# TCDS A00075CE: Vulcanair S.p.A. - Type: Type certificate data sheet - Status: Current - Holder: Vulcanair S.p.A. - Revision: 4 - Revised: July 20, 2021 - Product: Aircraft, Small Airplane - Certification basis: Part 23 - Registered aircraft: 21, by the registry models matched to it (OpenAirDocs) - Data sheet PDF: https://openairdocs.org/files/sha256/74/7d/747d5108783df6e25087abf135a825e7efadfc3aed362bbc1e40248d08a680fb - FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/C7A60611F73456D686258718004FC284.0001 - Page: https://openairdocs.org/tcds/A00075CE ## Models (1) As the data sheet lists them. - Vulcanair V1.0 ## What the data sheet says From the PDF's text layer, line by line; tables lose their columns. The PDF is the record. ```text Page No. 1 2 3 4 Rev. No. 4 0 0 4 DEPARTMENT OF TRANSPORTATION FEDERAL AVIATION ADMINISTRATION A00075CE Revision 4 Vulcanair S.p.A. Vulcanair V1.0 July 20, 2021 TYPE CERTIFICATE DATA SHEET A00075CE This data sheet which is a part of Type Certificate No. A00075CE prescribes conditions and limitations under which the product for which the Type Certificate was issued meets the airworthiness requirements of the Federal Aviation Regulations. Type Certificate Holder. Vulcanair S.p.A. Via Giovanni Pascoli, 7 80026 Casoria (Naples), Italy I. Model Vulcanair V1.0 (Utility Category), Approved December 20, 2017. Engine. One Lycoming IO-360-M1A Fuel. Aviation and automotive fuels listed in the Aircraft Flight Manual, Operating Limitations Section. Oil. Single or multi-viscosity oils, in accordance with Lycoming Service Instruction 1014 (latest issue). Engine Limits. For all operations 2700 rpm (180 HP). Other engine’s limitations listed in the Aircraft Flight Manual, Operating Limitations Section. Propeller and Propeller Limits. One Hartzell HC-C2YR-1BFP/F7497 Diameter 74 in. (No reduction permitted) Governor: Hartzell model S-1-63 Spinner: Hartzell model 103585 One - MT188R135-4G Diameter 74 in. MT-Propeller 2-blades laminated wood composite Model MT188R135-4G (fixed pitch) Spinner: MT-Propeller p/n P-1629 See Note 5. Airspeed Limits (CAS). Never exceed 168 knots Maximum structural cruising 125 knots Maneuvering 122 knots Flaps fully extended 78 knots Datum. Tangent to the wing leading edge. C.G. Range. (+16.06 in.) to (+18.31 in.) at 2546 lb. (+10.24 in.) to (+18.31 in.) at 1874 lb. and less Straight line variation between points. Minimum Crew. 1 pilot. Maximum Weights. Take-Off 2546 lb. (See NOTE 2) Landing 2425 lb. Number of Seats. 4 - (2 at +19.3in.), (2 at +44.1 in.) A00075CE 2 Maximum Baggage. 88.2 lb. (at +63.0 in.) Fuel Capacity. 52.8 gal. total (2 wing tanks 26.4 gal. each at +25.6 in.) 1.3 gal. unusable per tank (See NOTE 1 for data on unusable fuel). Oil Capacity. 2 gal. total (at -37.4 in.) 0.5 gal. unusable Leveling Means. Longitudinal and lateral: plumb weight hanging from the dedicated plate located on the cabin right roof, down to the target located on the cabin floor . Control Surface Movements. Wing flaps 1st position Down 13.5º ± 2° 2nd position Down 28º ± 2° 3rd position Down 42º ± 2° Ailerons Up 28° ± 2° Down 15° ± 1° Rudder Right 20° ± 2° Left 20° ± 2° Stabilator L.E. Up 14° ± 1° Down 8° ± 1° Stabilator Tab (with respect to stabilator chord) Up 9° ± 1° Down 9° ± 1° Load Factors. Positive +4.4 g (Flaps UP) Negative -1.0 g (Flaps UP) Manouvre Limits. Acrobatic manoeuvres approved Speed (IAS) Climbing Turn 129 knots Lazy Eight 140 knots Steep Turn 108 knots Stalls (except whip stall) Slow deceleration Spin is prohibited. At speeds in excess of design maneuvering speed (125 knots IAS), it is forbidden to use the flight controls fully or abruptly deflected. Serial Numbers Eligible. s/n 1001 and subsequent. Each