# TCDS 7A12: Aeronautica Macchi S.p.A. - Type: Type certificate data sheet - Status: Current - Holder: Aeronautica Macchi S.p.A. - Revision: 4 - Revised: April 29, 1968 - Product: Aircraft, Small Airplane - Certification basis: Part 3, CAR 3, CAR 10 - Registered aircraft: 2, by the registry models matched to it (OpenAirDocs) - Data sheet PDF: https://openairdocs.org/files/sha256/9d/07/9d07f46ab33c03a9ce219f41ac0a3698fe8044c5600d49dd1f91429b8166f8c0 - FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/40344D593F00C8178525672A00703796.0001 - Page: https://openairdocs.org/tcds/7A12 ## Models (4) As the data sheet lists them. - AL 60 - AL 60-C5 - AL 60-B - AL 60-F5 ## What the data sheet says From the PDF's text layer, line by line; tables lose their columns. The PDF is the record. ```text Page No. 1 2 3 4 5 Rev No. 4 4 4 - - DEPARTMENT OF TRANSPORTATION FEDERAL AVIATION ADMINISTRATION 7A12 Revision 4 AERONAUTICA MACCHI AL 60 (Formerly LASA 60 See NOTE 4) AL 60-B AL 60-F5 AL 60-C5 April 29, 1968 TYPE CERTIFICATE DATA SHEET NO. 7A12 This data sheet which is a part of type certificate No. 7A12 prescribes conditions and limitations under which the product for which the type certificate was issued meets the airworthiness requirements of the Civil Air Regulations. Type Certificate Holder Aeronautica Macchi S.p.A. Via Sanvito Silvestro, 8Q VARESE, Italy I. Model AL 60 (Normal Category), Approved June 26, 1961 (See NOTE 5) Engines Continental IO-470-R or Continental TSIO-470-B Fuel Continental IO-470-R engine: 91/96 minimum grade aviation gasoline Continental TSIO-470-B engine: 100/130 minimum grade aviation gasoline Engine limits Continental IO-470-R engine: For all operations, 2600 r.p.m. (250 hp.) Continental TSIO-470-B engine: For all operations, (Sea level) 35 in.Hg., 2600 r.p.m. (260 hp.) (16,000 ft.) 35 in.Hg., 2600 r.p.m. (260 hp.) Propeller and McCauley D2A36C33/90M-4 propeller limits Diameter: Maximum 86 in., minimum allowable for repairs 84 in. (No further reduction permitted) Pitch setting at 36 in. r adius: With Continental IO-470-R engine: Low 9.0 degrees, High 22.3 degrees With Continental TSIO-470-B engine: Low 10.0 degrees, High 27.5 degrees Airspeed limits Never exceed 176 m.p.h. (153 knots) Maximum structural cruising 140 m.p.h. (122 knots) Maneuvering 133 m.p.h. (116 knots) Flaps extended 100 m.p.h. ( 87 knots) C.G. range (+211.1) to (+216.5) at 3532 lb. (+204.5) to (+216.5) at 2700 lb. or less Straight line variation between points given. 7A12 2 Empty weight C.G. range None Maximum weight 3532 lb. No. seats 2 (+202), 2 (+230) or (+236), 2 (+261) Maximum baggage 200 lb. (+285) Fuel capacity 57 gal. total; 49 or 52.5 gal. usable (2 wing tanks) (+219) See NOTE 1 for unusable fuel. Oil capacity 3 gal. (+135) (Unusable oil - 4 qt.) Applicable to either engine. See NOTE 1 for system oil. Control surface Wing flaps Down 27 degrees ±1 degree movements Aileron Up 10 degrees ±1 degrees Down 11 degrees ±1 degree Elevator Up 25 degrees ±1/2 degree Down 16 degrees ±1 degree Rudder Right 20 degrees ±1 degree Left 19 degrees ±1 degree Horizontal Stabilizer (Minus) 1/2 degree ± 1/2 degree to (Minus) 5 1/2 degrees ±1/2 degree II. Model AL 60-B (Normal Category), Approved October 27, 1962 (Model AL 60-B same as Model AL 60 except structural changes to make