# NTSB SEA03LA018: Hawker Siddeley DH-125, N55RF, Seattle, WA, December 17, 2002 - Type: NTSB accident investigation - Classification: Accident · No injuries · Limited investigation · Final report - Date: December 16, 2002, 19:07 local (Dec 17, 2002, 03:07 UTC) - Place: Seattle, WA - Coordinates: 47.516666, -122.303337 - Nearby events: https://openairdocs.org/map.md?lat=47.5167&lon=-122.3033&mi=10 - Phase of flight: [Landing](https://openairdocs.org/ntsb-phases/550) (OpenAirDocs' grouping) - Highest injury: No injuries - Injuries: 3 uninjured - Status: Completed, report July 23, 2003 - Report: Approved by Office Director - Parties: FAA-FSDO - NTSB case key (mKey): 56219 - NTSB case page: https://web.ntsb.gov/investigations/?ntsbnumber=SEA03LA018 - NTSB report (PDF, downloads): https://data.ntsb.gov/carol-repgen/api/Aviation/ReportMain/GenerateNewestReport/56219/pdf - Page: https://openairdocs.org/ntsb/SEA03LA018 ## Probable cause The landing gear down and locked was not verified prior to landing. The checklist was not followed, and an inoperative landing gear warning horn were factors. ## Sequence of events In NTSB's coding before 2008 (https://www.ntsb.gov/GILS/Documents/codman.pdf). - Wheels up landing, landing - landing gear,gear warning system - not operating (contributing factor) - gear down and locked - not verified, pilot in command (cause) - checklist - not followed, pilot in command (contributing factor) ## Analysis The Co-Pilot was the flying pilot with the Captain giving directions throughout the approach phase. The Captain stated that he extended the flaps and the landing gear. When the aircraft touched down, the landing gear was not extended. The Co-Pilot reported that she did look down at the landing gear lever and at "three green lights" on the approach. The CVR was read out which indicated that the Co-Pilot directed the Captain to call inbound. The Captain acknowledged this and stated "fifteen flaps." The Co-Pilot then stated "fifteen flaps, before landing." The Captain did not respond to the Co-Pilot but instead made a radio transmission. The Captain shortly thereafter, stated that he was extending the flaps to 25 degrees. The Captain made another radio transmission to the tower when the Co-Pilot stated "final, sync, ignitions." The Captain responded "ignitions on." Full flaps were then extended. The Captain gave the Co-Pilot continued directions while on the approach for heading, speed and altitude. At approximately 300 feet, the Captain stated, "yaw damper's off, air valves are off, ready to land." The Captain reported that it was obvious that touchdown was on the flaps and keel. The Captain stated that he raised the flaps, shutdown the engines, and confirmed that the landing gear handle was down. During the gear swing test the landing gear cycled several times with no difficulties. All red and green lights illuminated at the proper positions. During the test, it was found that the gear not extended horn did not function with the gear retracted, the flaps fully extended and the power levers at idle. Later a bad set of contacts to the relay was found. When the relay was jumped, the horn sounded. Inspection of the damage to the aircraft revealed that the outer rims of both outer tires displayed scrape marks around the circumference of the rim. The outer surface of the gear door fairings were scraped and the flap hinge fairings was ground down. ## Factual narrative HISTORY OF FLIGHT On December 16, 2002, at 1907 Pacific standard time, a Hawker Siddeley DH-125, N55RF, registered to and operated by National Aircraft Leasing as a 14 CFR Part 91 business flight, landed gear up at Boeing Field, Seattle, Washington. Instrument meteorological conditions prevailed at the time and an instrument flight rules flight plan was in effect. The aircraft was substantially damaged and the airline transport pilot, commercial pilot and passenger were not injured. The flight originated in Sacramento, California, about one hour and 30 minutes prior to the accident. The flight crew reported that the Co-pilot seated in the right seat was the flying pilot for the duration of the flight. The initial phase of the approach utilized the autopilot in the GPS (Global Positioning System) mode. At 2,200 feet in altitude hold, the mode was switched to the ILS (Instrument Landing System) approach for runway 13R. During an interview and subsequent written statement, the Captain reported that during the approach he selected the flaps to 15 degrees and extended the landing gear. Flaps were then extended to 25 degrees when the descent