individual aircraft manufactured under this type certificate must be accompanied by an Export Certificate of Airworthiness as noted below under "Import Requirements" when an application for a U.S. airworthiness certificate is made. Certification Basis. Per section 2.1.3 of the FAA/EASA TIP, the Vulcanair model V1.0 FAR 21-17 certification basis contains regulations using the applicable airworthiness standards in effect on the date of application made to EASA, or the applicable airworthiness authority for its type certificate. It is specifically noted that the original date of application for the baseline model P.64B “Oscar B 1155” was January 30, 1968 (see IP G-1 Stage 4 closed May 14, 2017). CAR Part 3 effective May 15, 1956, including Amendments 3-1 through 3-8. For the replacement of the 180HP Lycoming IO-360-M1A, the following regulations are in effect for the areas of affected change: FAR 23 original issue, effective Feb. 1, 1965: §§ 23.33(a)(d), 23.301, 23.303, 23.305, 23.307, 23.361, 23.363, 23.1011(a)(b)(c), 23.1041, 23.1121(a), 23.1125, 23.1183, 23.1581, 23.1583(b), 23.1585(a), 23.1587(a), and 23.1589. FAR 23 Amendment 23-51 (JAR 23 Amendment 1, effective Feb. 1, 2001): §§ 23.21, 23.25, 23.29, 23.601, 23.603, 23.605, 23.607, 23.609, 23.611, 23.613, 23.619, 23.623, 23.625(a)(b)(c), 23.627, 23.777(a)(b)(c)(d)(f)(h), 23.781(b), 23.831(a), 23.901(a)(b)(c)(e), 23.903(a)(d)(f), 23.905(a) (b)(c)(d), 23.907, 23.925(a)(d), 23.951(a)(b), 23.955(a)(c)(e), 23.961, 23.991, 23.993, 23.995, 3 A00075CE 23.1093, 23.1141(a)(b)(c)(d)(f)(g), 23.1301, 23.1309, 23.1501, 23.1521(a)(b)(c)(d), 23.1529, 23.1541, and 23.1549. FAR 36 effective Dec. 1, 1965, included Amendments 36-1 through 36-30. For the installation of the Garmin G500 and JPI JDM-930 displays and aircraft power generation system to 24VDC, the following regulations are in effect for the areas of affected change: FAR 23 original issue, effective Feb. 1, 1965: §§ 23.207, 23.301, 23.303, 23.305, 23.1307(b), 23.1581, 23.1583(a)(b), 23.1585(a), and 23.1589. FAR 23 Amendment 23-51 (JAR 23 Amendment 1, effective Feb. 1, 2001): §§ 23.25, 23.29, 23.601, 23.603, 23.605, 23.607, 23.609, 23.611, 23.613, 23.619, 23.623, 23.625(a)(b)(c), 23.627, 23.697(b), 23.699, 23.771(a), 23.773(a), 23.777(a)(b)(c)(d)(f), 23.779, 23.781, 23.867(a)(b), 23.955(c), 23.963(e), 23.991(b), 23.995, 233.1141(a)(b)(c)(d), 23.1143(a)(b)(c)(g), 23.1145(a)(c), 23.1147, 23.1149(a), 23.1163(a)(b), 23.1165(a)(b)(c)(d), 23.1301, 23.1303, 23.1305(a)(b)(c)(d)(f)(g)(h), 23.1309, 23.1311, 23.1321(a)(c)(d)(e), 23.1322, 23.1323(a)(e)(f), 23.1325(a)(b)(c)(d)(g), 23.1327, 23.1331(a), 23.1337(a)(b)(c), 23.1351, 23.1353(a)(b)(c)(d)(e)(h), 23.1357, 23.1359, 23.1361, 23.1365, 23.1367, 23.1381, 23.1383, 23.1385, 23.1387, 23.1389, 23.1391, 23.1393, 23.1395, 23.1397, 23.1401, 23.1431, 23.1501, 23.1523, 23.1525, 23.1529, 23.1541, 23.1543(b)(c), 23.1545(a)(b)(c), 23.1547, 23.1549, 23.1553, and 23.1555. FAR 23 Amendment 23-57: § 23.1308. FAR 23 Amendment 23-61: § 23.1306. For the activation of the Terrain SVT feature on Garmin G500 avionics system, the following regulations are in effect for the areas of affected change: FAR 23 Amendment 23-51 (JAR 23 Amendment 1, effective Feb. 1, 2001): §§ 23.1301, 23.1309(a)(b), 23.1311(a), 23.1321(a), 23.1322(a)(b)(d)(e), 23.1431(a), 23.1501, 23.1525, 23.1581, and 23.1585(a). FAR 23 Amendment 23-57: § 23.1308. FAR 23 Amendment 23-61: § 23.1306. Validation Basis. Type Certificate A00075CE was issued pursuant to FAR 21.29 in validation of the EASA certification of compliance with the aforementioned certification basis, and in accordance with the standard airworthiness certificate provisions of FAR 21.183(c). Note: The airworthiness provisions