it eligible for 3850 lb. maximum weight). Engines Continental IO-470-R or Continental TSIO-470-B Fuel Continental IO-470-R engine : 91-96 minimum grade aviation gasoline Continental TSIO-470-B engine : 100/130 minimum grade aviation gasoline Engine limits Continental IO-470-R engine : For all operations, 2600 r.p.m. (250 hp.) Continental TSIO-470-B engine : For all operations, (Sea level) 35 in. HG., 2600 r.p.m. (260 hp.) (16,000 ft.) 35 in. Hg., 2600 r.p.m. (260 hp.) Propeller and McCauley D2A36C33/90m-4 Propeller limits Diameter: Maximum 86 in., minimum allowable for repairs 84 in. (No further reduction permitted) Pitch setting at 36 in. radius: Low 10.0 degrees, High 27.5 degrees Airspeed limits Never exceed 176 m.p.h. (153 knots) Maximum structural cruising 140 m.p.h. (122 knots) Maneuvering 140 m.p.h. (122 knots) Flaps extended 105 m.p.h. ( 92 knots) C.G. Range (+211.1) to (+216.5) at 3850 lb. (+204.5) to (+216.5) at 2945 lb. or less Straight line variation between points given. Empty weight C.G. range None Maximum weight 3850 lb. No. of seats 2 (+202), 2 (+230) or (+236), 2 (+261) Maximum baggage 200 lb. (+285) 3 7A12 Fuel capacity 57 gal. total; 52.5 gal. usable (2 wing tanks) (+219) with two-cell type tanks Macchi dwg. 2735 or 74.5 gal. total; 70 gal. usable (2 wing tanks) (+215) with four-cell type tanks Macchi dwg. 10085 or 91 gal. total; 84 gal. usable (2 wing tanks) (+219) with three-cell type tanks Macchi dwg. 27042 See NOTE 1 for unusable fuel. If four-cell type tanks, Macchi dwg. 10085, are installed, "Appendix C" is required in "Flight Manual". Oil capacity 3 gal. (+135) (Unusable oil - 4 qt.) See NOTE 1 for system oil. Control surface movements Wing flaps Down 27 degrees ± 1 degree Aileron Up 10 degrees ± 1 degree Down 11 degrees ± 1 degree Elevator Up 25 degrees ± 1/2 degree Down 16 degrees ± 1 degree Rudder Right 20 degrees ± 1 degree Left 19 degrees ± 1 degree Horizontal Stabilizer (Plus) 0 degrees 50 min. ± 10 min. to (Minus) 4 degree 20 min. ± 10 min. III. Model AL 60-F5 (Normal Category), Approved October 16, 1967, and Model AL 60-C5 (Normal Category) Approved February 29, 1968 (Model AL 60-F5 is similar to previous models except for major modifications to the airframe structure, such as strengthening of nose landing gear and engine mount. Model AL 60-C5 is the same as Model AL 60-F5 except for tail wheel type landing gear and location of fuselage door on left side.) Engine Lycoming IO-720-A1A Fuel 100/130 minimum grade aviation gasoline Engine limits For all operations, 2650 r.p.m. (400 hp.) Propeller and Hartzell HC-A3VK-4V8433 three-bladed constant speed. propeller limits Diameter : Maximum 84 5/8 in., minimum allowable for repairs 82 5/8 in. (No further reduction permitted) Pitch setting at 30 in. radius : Low 12.0 degrees, High 33.9 degrees Airspeed Limits Never exceed 185 m.p.h. (160 knots) Maximum structural cruising 149 m.p.h. (129 knots) Maneuvering 149 m.p.h. (129 knots) Flaps extended 112 m.p.h. ( 97 knots) C.G. Range (+211.1) to (+217.9) at 4490 lb. (+203.5) to (+217.9) at 3300 lb. or less Straight line variation between points given. Empty Weight C.G. Range None Maximum weight 4490 lb. No. of Seats 2 (+202), 2 (+230) or (+236), 2 (+261) Maximum baggage 200 lb (+285) Fuel capacity 91 gal. total; 84 gal. usable (2 wing