# TCDS A14EU: Hamburger Flugzeugbau G.m.b.H. - Type: Type certificate data sheet - Status: Historical - Holder: Hamburger Flugzeugbau G.m.b.H. - Revision: 6 - Revised: November 24, 2009 - Product: Aircraft, Large Airplane - Certification basis: Part 21, Part 25, Part 91, CAR 4b - Data sheet PDF: https://openairdocs.org/files/sha256/2a/36/2a3679683eeec467acd08d43661f4689d539debde0bd8217553db6069e148bfc - FAA DRS: https://drs.faa.gov/browse/excelExternalWindow/5AE47AFA5C097138862576800065DF58.0001 - Page: https://openairdocs.org/tcds/A14EU ## Models (1) As the data sheet lists them. - HFB 320 Hansa ## What the data sheet says From the PDF's text layer, line by line; tables lose their columns. The PDF is the record. ```text Page No. 1 2 3 4 5 6 Rev. No. 4 4 4 5 5 5 Surrendered October 27, 2009 DEPARTMENT OF TRANSPORTATION FEDERAL AVIATION ADMINISTRATION A14EU Revision 6 Hamburger Flugzeugbau HFB 320 HANSA November 24, 2009 TYPE CERTIFICATE DATA SHEET NO. A14EU This data sheet, which is a part of Type Certificate No. A 14EU, prescribes conditions and limitations under which the product for which the Type Certificate was issued meets the airworthiness requirements of the Civil Air Regulations. Type Certificate Holder Ha mburger Flugzeugbau G.m.b.H. (1) This TC was surrendered for cancellation on October 27, 2009. Only standard airworthiness certificates issued prior to October 27, 2009 are valid. (2) Future unsafe conditions existing in the aircraft may result in the revocation of the airworthiness certificates of the aircraft if there is no entity to comply with 14 CFR § 21.99(a), “Required design changes.” (3) Replacement parts may not be available in the future. I - Hamburger Flugzeugbau Model HFB 320 HANSA (Transport Aircraft), approved April 7, 1967 Engines 2 General Electric turbojet engines (See NOTE 7) CJ 610-1CJ 610-5 Fuel JP-1, JP-4, JP-5; in accordance with General Electric Specification D 50 T F 2 Class A, or later approved issue (See NOTE 3) Oil Synthetic oils in accordance with General Electric Specification D 50 T F 1-S 2 or later approved Issue. (See NOTE 4) Engine limits Take-off static thrust, (5 min.), standard day sea level 2850 lb. 2950 lb. Maximum Continuous thrust, standard day sea level 2700 lb. 2780 lb. Maximum permissible engi ne rotor operating speeds: Take-off (5 min.) 101.2% 16,700 rpm Max. Continuous 100.0% 16,500 rpm Maximum permissible e xhaust gas temperatures: Take-off (5 min.) 704°C 716°C Max. Continuous 677°C 702°C Max. Transient (10 secs.) 782°C 782°C Starting Transient (5 secs.) 854°C 854°C Max. permissible oil scavenge temp. 193°C 193°C Fuel and oil pressure limits: Fuel: Min., 5 psi above true fuel vapor pressure Max., 50 psi Oil: Min., 5 psig Max., 60 psig Maximum permissible air bleed extr actions: 6% of compressor output Airspeed limits (IAS) Vmo (Maximum operating) Sea level 320 kts 10,000 ft. 324 kts 15,000 ft. 327 kts A14EU 2 20,000 ft. 330 kts 22,500 ft. 333 kts Straight line variation between points Mmo 22,500 ft. and above M = 0,76 Maximum Take-Off Weight 19,400 lbs 20,280 lbs Va (Maneuvering) Sea level 202 kts 190 kts 10,000 ft. 203 kts 191 kts 20,000 ft. 205 kts 192 kts 30,000 ft. 208 kts 194 kts 38,000 ft. 210 kts 197 kts Straight line variation between points Vfe (Flap Extension) 13° and 20° 190 kts 50° 175 kts Vse (Slat Extension) 200 kts Vlo (Landing gear operation) 170 kts Extend and retract Vle (Landing gear extended) 170 kts Vab (Speed brake operating) 380 kts/0,83 M (See NOTE 5) Vdc (Drag chute extended) 3 - meter dia 150 kts 4 - meter dia 135 kts Vmc (Minimum control speeds) Sea level, ISA Flight 105 kts Ground 100 kts Maximum Take-Off Weight 19,400 lbs 20,280 lbs Tire limit speed (groundspeed) 146 kts 156 kts Datum Reference Datum is fuselage Frame No. 1, located at Body Station (B.S.) 3000 Leveling means No permanent fixture. Two spirit leve ls are used on cabin seat rails in accordance with procedure