of FAR 21.183(d) may be cited as the basis for issuance of standard airworthiness certificates for aircraft imported from a country other than the country of manufacture. Equipment. The basic required equipment as prescribed in the applicable airworthiness regulations (see Certification Basis) must be installed in the aircraft for standard airworthiness certification. In addition, the following items of equipment are required: a) Pre-stall warning indicator, Safe Flight Instrument Corp. Type 164R, or equivalent. b) EASA approved Aircraft Flight Manual (EASA approval No. 10057053). Import requirements The FAA can issue a U.S. airworthiness certificate based on an NAA Export Certificate of Airworthiness (Export C of A) signed by a representative of the Ente Nazionale per l’Aviazione Civile (ENAC) on behalf of the European Community. The Export C of A should contain the following statement : “The aircraft covered by this certificate has been examined, tested, and fou nd to comply with TC No . EASA.A.613 approved under U.S. Type Certificate No. A00075CE and to be in a condition for safe operation”. Country other than Manufacturer (U.S. bilateral agreement and the original Export Certificate of Airworthiness issued by th e country of manufacture must exist): A U.S. airworthiness certificate may be issued on the basis of a log book certifying statement endorsed by an authorized representative of the civil aviation authority of the exporting country. It is incumbent upon th e exporting civil aviation authority to determine that the A00075CE 4 certifying statement includes evidence of acceptable service history and modification deviations and the following statement: "The aircraft covered by this certificate has been examined, tested, in spected in accordance with the provisions of FAR 21.183 (d) or its equivalent, and found to conform to the type design approved under Type Certificate A00075CE and is in a condition for safe operation". For issuance of an airworthiness certificate in accor dance with 14 CFR Part 21.183(c), the Ente Nazionale per l’Aviazione Civile of Italy must certify that the airplane conforms to the type design and is in a condition for safe operation. The Ente Nazionale per l’Aviazione Civile of Italy will certify that t he airplane complies with all applicable mandatory continuing airworthiness information (MCAI) it has issued. Refer to the applicable bilateral agreement to verify eligibility for import into the United States of both new and used aircraft based on the sc ope of the agreement, to identify any required statements by the exporting authority on the export certificate of airworthiness (or equivalent document), and for procedures for coordinating exceptions to conformity statements on these documents. Refer to FAA Order 8130.2, Airworthiness Certification of Aircraft, for requirements for issuance of an airworthiness certificate for imported aircraft. Service Information Each of the documents listed below must state that it is approved by the European Aviation Safety Agency (EASA) or - for approvals made before September 28, 2003 - by the Ente Nazionale per l’Aviazone Civile (ENAC) . (These approvals pertain to the design data only). Service Bulletins Structural Repair Manuals Vendor Manuals Aircraft Flight Manuals, and Overhaul and Maintenance Manuals The FAA accepts such documents and considers them FAA -approved unless one of the following conditions exists: - The documents change the limitations, performance, or procedures of the FAA approved manuals; or - The documents make an acoustical or emissions change to this product’s U.S. type certificate as defined in 14 CFR § 21.93. The FAA uses the post type validation procedures to