AD 2006-15-18

Airworthiness directive · Wiring for the master dim and test system · Boeing 737-300 Series, 737-400 Series, 737-500 Series and 5 more

Effective
September 5, 2006
Published
July 31, 2006 · 71 FR 43037–43039
Issued
July 20, 2006
Models
737-300 Series, 737-400 Series, 737-500 Series, 737-600 Series, 737-700 Series, 737-700C Series, 737-800 Series, 737-900 Series
Data sheet
TCDSA16WE
Registered aircraft
825 matched by model
Product
Aircraft · Large airplane
Amendment
39-14699
Docket
FAA-2004-19245
Project
2004-NM-108-AD
Issued as
Final rule

Unofficial copy from the Federal Register XML, document E6-12099. Only the govinfo PDF is the legal edition. DRS record last changed May 30, 2024.

On this page

Summary

The FAA is adopting a new airworthiness directive (AD) for certain Boeing Model 737-300, -400, -500, -600, -700, -700C, -800, and -900 series airplanes. This AD requires modifying the wiring for the master dim and test system. For certain airplanes, this AD also requires related concurrent actions as necessary. This AD results from a report that the master dim and test system circuit does not have wiring separation of the test ground signal for redundant equipment in the flight compartment. We are issuing this AD to prevent a single fault failure in flight from simulating a test condition and showing test patterns instead of the selected radio frequencies on the communications panels, which could inhibit communication between the flightcrew and the control tower, affecting the continued safe flight of the airplane.

The airworthiness directive

2006-15-18 Boeing: Amendment 39-14699. FAA-2004-19245; Directorate Identifier 2004-NM-108-AD.

(a) Effective Date

PDF page 2

(a) This AD becomes effective September 5, 2006.

(b) Affected ADs

PDF page 2

(b) None.

(c) Applicability

PDF page 2

(c) This AD applies to Boeing Model 737-300, -400, and -500 series airplanes identified in Boeing Special Attention Service Bulletin 737-33-1132, Revision 2, dated September 8, 2005; and Model 737-600, -700, -700C, -800, and -900 series airplanes identified in Boeing Service Bulletin 737-33-1133, Revision 3, dated September 8, 2005; certificated in any category.

(d) Unsafe Condition

PDF page 2

(d) This AD results from a report that the master dim and test system circuit does not have wiring separation of the test ground signal for redundant equipment in the flight compartment. We are issuing this AD to prevent a single fault failure in flight from simulating a test condition and showing test patterns instead of the selected radio frequencies on the communications panels, which could inhibit communication between the flightcrew and the control tower, affecting the continued safe flight of the airplane.

(e) Compliance

PDF page 2

(e) You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done.

(f) Modification

PDF page 2

(f) Within 48 months after the effective date of this AD: Modify the wiring for the master dim test system in accordance with the Accomplishment Instructions of Boeing Special Attention Service Bulletin 737-33-1132, Revision 2, dated September 8, 2005 (for Model 737-300, -400, and -500 series airplanes); and Boeing Service Bulletin 737-33-1133, Revision 3, dated September 8, 2005 (for Model 737-600, -700, -700C, -800, and -900 series airplanes); as applicable.

(g) Actions Required To Be Accomplished Prior to or Concurrently With Paragraph (f) of This AD

PDF page 2

(g) Prior to or concurrently with accomplishment of paragraph (f) of this AD, do the actions specified in Table 1 of this AD, as applicable.