specified in HFB 320 Weight and Balance Manual Mean aerodynamic chord M.A.C. = 95.54 ins. (2427 mm) L.E. of M.A.C. at B.S. 10089 C.G. range Weight (lb) Forward Limit Aft Limit (Gear extended) All weights up to 10% MAC 23% MAC 15,400 lb (7000 kg) B.S. 10332 B.S. 10648 All weights between 13% MAC 23% MAC 16,500 lb (7500 kg) B.S. 10405 B.S. 10648 and 20,280 lb (9200 kg) Linear variation between points given Retracting gear moves C.G. forward 1,3% MAC Maximum weights (See NOTES 7 and 8) Taxi (Ramp) 19,620 lb (8900 kg) 20,500 lb (9300 kg) Take-off 19,400 lb (8800 kg) 20,280 lb (9200 kg) 3 A14EU Landing 18,520 lb (8400 kg) 19,400 lb (8800 kg) Zero fuel weight 15,870 lb (7200 kg) Minimum crew Two (Pilot and Copilot) Maximum passengers Twelve (See NOTE 6) Maximum baggage Pa ssenger configuration: 660 lbs. in compartment at aft end of passenger cabin, B.S. 11194 Limit compt. floor loading 61.44 lbs/sq ft. (See NOTE 6 for cargo configuration) Fuel capacity Usable fuel. (See NOTE 1 for unusable fuel) Applicable to SN 1023 to 1035 Applicable to SN 1036 and up LOCATION Arm Body Sta. No. Volume U.S. Gals Volume U.S. Gals Right or left tip tank (each) 9287 145.3 145.3 Right or left main wing tank 10982 310.4 310.4 (each) Fuselage tank 11534 165.1 181.2 Total (all tanks) 10609 1076.5 1092.6 Oil capacity Usable oil (U nusable oil is negligible) Location Arm Body Sta. No. Volume U.S. Galls Right or left tank (each) 13794 0.75 Maximum operating altitude 38,000 ft. Pressure Altitude Other operating limitations Aircraft sha ll be operated in compliance with the Operating Limitations specified in the Luftfahrt-Bundesamt (LBA) approved HFB 320 HANSA Airplane Flight Manual. Control surface movements Surface Travel Tolerance Elevator Up 19.5° + 0.5° Down 15.5° + 0.5° Rudder Right 19.5° + 0.5° Left 19.5° + 0.5° Ailerons Up 22.5° + 0.5° Down 17.5° + 0.5° Flaps (total) 50° Speed brakes 75° For detailed rigging instructions re fer to HFB 320 HANSA Maintenance Manual. Serial Numbers eligible A Luftfahrt- Bundesamt (LBA) Certificate of Airworthiness for Export, endorsed as noted below under import Requirements, must be submitted for each individual aircraft for which application for an FAA Certificate of Airworthiness is made. Certification basis FAR 21.29 and CAR 4b, da ted December 1953; Amendments 4b-1 through 4b-12 thereto; the provisions of Special Civil Ai r Regulation SR-422 B; Special Conditions of the Deutsche Versuchsanstalt fur Luft und Raumfahrt e.V. and Prufstelle fur Luftfahrtgerat (DVL - PfL) as listed in DVL-PfL report dated 21 March 1963 and HFB report dated 17 December 1963; and Special C onditions listed in Attachment A to FAA letter to Luftfahrt Bundesa mt (LBA) dated 17 January 1966. Type Certificate (Import) No. A14EU issued April 7, 1967 Date of Application for Type Certificate: February 6, 1963 A14EU 4 Compliance with the following additiona l requirements has been established: CAR Amendment 4b-14 CAR 4b.361 - Ditching CAR 4b.640 - Ice Protection FAR 25 Amendment 25.15 The LBA originally type certif icated this aircraft under its type certificate. The FAA validated this product under U.S. Type Ce rtificate Number A14EU. Effective September 28, 2003, the European Aviation Sa fety Agency (EASA) began oversight of this product on behalf of the LBA Import requirements A U.S. Certificate of Airworthiness may be issued on the basis of a Federal Republic of Germany Certificate of Airworthiness for E xport signed by an authorized representative of the Luftfahrt Bundesamt containing the following statement: "The airplane covered by this certificate has been examined and found to comply with U.S. Civil Air Regulation Part 4b- issued December 31, 1953, including amendments 4b-1 through 4b-12, additional requirements as stated unde r Certification Basis of Type Certificate Data Sheet No. A14EU, conforms to Type Certificate A14EU issued on April 7, 1967 or later revision and is