began. The Co-Pilot noted a "flapping or thumping noise" and the autopilot was disengaged and the flaps were extended to 45 degrees. The Captain reported that the engine sync was turned off and the ignitions turned on. A wind check was made at two miles out and the final checklist was completed with the yaw dampers off and the air valves shut. The Captain reported that the approach was stabilized and the touchdown was smooth. The Captain stated that it was obvious that touchdown was on the flaps and keel. The Captain raised the flaps, shutdown the engines, and confirmed that the landing gear handle was down. No audible warnings or warning lights were noted. The Co-Pilot reported that while preparing for landing on 13R, the Captain asked her if she wanted 15 degrees of flaps and gear down. The Co-Pilot stated that she did. When the autopilot was disengaged, a loud "thumping" sound was heard and she called it to the Captain's attention. The Captain stated that everything was normal and to continue flying. The Captain called out and extended the flaps to 25 degrees, with the noise continuing. The Co-Pilot mentioned that "something did not feel right," and the Captain told her to continue. The Co-Pilot glanced at the instruments and noticed that the landing gear was down and locked and she saw three green lights. On short final, 45 degrees of flaps were extended and the landing continued. No warning horns were noted. The Co-Pilot noted a "very long flare" and told the captain that something was wrong. At this time, the crew heard and felt the scraping sound and they knew that the main landing gear was not down. After the aircraft came to rest, the Co-Pilot noted that the landing gear lever was down and in the locked position. DAMAGE TO AIRCRAFT The fire damage was localized to the area of the underbelly keel and just aft of the left main landing gear and traveled up and along the left side of the fuselage, inboard of the left engine. The fuselage skin was melted and torn away. The belly keel was also compromised. The inside of the left engine cowling displayed heat distress. The flap hinge fairings that extend below the flaps were ground down. The flaps did not appear to be damaged. The left and right main landing gear door fairings, with semi-circular cut outs that exposed the outer tires when retracted, displayed scrape marks noted to the outer side of both doors in the area where the material rises. There was no damage noted to the leading edge or ends of the doors. Both left and right side outer tire rims displayed scrape marks along the circumference of the rim. PERSONNEL INFORMATION At the time of the accident, the Captain held airline transport pilot and flight instructor certificates for single and multi-engine aircraft with an instrument rating. The Captain reported a total flight time of 13,497 hours in all aircraft and 1,713 hours in the make and model aircraft involved in the accident. The Captain held a Class II medical certificate dated January 2, 2002. No waivers or limitations were reported. The Co-Pilot held commercial, flight instructor and flight engineer certificates for single engine land and sea, and multi-engine land aircraft with an instrument rating. The Co-Pilot reported a total flight time of 2,400 hours in all aircraft and 200 hours in the make and model aircraft involved in the accident. The Co-Pilot held a Class II medical certificate dated February 5, 2002. No waivers or limitations were reported. FLIGHT RECORDERS The Fairchild model GA-100 cockpit voice recorder (CVR), s/n 01093 was removed from the aircraft and transported to the National Transportation Safety Board, Audio Laboratory, Washington, D.C. on December 23, 2002. The CVR was examined by the Transportation Safety Specialist who noted that the unit showed no evidence of structural damage, and the interior sustained no apparent heat or impact damage. The Dukane underwater locator beacon (ULB) was tested and found to operate satisfactorily. The Cockpit Voice Recorder committee convened on January 9, 2003 and a transcript of the cockpit conversations was prepared of the final 12:34 minutes of the 32:12 minute recording. The transcript began at 1855:55 with the Captain reporting that they were four minutes to the NOLLA turn point. The Co-Pilot was the flying pilot and was responding to the Captain's directions to maintain course alignment and establishment to the glide slope. The communications/directions from the Captain continued for course headings, speed and altitude adjustments. At 1900:51, the Co-Pilot made a comment, "What's