Table 1.—Prior/Concurrent Actions
For—Accomplish all actions associated with—According to the Accomplishment Instructions of—
Group 57 airplanes identified in Boeing Special Attention Service Bulletin 737-33-1132, Revision 2, dated September 8, 2005Installing an engine instrument system (EIS) andBoeing Service Bulletin 737-77-1022, Revision 1, dated October 26, 1989.
Modifying the advisory system for the EISBoeing Service Bulletin 737-77-1023, Revision 1, dated November 9, 1989.
Group 37 and 46 airplanes identified in Boeing Service Bulletin 737-33-1133, Revision 3, dated September 8, 2005Installing wiring for the test system for the audio control panel lampBoeing Service Bulletin 737-33-1121, Revision 1, dated December 19, 2002.
Group 2 airplanes identified in Boeing Service Bulletin 737-33-1121, Revision 1, dated December 19, 2002Installing splice SP896Boeing Service Bulletin 737-26A1083, Revision 1, dated November 15, 2001.
Group 39 airplanes identified in Boeing Service Bulletin 737-33-1133, Revision 3, dated September 8, 2005Installing a smoke detection and fire extinguishing system in the cargo compartmentBoeing Service Bulletin 737-26A1083, Revision 1, dated November 15, 2001.
Group 59 airplanes identified in Boeing Special Attention Service Bulletin 737-33-1132, Revision 2, dated September 8, 2005Replacing the very high frequency (VHF) and high frequency (HF) communications panels with radio control panelsBoeing Service Bulletin 737-23-1102, dated June 3, 1999.

(h) Actions Accomplished per Previous Issue of Service Bulletins

PDF page 3

(h) Actions accomplished before the effective date of this AD in accordance with the service bulletins identified in Table 2 of this AD are considered acceptable for compliance with the corresponding actions specified in this AD.

Table 2.—Previous Issues of Service Bulletins
Service BulletinRevision levelDate
Boeing Special Attention Service Bulletin 737-33-1133OriginalDecember 19, 2002.
Boeing Service Bulletin 737-33-1133Revision 1April 17, 2003.
Boeing Service Bulletin 737-33-1133Revision 2December 4, 2003.
Boeing Special Attention Service Bulletin 737-33-1132OriginalMarch 20, 2003.
Boeing Special Attention Service Bulletin 737-33-1132Revision 1March 4, 2004.

(i) Alternative Methods of Compliance (AMOCs)

PDF page 3

(i)(1) The Manager, Seattle Aircraft Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19.

(2) Before using any AMOC approved in accordance with § 39.19 on any airplane to which the AMOC applies, notify the appropriate principal inspector in the FAA Flight Standards Certificate Holding District Office.

(j) Material Incorporated by Reference

PDF page 3

(j) You must use the service information identified in Table 3 of this AD to perform the actions that are required by this AD, unless the AD specifies otherwise.

Table 3.—Material Incorporated by Reference
Service BulletinRevision levelDate
Boeing Service Bulletin 737-23-1102OriginalJune 3, 1999.
Boeing Service Bulletin 737-26A10831November 15, 2001.
Boeing Service Bulletin 737-33-11211December 19, 2002.
Boeing Service Bulletin 737-33-11333September 8, 2005.
Boeing Service Bulletin 737-77-10221October 26, 1989.
Boeing Service Bulletin 737-77-10231November 9, 1989.
Boeing Special Attention Service Bulletin 737-33-11322September 8, 2005.

Boeing Service Bulletin 737-77-1022, Revision 1, dated October 26, 1989, contains the following effective pages:

Page No.Revision level shown on pageDate shown on page
1, 3, 5-7, 10, 17, 28-55Revision 1Oct. 26, 1989.
2, 4, 8, 9, 11-16, 18-27OriginalJune 15, 1989.

The Director of the Federal Register approved the incorporation by reference of these documents in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Contact Boeing Commercial Airplanes, P.O. Box 3707, Seattle, Washington 98124-2207, for a copy of this service information. You may review copies at the Docket Management Facility, U.S. Department of Transportation, 400 Seventh Street, SW., Room PL-401, Nassif Building, Washington, DC; on the Internet at http://dms.dot.gov; or at the National Archives and Records Administration (NARA). For information on the availability of this material at the NARA, call (202) 741-6030, or go to http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html.

Rule preamble

The FAA’s background, reasoning and cost estimate, published with the AD.

DatesPage 1

This AD becomes effective September 5, 2006.

The Director of the Federal Register approved the incorporation by reference of certain publications listed in the AD as of September 5, 2006.