approve these documents. The FAA may delegate on case -by-case to EASA to approve on behalf of the FAA for the U.S. type certificate. If this is the case it will be noted on the document. NOTE 1. Current weight and balance report including list of equipment in certificated empty weight, and loading instructions, must be provided for each aircraft at the time of original airworthiness certification. The certificated empty weight and corresponding center of gravity location must include unusable fuel ( 15.9 lb. at +25.6 in.). NOTE 2. a) The following placards must be displayed in full view of the pilot:  “THIS AIRCRAFT MUST BE OPERATED AS AN UTILITY CATEGORY AIRPLANE, IN ACCORDANCE WITH THE OPERATING LIMITATIONS PRESCRIBED BY PLACARDS, MARKINGS AND APPLICABLE FLIGHT MANUAL”  “MAXIMUM TAKE-OFF WEIGHT OF 1155 K g (2546 lb.) IS ALLOWED ONLY IF THE LANDING WEIGHT CALCULATED ON THE BASIS OF FUEL CONSUMPTION IS NOT HIGHER THAN 1100 Kg (2425 lb.)” In addition, all placards required in the EASA approved Airplane Flight Manual must be installed in the appropriate location. b) Each individual airplane must be equipped with a placard that specifies the kind of operation such as VFR, or IFR, DAY or NIGHT, to which the operation of the airplane is limited by the equipment installed. NOTE 3. All the service life limits, overhaul limits , instructions for continued airworthiness, airworthiness limitations, special inspections and mandatory maintenance requirements that are published on Vulcanair Aircraft Maintenance Manuals at the date of Type Certificate A00075CE are considered FAA appro ved. These airworthiness limitations may not be changed without FAA-approval. 5 A00075CE NOTE 4. Vulcanair V1.0 aircraft model is approved for sailplane glider towing if the aircraft is modified as per Vulcanair Service Bulletin VA-03. NOTE 5. V1.0 model ai rcraft f rom s/n 1001 onwards may be optionally equipped with the following propeller: MT-Propeller model MT188R135-4G. Lycoming SI1435 conversion required for installation on Lycoming model IO-360-M1A. Vulcanair Major Change MOD.V1/22 “Fixed pitch propeller - MT-Propeller” (EASA Approval 10072391). ----- END ----- ``` ## ADs (2, in force first) - [AD 2023-17-10](https://openairdocs.org/ad/2023-17-10): Fuselage Main, Frame · Vulcanair Vulcanair V1.0. Effective Oct 26, 2023 - [AD 2022-03-15](https://openairdocs.org/ad/2022-03-15): Fuel Quantity Indicator · Garmin G3X Touch Electronic Flight Instrument System (STC SA01899WI or SA02658SE). Effective Mar 21, 2022 ## Registered aircraft by registry model (OpenAirDocs) - [Vulcanair S P A VULCANAIR V1.0](https://openairdocs.org/model/vulcanair-s-p-a-vulcanair-v1-0): 19 aircraft (registry code 6780115) - [Vulcanair VULCANAIR V1.0](https://openairdocs.org/model/vulcanair-vulcanair-v1-0): 2 aircraft (registry code 6780114) ## STCs approved under this data sheet (5) - [STC SA02571SE](https://openairdocs.org/stc/SA02571SE): Installation of Garmin G500/G600 TXi Integrated Avionics System (Primary Flight Display, Multi-Function Display, and Engine Indicating System Display).. Garmin International Inc. - [STC SA12406WI](https://openairdocs.org/stc/SA12406WI): Installation of a Garmin AXIS Flight Display System. Garmin International Inc. - [STC SA02511SE](https://openairdocs.org/stc/SA02511SE): Installation of replacement fuel quantity indicator sending unit(s). CiES Inc. - [STC SA02658SE](https://openairdocs.org/stc/SA02658SE): Installation of Garmin GI 275 Multi-Function Display System. Garmin International Inc. - [STC SA01967WI](https://openairdocs.org/stc/SA01967WI): Use of GAMI G100UL High Octane Unleaded Avgas. General Aviation Modifications Inc. --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.