprocating - Damage: Substantial damage - Flight: Personal, Part 91 - Registered owner: Stephen L. Walters - Airworthiness certificate: Standard, Utility; Standard, Normal - Last inspection: Annual, October 17, 1999, 27 hours before - Departed: ALW, WALLA WALLA, WA - Destination: 4S2, HOOD RIVER, OR - Flight plan: VFR ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 49; private; airplane ratings: single-engine land; medical: class 3, valid medical--w/ waivers/lim; seat: left; flight hours: 159 total, 28 in this make and model, 61 as pilot in command, 31 in the last 90 days, 13 in the last 30 days ## Weather - Conditions: Visual (VMC), Day - Visibility: 30 statute miles - Lowest ceiling: none - Temperature: 88 °F ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20000630012729A](https://openairdocs.org/incident/20000630012729A), Jun 30, 2000: Piper PA28140, Pasco, WA, No damage. (-23) I had departed from the walla walla airport at about 11:18 am. I was travelling to hood river. On take off I experienced a little engine roughness but it… ## Other investigations on N6887W (1) From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. - [NTSB LAX66F0244](https://openairdocs.org/ntsb/LAX66F0244), Feb 9, 1966: Piper PA-28 (N6887W), Santa Barbra, CA, substantial damage From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.