airworthy". The FAA can issue a U.S. airworthine ss certificate based on an LBA Export Certificate of Airworthiness (Export C of A) signed by a representative of the LBA on behalf of the European Co mmunity. The Export C of A should contain the following statement: ‘The aircraft covered by this certificate has been examined, tested, and found to conform to the type desi gn approved under U.S. Type Ce rtificate No A14EU and to be in a condition for safe operation. Required equipment The basic required equipment as pres cribed in the applicable airworthiness and operating regulations must be installed in the aircraft for certification. A required Equipment List approved by Luftfahrt-Bundesamt is appended to the approved HFB 320 HANSA Airplane Flight Manual and contains under "Required Equipment" the minimum equipment required by the airworthiness regulations plus the additional equipment required for VFR/ IFR Day/Night operation under FAR Part 91. A current LBA-Approved HFB 320 HANSA Airpla ne Flight Manual must be carried on the aircraft at all times. Service information All HFB 320 HANSA Service Bulletins are approved by the Luftfahrt- Bundesamt, or an authorized representative of that authority , and carry a statement to that effect. Supplementary and important information for operation and maintenance are provided in: HFB 320 HANSA - Weight and Balance Manual - Operation Manual - Maintenance Manual - Structure Repair Manual - Illustrated Parts Catalog NOTES NOTE 1. (a) A current Weight and Balance Report including list of equipment in certificated empty weight and loading instructions, must be in each aircraft at the time of original certification and at all times thereafter. (b) The airplane must be loaded so that the C.G. is within the specified limits at all times. (c) The weight of system fuel as defined below and hydr aulic fluid must be included in the empty weight of the a i r p l a n e . (d) Unusable fuel Drainable unusable fuel is the am ount of fuel in the tanks which is not available for engine supply under critical flight conditions. This dr ainable unusable fuel does not include the trapped fuel in the tanks and the unusable fuel in the feed lines . The total unusable fuel must be included in the airplane empty weight. The total unusable fuel is distributed as follows: Applicable to SN 1023 to 1035 Volume Weight Arm Body 5 A14EU Location U.S. Gals . lb Station Fuselage tank (undrainable) 2.8 18.7 11515 Wing tanks (both) (undrainable) 2.6 17.6 11155 Tip tanks (both) (undrainable) 1.3 8.8 9345 Feedlines 1.8 12.1 13065 Fuselage tank (drainable) 3.3 22.1 11515 Wing tanks (both) (drainable) 7.0 46.3 11895 Tip tanks (both) (drainable) 3.3 22.1 9345 TOTAL unusable fuel 22.1 147.7 11267 Applicable to SN 1036 and up Fuselage tank (undrainable) 1.0 6.6 11515 Wing tanks (both) (undrainable) 5.3 35.3 11155 Tip tanks (both) (undrainable) 1.3 8.8 9345 Feedlines 1.8 12.1 13065 Fuselage tank (drainable) 0.7 4.4 11515 Wing tanks (both) (drainable) 6.6 44.1 11895 Tip tanks (both) (drainable) 3.3 22.0 9345 TOTAL unusable fuel 19.9 133.5 11267 NOTE 2. Service Life Limits Structural components of which the service life is restricted, are identified in the HFB 320 HANSA Maintenance Manual, Volume 5, and the approved airplane Flight Manual. NOTE 3. Approved fuels by brand designation for the CJ 610 - series engines are listed in the Operation Manual, section 14. NOTE 4. Approved oils by brand designation for the CJ 610 - series engines are listed in the Operation Manual, section 14. NOTE 5. Design speed for the speed brakes is Vd (380 kts, IAS) and Md (M - 0,83) In emergency the speed brakes may be operated up to this speed. NOTE 6. After removal of the passenger s eats and installation of the cargo net the aircraft may be used for cargo. For detail information with regard to the conversion from one version into the other refer to the Operation Manual. Max. allowable compartment loadings for the cargo configuration are: Floor loading Compt. Body Station Weight (lb) (lb/sq.ft.) Cabin 7315-10369 2,860 81.92 Baggage compt. 