tanks) (+219) See NOTE 1 for unusable fuel 7A12 4 Oil capacity 17 qt. (+138) (Unusable oil - 5 qt.) See NOTE 1 for system oil. Control surface movements Wing flaps Down 32 degrees ± 1 degree Aileron Up 10 degrees ± 1 degree Down 11 degrees ± 1 degree Elevator Up 25 degrees ± 1/2 degree Down 16 degree ± 1 degree Rudder Right 20 degree ± 1 degree Left 19 degrees ± 1 degree Horizontal Stabilizer (Plus) 3 degrees ± 1/2 degree to (Minus) 7 degrees ± 1/2 degree DATA PERTINENT TO ALL MODELS Datum 191.67 in. forward of leading edge of wing at wing root. Leveling means Cabin floor - left center seat rail inside cabin door. Serial Nos. eligible A Registro Aeronautico Italiano (R.A.I.) Certificate of Airworthiness for Export endorsed as noted below under "Import requirement" must be submitted for each individual aircraft for which certification is made. Certification basis CAR 10. Type Certificate No. 7A12 issued June 26, 1961. Car 3 dated May 15, 1956, including Amendments 3 - 1 through 3 - 5. Import Requirements A U.S. Airworthiness Certificate may be issued on the basis of a Certificate of Airworthiness for Export signed by a representative of the Registro Aeronautico Italiano (R.A.I.), containing the following statement: "The airplane covered by this certificate has been examined and found to comply with U.S. Civil Air Regulation Part 3, dated May 15, 1956, including Amendment 3-1 through 3-5 and conforms to T.C. 7A12". Equipment The basic required equipment as prescribed in the applicable airworthiness regulations (See Certification basis) must be installed in the aircraft for certification. In addition, the following items of equipment are required: a. Pre-stall warning indicator, Safe Flight Instrument Corp. 164 R. b. 1. R.A.I. approved Airplane Flight Manual for AL 60-1 dated June 8, 1962 or 2. R.A.I. approved Airplane Flight Manual for AL 60-2 dated April 20, 1962 or 3. R.A.I. approved Airplane Flight Manual for AL 60-B-1 dated July 2, 1962 or 4. R.A.I. approved Airplane Flight Manual for AL 60-B-2 dated July 12, 1962 or 5. R.A.I. approved Airplane Flight Manual for AL 60-F5 dated July 26, 1967 or 6. R.A.I. approved Airplane Flight Manual for AL 60-C5 dated January 19, 1968 (See NOTE 3 for model designation). NOTE 1. Current weight and balance report including list of equipment included in certificated empty weight, and loading instructions when necessary, must be provided for each aircraft at time of original certification and at all times thereafter. The certificated empty weight and corresponding center of gravity locations must include: System oil of 1 lb. at (+135) and unusable fuel of 48 lb. at (+219) for the serial number 2/6144, 4/6146, 5/6147, 6/6148, 7/6149, 8/6150, 9/6154, 11/6156, 12/6157 (only Model AL60). System oil of 1 lb. at (+135) and unusable fuel of 27 lb. at (+219) for the serial number 1/6143, 3/6145, 10/6155, 13/6158 and successive up to serial number 61/6241 fitted with two-cell type tanks Macchi dwg. 2735 and four-cell type tanks Macchi dwg. 10085 (Model AL-60 and AL 60-B). System oil of 1 lb. at (+135) and unusable fuel of 42 lb. at (+219) for airplane fitted with thr ee-cell type tanks Macchi dwg. 27042. (Model AL 60-B serial number 62/6242 and all successive). System oil of 1 lb. at (+138) and unusable fuel of 42 lb. at (+219) for Model AL 60-F5 and AL 60-C5. 