AD 2003-22-02

Airworthiness directive · High Pressure (HP) fuel tubes · Rolls-Royce RB211 Trent 556-61

Effective
November 14, 2003
Published
October 30, 2003 · 68 FR 61737–61739
Issued
October 20, 2003
Model
RB211 Trent 556-61
Data sheet
TCDSE00066EN
Registered aircraft
182 matched by model
Product
Engine
Amendment
39-13349
Docket
2003-NE-42-AD
Issued as
Final rule; request for comments

Unofficial copy from the Federal Register XML, document 03-27152. Only the govinfo PDF is the legal edition. DRS record last changed May 30, 2024.

On this page

Summary

The FAA is adopting a new airworthiness directive (AD) for certain Rolls-Royce (RR) plc RB211 Trent 556-61 turbofan engines. This AD requires a gauge inspection of the space between the high pressure (HP) fuel tubes adaptor face and seals, and a gauge inspection of the space between the fuel flow transmitter and seals, for evidence of permanent distortion of the face of the fuel tube connecting flanges, and replacement of parts if necessary. This AD is prompted by a report of fuel leaking from the engine fan cowl during an aircraft taxi. We are issuing this AD to prevent in-flight fuel leaks, which could result in an engine fire.

The airworthiness directive

2003-22-02 Rolls-Royce plc: Amendment 39-13349. Docket No. 2003-NE-42-AD.

(a) Effective Date

PDF page 3

(a) This airworthiness directive (AD) becomes effective November 14, 2003.

(b) Affected ADs

PDF page 3

(b) None.

(c) Applicability

PDF page 3

(c) This AD applies to all Rolls-Royce plc (RR) RB211 Trent 556-61 engines with serial numbers (SNs) before 71125, except for those SNs that are listed in the following Table 1 of this AD.

Table 1.—Engine SNs Not Affected by This AD
7100171003710067101271013
7101571016710177102071021
7102271023710327103771053
7106071064710687106971070
7107271073710747107671077
7107871079710807108371084
7108571086710877108871089
7109071091710927109371094
7109570196710977109871099
7110071101711027110471105
7110671107711087110971110
7111171112711137111471115
7111671117711187112071121
7112271123

These engines are installed on, but not limited to, Airbus A340 airplanes.

(d) Unsafe Condition

PDF page 3

(d) This AD is prompted by a report of fuel leaking from the engine fan cowl during an aircraft taxi. We are issuing this AD to prevent in-flight fuel leaks, which could result in an engine fire.

(e) Compliance

PDF page 3

(e) You are responsible for having the actions required by this AD performed within the compliance times specified unless the actions have already been done.

(f) Credit for Previous Compliance

PDF page 3

(f) For engines that have incorporated RR Alert Service Bulletin (ASB) No. RB.211-73-AE200, dated July 11, 2003, no further action is required.

(g) One-Time Gauge Inspections

PDF page 3

(g) Before further flight, gauge inspect the space between the high pressure (HP) fuel tubes adaptor face and seals and the space between the fuel flow transmitter and the seals for evidence of permanent distortion of the face of the fuel tube connecting flanges, and replace parts if necessary. Use paragraphs 3.A. through 3.B. of the Accomplishment Instructions of RR ASB No. RB.211-73-AE200, dated July 11, 2003, to do the inspections and parts replacements.

(h) Alternative Methods of Compliance

PDF page 3

(h) The Manager, Engine Certification Office, has the authority to approve alternative methods of compliance for this AD if requested using the procedures found in 14 CFR 39.19.

(i) Material Incorporated by Reference

PDF page 3

(i) You must use Rolls-Royce plc ASB No. RB.211-73-AE200, dated July 11, 2003, to perform the actions required by this AD. The Director of the Federal Register approved the incorporation by reference of this service bulletin in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. You can get a copy from Rolls-Royce plc, P.O. Box 31, Derby, England, DE24 8BJ; telephone: 011-44-1332-242424; fax: 011-44-1332-249936. You may review copies at the Federal Aviation Administration, New England Executive Park, or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

(j) Related Information

PDF page 3

(j) CAA airworthiness directive G-2003-0001, dated July 15, 2003, also addresses the subject of this AD.

Rule preamble

The FAA’s background, reasoning and cost estimate, published with the AD.

DatesPage 1

Effective November 14, 2003. The Director of the Federal Register approved the incorporation by reference of certain publications listed in the regulations as of November 14, 2003.

We must receive any comments on this AD by December 29, 2003.

AddressesPage 2

Use one of the following addresses to submit comments on this AD:

• By mail: The Federal Aviation Administration (FAA), New England Region, Office of the Regional Counsel, Attention: Rules Docket No. 2003-NE-42-AD, 12 New England Executive Park, Burlington, MA 01803-5299.

• By fax: (781) 238-7055.

• By e-mail: 9-ane-adcomment@faa.gov.

You can get the service information referenced in this AD from Rolls-Royce plc, P.O. Box 31, Derby, England, DE248BJ; telephone: 011-44-1332-242424; fax: 011-44-1332-249936.

You may examine the AD docket, by appointment, at the FAA, New England Region, Office of the Regional Counsel, 12 New England Executive Park, Burlington, MA. You may examine the service information, by appointment, at the FAA, New England Region, Office of the Regional Counsel, 12 New England Executive Park, Burlington, MA; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

For further information contactPage 2

James Lawrence, Aerospace Engineer, Engine Certification Office, FAA, Engine and Propeller Directorate, 12 New England Executive Park; telephone (781) 238-7176; fax (781) 238-7199.