AddressesPage 1

You may examine the AD docket on the Internet at http://dms.dot.gov or in person at the Docket Management Facility, U.S. Department of Transportation, 400 Seventh Street, SW., Nassif Building, Room PL-401, Washington, DC.

Contact Boeing Commercial Airplanes, P.O. Box 3707, Seattle, Washington 98124-2207, for service information identified in this AD.

For further information contactPage 1

Binh Tran, Aerospace Engineer, Systems and Equipment Branch, ANM-130S, FAA, Seattle Aircraft Certification Office, 1601 Lind Avenue, SW., Renton, Washington 98057-3356; telephone (425) 917-6485; fax (425) 917-6590.

Examining the DocketPage 1

You may examine the AD docket on the Internet at http://dms.dot.gov or in person at the Docket Management Facility office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Management Facility office (telephone (800) 647-5227) is located on the plaza level of the Nassif Building at the street address stated in the ADDRESSES section.

DiscussionPage 1

The FAA issued a supplemental notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to certain Boeing Model 737-300, -400, -500, -600, -700, -700C, -800, and -900 series airplanes. That supplemental NPRM was published in the Federal Register on May 26, 2006 (71 FR 30346). That supplemental NPRM proposed to require modifying the wiring for the master dim and test system. For certain airplanes, the supplemental NPRM also proposed to require related concurrent actions as necessary.

CommentsPage 1

We provided the public the opportunity to participate in the development of this AD. We have considered the single comment received. The commenter, Boeing, supports the supplemental NPRM.

ConclusionPage 1

We have carefully reviewed the available data, including the comment received, and determined that air safety and the public interest require adopting the AD as proposed in the supplemental NPRM.

Costs of CompliancePage 1

There are about 2,868 airplanes of the affected design in the worldwide fleet. This AD will affect about 1,181 airplanes of U.S. registry. The following table provides the estimated costs for U.S. operators to comply with this AD.

Estimated Costs
Boeing Service BulletinWork hoursAverage labor rate per hourPartsCost per airplaneFleet cost
737-33-1132, Revision 214$80Nominal$1,120$1,322,720
737-33-1133, Revision 3380Nominal240283,440
Estimated Concurrent Service Bulletin Costs
Boeing Service BulletinWork hoursAverage labor rate per hourPartsCost per airplaneNumber of U.S.-registered airplanesFleet cost
737-26A1083, Revision 1185$80Between $30,000 and $36,400Between $44,800 and $51,2001Between $44,800 and $51,200.
737-33-1121, Revision 1Between 5 and 6$80Between $200 and $340Between $600 and $82083Between $49,800 and $68,060.
737-77-1022, Revision 172$80No charge$5,7604$23,040.
737-77-1023, Revision 1Between 1 and 3$80NominalBetween $80 and $24026Between $2,080 and $6,240.
737-23-110277$80$22,164$28,3240No fleet cost unless an affected airplane is imported and placed on the U.S. register.
Authority for This RulemakingPage 2

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, “General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory findingsPage 2

We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that this AD:

(1) Is not a “significant regulatory action” under Executive Order 12866;

(2) Is not a “significant rule” under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and

(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket. See the ADDRESSES section for a location to examine the regulatory evaluation.

Adoption of the amendmentPage 2

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

1. The authority citation for part 39 continues to read as follows:

2. The Federal Aviation Administration (FAA) amends § 39.13 by adding the following new airworthiness directive (AD):

Affected TCDS · 1

The type certificate data sheets for the models this AD names, matched by model and maker.

Registered aircraft · 825

Registered aircraft whose airframe or engine model this AD names. Matched by model only, so check each against the AD’s applicability.

By aircraft maker
  • Boeing825 aircraft
By year built
19862025
Registered aircraft by year built: 791 aircraft
19862
19873
19892
19901
19915
19924
19934
19941
19953
19972
199840
199987
200072
200183
200212
20037
200413
200514
200621
200721
200826
200938
201062
201121
201230
201331
201423
201520
201642
201772
201827
20252

34 with no year recorded

By model

See all 32 models

Aircraft

See all 825 aircraft