10369-12166 660 61.44 NOTE 7. Variations in engine configurations listed are elig ible by applying LBA approved Modification Kits or Service Bulletins. NOTE 8. Aircraft with CJ 610-1 engines are eligible fo r higher take-off weight by applying HFB Service Bulletins containing LBA approved AFM-Revision. In this case all weights, c.g. and speed data for 20,280 lbs maximum take-off weight apply. NOTE 9. The aircraft is eligible for a maximum operating altitude of 40,000 ft. by applying HFB Service Bulletin 28-13 and LBA approved AFM-Revision 19 (or subsequent LBA approved AFM Revisions). NOTE 10. SERVICE INFORMATION: Each of the documents listed below that contain a statement that it is approved by the European Aviation Safety Agency (EASA) - or for approvals made before September 28, 2003 - by the LBA., are accepted by the FAA and are considered FAA approved. These approvals pertain to the type design only. Hamburger Flugzeugbau G.m.b.H Service Bulletins, except as noted below, • Structural repair manuals • Vendor manuals referenced in Hamburger Flugzeugbau G.m.b.H]service bulletins • Aircraft flight manuals A14EU 6 • Repair Instructions • Design changes that are contained in Service Bulletins and are classified as level 1 major in accordance with the US Bilateral Aviation Safety Agreement Implementation Procedures for Airworthiness must be approved by the FAA .....END..... ``` ## ADs (8, in force first) - [AD 2006-03-16](https://openairdocs.org/ad/2006-03-16): HFB 320 Hansa Airplane Flight Manual · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective Mar 15, 2006 - [AD 2004-01-11](https://openairdocs.org/ad/2004-01-11): Elevator trim control cable assemblies · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective Feb 13, 2004 - [AD 88-03-05](https://openairdocs.org/ad/88-03-05): Wing Flaps, Slats, Speed Brakes · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective Feb 28, 1988 - [AD 84-10-05](https://openairdocs.org/ad/84-10-05): Surface Wing Structure · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective May 29, 1984 - [AD 84-06-04](https://openairdocs.org/ad/84-06-04): Stabilizer/Elevator Fittings · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective Apr 9, 1984 - [AD 83-10-04](https://openairdocs.org/ad/83-10-04): Horizontal Stabilizer Attachment Fittings · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective Jun 6, 1983 - [AD 76-09-04](https://openairdocs.org/ad/76-09-04): Nose Landing Gear Steering Torque · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective May 10, 1976 - [AD 76-07-13](https://openairdocs.org/ad/76-07-13): Camlocks · Hamburger Flugzeugbau G.m.b.H. HFB 320 Hansa. Effective Apr 26, 1976 ## Registered aircraft by registry model (OpenAirDocs) - [Hamburger Flugzeugbau HFB 320 HANSA](https://openairdocs.org/model/hamburger-flugzeugbau-hfb-320-hansa): 0 aircraft (registry code 4071204) ## STCs approved under this data sheet (4) - [STC SA01709CH](https://openairdocs.org/stc/SA01709CH): Reduced passenger seating from 8 to 4. Approved for HFB 320 HANSA, serial number 1037 ONLY.. Grand Aire Express, Inc - [STC SA985SW](https://openairdocs.org/stc/SA985SW): On-board ground air conditioner.. J W Miller Aviation Inc - [STC SA1877WE](https://openairdocs.org/stc/SA1877WE): Installation of Fairchild A-100 voice recorder, A-152 control unit and Fairchild flight data recorder system.. Hansa Jet Corporation - [STC SA1921WE](https://openairdocs.org/stc/SA1921WE): Installation of folding observer's jump seat in lieu of Hansa jump seat.. American Hansa Jet Corporation --- OpenAirDocs.org is an independent research project of [Contrail Labs](https://contraillabs.com/). It is not affiliated with the FAA or the NTSB. Source documents are U.S. government works in the public domain.