5 7A12 NOTE 2. The following placards must be displayed in front and in clear view of pilots: "THIS AIRPLANE MUST BE OPERATED AS A NORMAL CATEGORY AIRPLANE IN COMPLIANCE WITH THE APPROVED AIRPLANE FLIGHT MANUAL". "NO ACROBATIC MANEUVERS, INCLUDING SPINS, APPROVED". NOTE 3. For convenience in identifying the appropriate model, the number following the dash identifies only the engine installation: - 1 is applicable to Continental IO-470-R - 2 is applicable to Continental TSIO-470-B - 5 is applicable to Lycoming IO-720-A1A NOTE 4. All Model LASA 60 aircraft were redesignated as Model AL 60 on April 27, 1962. NOTE 5. When Aeronautica Macchi Modification Bulletin No. 7 dated September 20, 1962, is complied with, Model AL 60 is changed to AL 60-B. Modification Kit supplied by Aeronautica Macchi will be accompanied by a "Certificato di Collaudo" issued by R.A.I. Two Flight Manuals, one for the owner, and one for the FAA Regional Office, will be supplied with each Kit. NOTE 6. Each individual airplane will be supplied with a placard that specifies the kinds of operation such as VFR or IFR, Day or Night to which the operation of the airplane is limited by the equipment installed. -END- ``` ## ADs (3, in force first) - [AD 2005-01-19](https://openairdocs.org/ad/2005-01-19): Mode S transponders · GARMIN International GTX 330D, GTX 330, GTX 33D and 830 more. Effective Feb 23, 2005 - [AD 83-07-13](https://openairdocs.org/ad/83-07-13): Engine Mount Structure · Aeronautica Macchi AL 60 and AL 60-B. Effective Apr 14, 1983 - [AD 63-07-02](https://openairdocs.org/ad/63-07-02): Engine Exhaust Manifold · Aeronautica Macchi AL 60 and AL 60-B. Effective May 2, 1963 ## Registered aircraft by registry model (OpenAirDocs) - [Macchi AL 60-B](https://openairdocs.org/model/macchi-al-60-b): 1 aircraft (registry code 5400106) - [Macchi AL60-F5](https://openairdocs.org/model/macchi-al60-f5): 1 aircraft (registry code 5400108) - [Macchi AL 60](https://openairdocs.org/model/macchi-al-60): 0 aircraft (registry code 5400104) ## STCs approved under this data sheet (45) - [STC SA239SW](https://openairdocs.org/stc/SA239SW): Installation of Alcor exhaust gas temperature (EGT) indicator kits. Alcor LLC - [STC SA5581SW](https://openairdocs.org/stc/SA5581SW): Installation of ALCOR true-flow/ totalizer system. Alcor LLC - [STC SA02019WI](https://openairdocs.org/stc/SA02019WI): Installation of the Trig Avionics TX56, TX56A, TX57, or TX57A VHF Nav-Com Radio.. Peregrine - [STC SA00756DE](https://openairdocs.org/stc/SA00756DE): Installation of Automatic Dependent Surveillance Broadcast (ADS-B) Out Equipment using a Trig Avionics TT22 Transponder and an approved Global Positioning System (GPS) Position Sensor. Peregrine - [STC SA11174SC PAGE 1](https://openairdocs.org/stc/SA11174SC%20PAGE%201): Installation of BendixKing by Honeywell KSN 770 and KSN 765 WAAS LPV approach capable nav/comm systems. Honeywell International Inc (Bendix King) - [STC SA10822SC](https://openairdocs.org/stc/SA10822SC): Installation of EFD1000 Primary Flight Display. Aspen Avionics Inc. - [STC SA00401BO](https://openairdocs.org/stc/SA00401BO): Installation of a SkyTrax100B UAT receiver. Avidyne Corporation - [STC SA03286CH](https://openairdocs.org/stc/SA03286CH): Install an electronic engine