that noise? Do you hear that?" The Captain responded "Yep. I don't know. Something. I think it's a gyro noise." At 1900:56, Seattle Approach contacted the flight indicating that they were five miles from NOLLA. A direction to turn right to a heading of 050 degrees was given and to maintain 2,200 feet until established on the localizer. The flight was cleared for the ILS (Instrument Landing System) for runway 13 right. The Captain responded to the controllers directions. The communications between the Captain and the Co-Pilot continued with the Captain directing the Co-Pilot to continue utilizing the auto-pilot for the approach. It was noted by the Captain at 1902:46, that the frequency for the approach was not correct. At 1903:10, the Co-Pilot noted that they were at NOLLA, and directed the Captain to call inbound. The Captain acknowledged the Co-Pilot and then selected "fifteen flaps." The Co-Pilot responded "fifteen flaps, before landing. We doing this auto-pilot? The Captain did not respond to the Co-Pilot, but instead made a radio transmission to Approach Control reporting that they were at NOLLA. The approach controller directed the flight to contact tower (Boeing Tower) on 120.6. The Co-Pilot then stated that they were left of course, then corrected to say they were right of course, and questioned, "I need to go left?" The Captain responded that "it's gonna, engage here in a minute." The Captain then indicated that he was extending the flaps to twenty-five, and directed the Co-Pilot to "pull the power a little." At 1903:36, the Captain contacted Boeing Tower and reported that they were just passed NOLLA. The controller responded that they were cleared to land, gave the wind conditions as wind from 160 degrees at 8 knots, and identified traffic. At 1904:02, the Co-Pilot stated, "final, sync, ignitions?" The Captain responded "ignition's on." Communications continued between the Captain and Co-Pilot about the use of the auto-pilot. The Captain continued to direct the Co-Pilot on course heading, altitude and airspeed to remain aligned on the locali ## Aircraft - Registration: [N55RF](https://openairdocs.org/deregistered/N55RF-2003-08-22), registration cancelled 2003-08-22, S/N 25020, built 1964 (OpenAirDocs) - Reported make and model: Hawker Siddeley DH-125 - Registry model: [Hawker Siddeley DH-125](https://openairdocs.org/model/hawker-siddeley-dh-125) (registry code 4230102) (OpenAirDocs) - Registry engine: [Brist Sid MARK-521](https://openairdocs.org/engine/brist-sid-mark-521) (registry code 10201, turbo-jet) (OpenAirDocs) - Category: Airplane - Serial number: 25020 - Airframe hours: 14162 - Engines: Allied Signal TFE-731-3R-1H 3700 lbs thrust turbo fan - Damage: Substantial damage - Fire: On-Ground - Flight: Business, Part 91 - Registered owner: National Aircraft Leasing - Airworthiness certificate: Standard, Normal - Last inspection: Continuous airworthiness, December 12, 2002, 12 hours before - Departed: MHR, Sacramento, CA - Destination: BFI, Seattle, WA - Flight plan: IFR - Airport: BFI, Boeing Fld/King Co Intl, runway 13R, 10,001 × 200 ft, asphalt ## Flight crew As NTSB recorded them. NTSB leaves out names. - Pilot; age 68; injuries: none; airline transport, commercial, flight instructor; airplane ratings: multi-engine land, single-engine land; instrument ratings: airplane; medical: class 2, valid medical--no waivers/lim.; last flight review March 14, 2002; seat: left; flight hours: 13,497 total, 1,713 in this make and model, 10,622 as pilot in command, 76 in the last 90 days, 30 in the last 30 days, 2 in the last 24 hours - Co-pilot; injuries: none ## Weather - Conditions: Instrument (IMC), Night/dark - Wind: 170° at 8 knots - Visibility: 10 statute miles - Lowest ceiling: 9,000 ft broken - Temperature: 46 °F, dew point 37 °F - Altimeter: 29.44 inHg - Observed at: BFI ## FAA reports on this event (1) The FAA's own accident and incident reports, matched to the aircraft by N-number and date (OpenAirDocs). - [Accident 20021216033129A](https://openairdocs.org/incident/20021216033129A), Dec 16, 2002: Raythn DH125, Seattle, WA, Substantial damage. (-23) Pilot allan john kelly allowed the co-pilot to fly the aircraft from the right seat. Aircraft landed gear up and caught on fire. Pilot stated they had… From the NTSB's public API. Aircraft are matched to registry aircraft by N-number and event date, checked against the reported serial number, make and model; the registry's history has gaps, so older matches can be wrong. Compare the reported make and model. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.