# NTSB SEA01LA104: Curtis Lionheart, N816JC, Bremerton, WA, May 24, 2001 - Type: NTSB accident investigation - Classification: Accident · No injuries · Limited investigation · Final report - Date: May 24, 2001, 14:45 local (21:45 UTC) - Place: Bremerton, WA - Coordinates: 47.589645, -122.620346 (estimated) - Nearby events: https://openairdocs.org/map.md?lat=47.5896&lon=-122.6203&mi=10 - Phase of flight: [Landing](https://openairdocs.org/ntsb-phases/550) (OpenAirDocs' grouping) - Highest injury: No injuries - Injuries: 1 uninjured - Status: Completed, report September 19, 2001 - Report: Approved by Office Director - Parties: Seattle FSDO - NTSB case key (mKey): 52378 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=SEA01LA104 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/52378/pdf - Page: https://openairdocs.org/ntsb/SEA01LA104 ## Probable cause the pilot's failure to ensure the aircraft's longitudinal axis was aligned with the runway prior to touchdown, and his failure to maintain directional control during the landing roll. Factors include landing with a tailwind, and the pilot's lack of recent experience in the particular make and model aircraft. A factor in the severity of the post-accident fire was the kit manufacturer's inadequate design, which allowed the excessive side-load failure of a main gear leg to pull a portion of the wall from a wing fuel tank. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Loss of control - on ground/water, landing - flare/touchdown - proper alignment - not maintained, pilot in command (cause) - lack of recent experience in type of aircraft, pilot in command (contributing factor) - directional control - not maintained, pilot in command (cause) - weather condition - tailwind (contributing factor) - Gear collapsed, landing - roll - landing gear,main gear - overload - Fire, landing - roll - fuel system,tank - ruptured - acft/equip,inadequate design, kit manufacturer (contributing factor) ## Analysis The flight during which the accident took place was the maiden flight for the recently completed tailwheel-equipped experimental aircraft. After flying familiarization maneuvers for about 30 minutes, the pilot returned to the departure airfield, where he made two preplanned low approaches in order to establish the best indicated airspeed for his first landing. During his third approach, which was intended to terminate in a full-stop landing, the pilot was high on final. He therefore applied right rudder to slip the aircraft in order to lose altitude. Although the pilot eliminated most of the slip as he flared the aircraft for landing, as it floated down the runway, he inadvertently allowed the nose to begin rotating to the right. Then, just before the aircraft touched down, the nose of the aircraft rotated further to the right. The aircraft touched down in a significant right crab and immediately rocked up onto its left main gear. At the same time, it started increasing its rate of turn to the right. About 275 feet from where the aircraft touched down, the left main gear experienced an overload failure, followed immediately by the right. As the right main gear collapsed, it tore a portion of the right wing fuel tank wall loose, and a large volume of fuel was released into the wheel well. As the right wing settled to the asphalt surface, a massive fire broke out, which ultimately consumed the aircraft. It was later determined that the pilot had made only four landings in a tailwheel equipped aircraft in the last year, none of which were in the make and model he was flying at the time of the accident. It was further determined that the pilot attempted the landing in a tailwind of approximately five knots. ## Factual narrative On May 24, 2001, approximately 1445 Pacific daylight time, an experimental Curtis Lionheart was consumed by fire after experiencing a gear collapse during a landing at Bremerton National Airport, Bremerton, Washington. The airline transport pilot, who was the sole occupant, was not injured, but the aircraft, which was owned and operated by the pilot, was destroyed in the post-crash fire. The local 14 CFR, Part 91 maiden flight of the experimental aircraft, which was being conducted in visual meteorological conditions, departed the same airport about 45 minutes earlier. No flight plan had been filed. After departing Bremerton National, the pilot flew around the area performing a series of preplanned maneuvers in order to determine the flight characteristics of the aircraft. By comparing the indicated airspeed of the subject aircraft to that of the chase plane during this series of maneuvers, the pilot was able to determine that the airspeed indicator in the Lionheart was indicating approximately 25 knots lower than it should have. Upon returning to the Bremerton Airport, the pilot made two preplanned low approaches, taking into consideration the apparent indicated airspeed error. According to the pilot, his first approach, executed at 70 knots indicated airspeed, was determined to be too fast. His next low approach, executed at 45 knots indicated airspeed, "looked good and felt good," so he decided to use 45 knots the next time around and terminate in a full-stop landing. After viewing multiple videos showing the accident sequence, and interviewing witnesses who were present at the event, it was determined that on this third approach, as the aircraft passed a point approximately one-half mile from the approach end of the