ignition system. Electroair Acquisition Corporation - [STC SA04032CH](https://openairdocs.org/stc/SA04032CH): Install rocker switch assemblies. Electroair Acquisition Corporation - [STC SA04280CH](https://openairdocs.org/stc/SA04280CH): Install rocker switch assemblies on dual magneto configuration in accordance with Electroair Acquisition Corporation Installation Instructions as listed on AML No. SA04280CH, or later FAA approved revision.. Electroair Acquisition Corporation - [STC SA00744DE](https://openairdocs.org/stc/SA00744DE): Installation of the Automatic Dependent Surveillance Broadcast (ADS-B) Out Equipment using a Trig Avionics TT31 Transponder and an approved position sensor. Peregrine - [STC SA00765DE](https://openairdocs.org/stc/SA00765DE): Installation of Automatic Dependent Surveillance Broadcast (ADS-B) Out functionality using the BendixKing KT74 Transponder and qualified position sensor. Peregrine - [STC SA04165NY](https://openairdocs.org/stc/SA04165NY): Installation of Latitude Technologies Skynode S200 Satcom system must be performed. Latitude Technologies Corporation - [STC SA01835WI](https://openairdocs.org/stc/SA01835WI): Installation of Trig Avionics TY-96 or TY-97 VHF Communications Radio. Peregrine - [STC SA01933LA-D](https://openairdocs.org/stc/SA01933LA-D): Installation of Garmin Model 400W / 500W Series GPS-WAAS Navigation System. Garmin International Inc - [STC SA00382BO](https://openairdocs.org/stc/SA00382BO): Installation of Globalstar Antenna and Cradle provisions to support a Globalstar GPS-1700 in non-composite airplanes. Avidyne Corporation - [STC SA00343BO](https://openairdocs.org/stc/SA00343BO): Installation of a single configuration or a dual configuration Avidyne Corporation Integrated Flight Display, Model IFD540 loaded with Release 10.0 software (or later FAA approved release). Avidyne Corporation - [STC SA00352BO PAGE 1](https://openairdocs.org/stc/SA00352BO%20PAGE%201): Installation of an Avidyne Corporation Mode A/C/S Transponder with ADS-B Out capability, Model AXP340 loaded with Version 3.13 software (or later FAA approved version),. Avidyne Corporation - [STC SA01229SE PAGE 1](https://openairdocs.org/stc/SA01229SE%20PAGE%201): Installation of GNS 480 (CNX80) GPS WAAS Navigator with integrated VHF Navigation and Communication radios. Garmin International Inc - [STC SA01933LA-D PAGE 1](https://openairdocs.org/stc/SA01933LA-D%20PAGE%201): Installation of Garmin Model 400W / 500W Series GPS-WAAS Navigation System. Garmin International Inc - [STC SA02717NY PAGE 1](https://openairdocs.org/stc/SA02717NY%20PAGE%201): Installation of VoiceFlight Systems LLC VFS101 Speech Recognition Module. VoiceFlight Systems LLC - [STC SA01692SE](https://openairdocs.org/stc/SA01692SE): Installation of a Garmin GMX 200 Multi-Function Display. Garmin International Inc - [STC SA03148NY](https://openairdocs.org/stc/SA03148NY): The installation of the Latitude Technologies Corporation S100 Tracking System. Latitude Technologies Corporation - [STC SA02016SE-D](https://openairdocs.org/stc/SA02016SE-D): Installation of Garmin GTS 800, GTS 820 or GTS 850 Traffic System. Garmin International Inc - [STC SA01487SE-D](https://openairdocs.org/stc/SA01487SE-D): Installation of a GDL 69 or GDL 69A XM Satellite Receiver. Garmin International Inc - [STC SA00243BO](https://openairdocs.org/stc/SA00243BO): Installation of Centurion Consulting, Inc. GPS Steering Assist Module (SAM) with roll steering (p/n 0025-5100), or without roll steering (p/n 0025-5200).. Icarus Avionics, LLC - [STC SA593CH](https://openairdocs.org/stc/SA593CH): Install Champion SlickSTART magneto booster system.. Champion Aerospace LLC - [STC SA01473SE](https://openairdocs.org/stc/SA01473SE): Installation of a GTX 32 (mode C), GTX 33 (mode S), or GTX 33D (mode S with diversity) Remote Transponde. Garmin AT Inc. - [STC SA4005NM](https://openairdocs.org/stc/SA4005NM): Precise Flight Inc. Pulselite Control System. Precise Flight Inc - [STC SA01695SE](https://openairdocs.org/stc/SA01695SE): Installation of an antenna. Garmin AT Inc. - [STC SA2683NM](https://openairdocs.org/stc/SA2683NM): Installation of Precise Flight, Inc. stand-by vacuum system (SVS). Precise Flight Inc - [STC SA02154AK](https://openairdocs.org/stc/SA02154AK): Installation of the UPS Aviation Technologies Inc. Apollo MX20 multi-function display, P/N 430-0270-500.. Garmin AT Inc. - [STC SA02217AK](https://openairdocs.org/stc/SA02217AK): Installation of Garmin AT Model GDL90 UAT Data Link System, in accordance with Garmin AT, Inc., GDL 90 UAT Master Data List, P/N 560-0278-01, Revision A, dated November 12, 2004, or later FAA approved revision.. Garmin AT Inc. - [STC SA5159NM](https://openairdocs.org/stc/SA5159NM): Installation of chip detector system.. Northwest Aircraft Inc - [STC SA4938NM](https://openairdocs.org/stc/SA4938NM): Installation of a Continental IO-520-D engine and a McCauley D2A34C58/90AT propeller.. Methow Aviation Inc - [STC SA418NW](https://openairdocs.org/stc/SA418NW): Installation of a float spreader assembly.. Jobmaster Company Inc - [STC SA2820SW](https://openairdocs.org/stc/SA2820SW): Operation with right door removed for parachute jumping.. Hurst Jack A - [STC SA1864WE](https://openairdocs.org/stc/SA1864WE): Installation of Edo Model 4580 floats.. Jobmaster Company Inc - [STC SA224WE](https://openairdocs.org/stc/SA224WE): Heated pitot head and larger capacity battery, new battery box, and external power receptacle. Lockheed Aircraft Intl Inc - [STC SA38WE](https://openairdocs.org/stc/SA38WE): Fluidyne 3000 nose ski and 4000 Mark II main skis.. Lockheed Aircraft Intl Inc - [STC SA591WE](https://openairdocs.org/stc/SA591WE): Holes in bottom of aircraft for camera and driftmeter for aerial photography.. Angeles Flying Service - [STC SA00765DE PAGE 1](https://openairdocs.org/stc/SA00765DE%20PAGE%201) (historical): Installation of Automatic Dependent Surveillance Broadcast (ADS-B) Out functionality using the BendixKing KT74 Transponder and qualified position sensor. Peregrine - [STC SA02717NY](https://openairdocs.org/stc/SA02717NY) (historical): Installation of VoiceFlight Systems LLC VFS101 Speech Recognition Module. VoiceFlight Systems LLC - [STC SA01933LA](https://openairdocs.org/stc/SA01933LA) (historical): Installation of Garmin Model 400W / 500W Series GPS-WAAS Navigation System. Garmin AT Inc. - [STC SA01229SE](https://openairdocs.org/stc/SA01229SE) (historical): Installation of CNX80 GPS WAAS Navigator with integrated VHF Navigation and Communication radios.. UPS Aviation Technologies --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.