Supplementary informationPage 2

The Civil Aviation Authority, (CAA), which is the airworthiness authority for the United Kingdom (U.K.), recently notified the FAA that an unsafe condition may exist on all RR plc RB211 Trent 556-61 engines with serial numbers (SNs) before 71125, except for those SNs that are listed in Table 1 of this AD. The CAA advises that fuel was observed running from the engine fan cowl doors during an aircraft taxi. Further investigation revealed the source of the fuel leak to be permanent distortion of the face of the fuel tube connecting flanges at the fuel flow meter resulting in a significant fuel leak, which could result in an engine fire. The CAA also advises that the distortion of the flange is not aggravated by service use, but by exposure to fuel pressures that extrudes the seal through the gap between the flanges.

Relevant service informationPage 2

We have reviewed and approved the technical contents of RR plc Alert Service Bulletin (ASB) RB.211-73-AE200, dated July 11, 2003, that describes procedures for the following:

• Gauge inspection of the space between the HP fuel tubes adaptor face and the seals, and replacement of the seal gasket and tube, if necessary; and

• Gauge inspection of the space between the fuel flow transmitter and the seals, and replacement of the seal gasket and tube, if necessary.

The CAA classified this service bulletin as alert and issued AD G-2003-0001, dated July 15, 2003, in order to ensure the airworthiness of these RR plc engines in the U.K.

Bilateral airworthiness agreementPage 2

This engine model is manufactured in the U.K. and is type certificated for operation in the United States under the provisions of section 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and the applicable bilateral airworthiness agreement. Under this bilateral airworthiness agreement, the CAA has kept the FAA informed of the situation described above. We have examined the findings of the CAA, reviewed all available information, and determined that AD action is necessary for products of this type design that are certificated for operation in the United States.

FAA's Determination and Requirements of This ADPage 2

Although no airplanes that are registered in the United States use these engines, the possibility exists that the engines could be used on airplanes that are registered in the United States in the future. The unsafe condition described previously is likely to exist or develop on other RR plc Trent 556-61 engines of the same type design. We are issuing this AD to prevent in-flight fuel leaks, which could result in an engine fire. You must use the service information described previously to perform the actions required by this AD.

FAA's Determination of the Effective DatePage 2

Since there are currently no domestic operators of this engine model, notice and opportunity for public comment before issuing this AD are unnecessary. Therefore, a situation exists that allows the immediate adoption of this regulation.

Changes to 14 CFR Part 39—Effect on the ADPage 2

On July 10, 2002, we issued a new version of 14 CFR part 39 (67 FR 47997, July 22, 2002), which governs our AD system. This regulation now includes material that relates to special flight permits, alternative methods of compliance, and altered products. This material previously was included in each individual AD. Since this material is included in 14 CFR part 39, we will not include it in future AD actions.

Comments invitedPage 2

This AD is a final rule that involves requirements affecting flight safety and was not preceded by notice and an opportunity for public comment; however, we invite you to submit any written relevant data, views, or arguments regarding this AD. Send your comments to an address listed under ADDRESSES. Include “AD Docket No. 2003-NE-42-AD” in the subject line of your comments. If you want us to acknowledge receipt of your mailed comments, send us a self-addressed, stamped postcard with the docket number written on it; we will date-stamp your postcard and mail it back to you. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the rule that might suggest a need to modify it. If a person contacts us verbally, and that contact relates to a substantive part of this AD, we will summarize the contact and place the summary in the docket. We will consider all comments received by the closing date and may amend the AD in light of those comments.

We are reviewing the writing style we currently use in regulatory documents. We are interested in your comments on whether the style of this document is clear, and your suggestions to improve the clarity of our communications with you. You may get more information about plain language at http://www.faa.gov/language and http://www.plainlanguage.gov.

Examining the AD DocketPage 2

You may examine the AD Docket (including any comments and service information), by appointment, between 8 a.m. and 4:30 p.m., Monday through Friday, except Federal holidays. See ADDRESSES for the location.

Regulatory findingsPage 2

We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that the regulation:

1. Is not a “significant regulatory action” under Executive Order 12866;

2. Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and

3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared a summary of the costs to comply with this AD and placed it in the AD Docket. You may get a copy of this summary by sending a request to us at the address listed under ADDRESSES. Include “AD Docket No. 2003-NE-42-AD” in your request.

Adoption of the amendmentPage 3

Accordingly, under the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

1. The authority citation for part 39 continues to read as follows:

2. The FAA amends § 39.13 by adding the following new airworthiness directive:

Affected TCDS · 1

The type certificate data sheets for the models this AD names, matched by model and maker.

Registered aircraft · 182

Registered aircraft whose airframe or engine model this AD names. Matched by model only, so check each against the AD’s applicability.

By aircraft maker
  • Boeing181 aircraft
  • Airbus1 aircraft
By year built
19822014
Registered aircraft by year built: 181 aircraft
19821
19831
19851
19873
19881
19894
19901
19914
19927
19931
199427
199515
19968
199713
199811
199924
200018
200126
20025
20034
20045
20141

1 with no year recorded

By model

Aircraft

See all 182 aircraft