runway, it was at a higher altitude than it had been on the first two approaches. According to the pilot, he could see that he was going to "land beyond the spot I had picked out," so he elected to slip the aircraft in order to increase its rate of descent. As the aircraft passed the runway threshold, the pilot initiated the landing flare and began to eliminate the slip. After the aircraft leveled off above the runway surface and began to float during its deceleration to touchdown speed, it was tracking approximately parallel to the runway centerline. In addition, the pilot's control inputs to eliminated the slip had brought the longitudinal axis of the aircraft to a point where it was nearly aligned with the runway. But, during the last portion of the aircraft's pre-touchdown deceleration, its nose began rotating to the right. Then, just prior to touchdown, the aircraft's lateral axis experienced an additional significant clockwise shift. At the moment the aircraft's main gear came in contact with the runway, it was tail-low and its lateral axis was cocked a significant degree to the right of the runway heading. Immediately after touchdown (within one second), the aircraft rocked up onto its left main gear and rapidly began rotating further to the right. As the aircraft passed a point approximately 275 feet beyond its initial touchdown point, the left main gear failed inward (direction of normal retraction). Immediately thereafter (within two seconds), the right main gear failed outward (opposite normal direction of retraction). At the instant the bottom of the right wing contacted the runway, a massive fire broke out that ultimately consumed the aircraft. Further investigation determined that although the wind had been light and variable during most of the day, at the time of the accident, the landing was being executed in a tailwind of approximately five knots. Discussions with the pilot also revealed that in the last year, he had accomplished a total of four landings in tailwheel-equipped aircraft. Two of those landings were in were in a Cessna 185, and the others were in a Piper J-3 Cub. During this same period, the pilot had made no landings in a Lionheart. During the investigation, the main gear legs and the gear actuator/down-lock mechanisms were inspected. The inspection revealed that during the accident sequence, both down-lock mechanisms (internal to the actuators) had remained locked, and the actuator rods had remained extended. It was also determined that on the left main gear, the 5/8 inch 17-4 stainless steel pin/bolt that attaches the actuator/down-lock rod to the gear housing had failed in overload. A review of the aircraft gear systems assembly disclosed that such a failure would allow the left main gear to retract inward (as it did in this sequence of events). Inspection of the right main gear revealed that the gear leg and actuator/down-lock had remained intact (and locked), and that there were no failures in their structure or interconnection. Further inspection revealed that at the point where the top of the right gear leg attaches to the inboard rib/bulkhead of the right fuel tank, the gear leg had separated from the airframe, taking a portion of the rib/bulkhead with it. A further review of the gear system and the lower wing assembly detail drawings disclosed that separation of the right main gear leg in the aforementioned manner would allow the gear leg to pivot outward around the actuator attach point (as it did in this sequence of events), and would provide an opening for fuel to spill directly into the right main gear well. ## Aircraft - Registration: [N816JC](https://openairdocs.org/deregistered/N816JC-2001-09-24), registration cancelled 2001-09-24, S/N GA-LH-004 (OpenAirDocs) - Reported make and model: Curtis Lionheart - Registry model: [Curtis J C LIONHEART](https://openairdocs.org/model/curtis-j-c-lionheart) (registry code 056075A) (OpenAirDocs) - Category: Airplane, amateur-built - Serial number: GH-LA-004 - Airframe hours: 1 - Engines: P&W R-985 450 horsepower reciprocating - Damage: Destroyed - Fire: On-Ground - Flight: Personal, Part 91 - Operator: John C. Curtis - Registered owner: Griffon Northwest, Inc. - Airworthiness certificate: Special, Experimental (Special) - Last inspection: Annual, May 17, 2001, 0 hours before - Departed: PWT, Bremerton, WA - Airport: PWT, Bremerton National, runway 19, 6,200 × 150 ft, asphalt ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 64; injuries: none; flight engineer, airline transport; airplane ratings: single-engine land, single-engine sea, multi-engine land; instrument ratings: airplane; medical: class 3, valid medical--no waivers/lim.; last flight review January 25, 2001; seat: left; flight hours: 17,000 total, 3 in this make and model, 6,200 as pilot in command, 4 in the last 90 days, 3 in the last 30 days, 0 in the last 24 hours ## Weather - Conditions: Visual (VMC), Day - Wind: 20° at 6 knots - Visibility: 10 statute miles - Lowest ceiling: none - Temperature: 70 °F, dew point 54 °F - Altimeter: 30.14 inHg - Observed at: KPWT ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20010524009939A](https://openairdocs.org/incident/20010524009939A), May 24, 2001: Amtr LIONHEART, Bremerton, WA, No damage. (-23)This was the initial flight of a recently completed experimental amateur built aircraft. The 45 minute flight went as planned and the only problem noted… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.