AD 2023-21-06

This airworthiness directive (AD) is effective December 11, 2023.

None.

This AD applies to Embraer S.A. Model EMB-505 airplanes, as identified in Agência Nacional de Aviação Civil (ANAC) AD 2023-05-03, effective June 2, 2023 (ANAC AD 2023-05-03), certificated in any category.

Joint Aircraft System Component (JASC) Code 2500, Cabin Equipment/Furnishings.

This AD was prompted by analysis of certain monuments (the right-hand refreshment center and left-hand forward cabinet) that identified the need for installing structural reinforcements and replacing applicable floor support rivets. The FAA is issuing this AD to address the unsafe condition. The unsafe condition, if not addressed, could result in a monument not withstanding the loads expected for specific emergency landing conditions, which may cause the detachment of mass items and result in injuries to the airplane occupants.

Comply with this AD within the compliance times specified, unless already done.

Except as specified in paragraphs (h) and (i) of this AD: Comply with all required actions and compliance times specified in, and in accordance with, ANAC AD 2023-05-03.

(1) Where ANAC AD 2023-05-03 refers to its effective date, this AD requires using the effective date of this AD.

(2) The service information referenced in ANAC AD 2023-05-03 allows the use of alternative or similar parts in place of the ones specified in the kits, provided that these alternative or similar parts are approved by Embraer. This AD requires approval from either the Manager, International Validation Branch, FAA; ANAC; or ANAC's authorized Designee. If approved by the ANAC Designee, the approval must include the Designee's authorized signature.

(3) Where the service information referenced in ANAC AD 2023-05-03 specifies discarding parts, this AD requires removing those parts from service.

(4) This AD does not adopt paragraph (d) of ANAC AD 2023-05-03.

Although the service information referenced in ANAC AD 2023-05-03 specifies to submit certain information to the manufacturer, this AD does not include that requirement.

The Manager, International Validation Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the International Validation Branch, mail it to the address identified in paragraph (k) of this AD or email to: 9-AVS-AIR-730-AMOC@faa.gov. If mailing information, also submit information by email. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local Flight Standards District Office/certificate holding district office.

For more information about this AD, contact Jim Rutherford, Aviation Safety Engineer, FAA, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; phone: (816) 329-4165; email: jim.rutherford@faa.gov.

(1) The Director of the Federal Register approved the incorporation by reference of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.

(2) You must use this service information as applicable to do the actions required by this AD, unless the AD specifies otherwise.

(i) Agência Nacional de Aviação Civil (ANAC) AD 2023-05-03, effective June 2, 2023.

(ii) [Reserved]

(3) For ANAC AD 2023-05-03, contact ANAC, Continuing Airworthiness Technical Branch (GTAC), Rua Doutor Orlando Feirabend Filho, 230—Centro Empresarial Aquarius—Torre B—Andares 14 a 18, Parque Residencial Aquarius, CEP 12.246-190—São José dos Campos—SP, Brazil; phone: 55 (12) 3203-6600; email: pac@anac.gov.br; website: anac.gov.br/en/. You may find this material on the ANAC website at sistemas.anac.gov.br/certificacao/DA/DAE.asp.

(4) You may view this service information at the FAA, Airworthiness Products Section, Operational Safety Branch, 901 Locust, Kansas City, MO 64106. For information on the availability of this material at the FAA, call (817) 222-5110.

(5) You may view this material at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, visit www.archives.gov/federal-register/cfr/ibr-locations or email fr.inspection@nara.gov.