CHI94FA128

The instrument rated private pilot was on the return leg of his first actual IFR flight, 3 days after completing his instrument-airplane checkride. He had accumulated 2 hours of actual IFR flight time prior to this flight. The examiner, who had failed him on his initial checkflight 2 weeks prior to the successful check, stated that the applicant tended to get overloaded by communications in addition to navigation and aircraft control. Weather at the destination was between 500-1 and 400-1/2 in blowing snow, with winds gusting to 30 knots. Approach minimums were 500-1. Communications with ARTCC were difficult throughout the flight. The radar track was circuitous, did not follow the published approach or missed approach, and depicted a descending spiral for the final 3 minutes of the flight. During these turns, the pilot stated he was proceeding to his alternate. The flap actuator was found in the fully extended position. No discrepancies were noted in the flight instruments, pitot-static system, or engines.

History of flight

On April 4, 1994, at 1313 hours mountain daylight time, a Piper PA-23-250 Aztec, N5399Y, owned by James W. Furman of Alliance, Nebraska, impacted level terrain 10.5 miles southwest of Alliance, Nebraska. The airplane was destroyed. The instrument rated private pilot and the non-pilot passenger received fatal injuries. Instrument meteorological conditions (snow and fog) prevailed at the time of the accident, and an IFR flight plan was filed. The flight was conducted under 14 CFR Part 91, and originated from Mitchell, South Dakota, at 1130 hours.

The airplane was refueled with 66.7 gallons of 100LL aviation gasoline at Alliance (AIA) prior to the original departure on April 4, 1994. The airplane was reported as "topped off." It was refueled with 50.6 gallons of 100LL aviation gasoline at Mitchell, South Dakota, prior to the return trip, and again was reported as "topped off." The fuel capacity of the airplane was 144 gallons.

The pilot reported executing a missed approach at Alliance Municipal Airport and was cleared to his alternate, Scottsbluff Municipal Airport, Scottsbluff, Nebraska when the Denver Air Route Traffic Control Center (ARTCC) reported radar contact was lost.

ARTCC radar data was plotted to reproduce a ground track. This track was produced both on a data chart, and also overlayed onto a low altitude sectional chart depicting ground path as compared to the Victor-100 Airway. This ground path was consistently south of Victor-100 while inbound to the AIA VOR, and circuitous after passing AIA VOR. The ground track did not follow the published VOR-30 approach course. The ground track after the pilot stated he did not break out did not follow the published missed approach procedure.

Personal information

The 33 year old pilot held private pilot certificate number 506749759, with privileges for single and multiengine flight. He had a total time of 191 hours at the time of the accident, with 97 hours in the accident airplane. He held a third class medical certificate without limitations. His most recent flight review took place on April 1, 1994, 3 days before the accident, and was performed in the accident airplane. This was a flight check for his instrument-airplane rating, and was the second attempt to complete this checkride. The failure had occurred on March 24, 1994. According to the Designated Pilot Examiner who administered both flight checks, the failure was due to the applicant's inability to satisfactorily perform holding maneuver entries. The examiner stated during an interview on April 7, 1994, that the pilot tended to become overloaded by radio communications when combined with aircraft control and navigation duties, although his ability to perform the required maneuvers was satisfactory on April 1, 1994.

A co-owner of the airplane stated that the pilot was both cautious, and not comfortable flying without another pilot on board. The same owner reported that the pilot did not use the autopilot.

Prior to the accident flight, the pilot had accrued 34.5 hours of simulated instrument flight, and 2.5 hours of actual instrument flight.

Aircraft information

The airplane was a Piper PA-23 Aztec, serial number 27-2474, and had accrued 2835 hours at the time of the accident. The last inspection performed was an annual inspection performed on February 22, 1994, 26 flight hours prior to the accident. Both engines had total times of 2835 hours. The left engine had accrued 420 hours since overhaul. The right engine had accrued 1900 hours since overhaul.

The airplane was equipped with hydraulic flaps which were extended and retracted by a single actuating cylinder located on the right flap.

The airplane had an Altimatic II Autopilot (Model AK090).

The autopilot had been diagnosed on June 4, 1992 with 2 discrepancies:

(1) "Autopilot causes aircraft to climb when on." (2) "Altitude hold inop."

The corrective action listed was:

"No bench check or repair capability"

No other maintenance actions were located which concerned the autopilot system.

One of the owners of the airplane indicated that in June 1993, the autopilot was tested by himself. He stated that it would work, then climb. The rotary on/off knobs would engage between the 2 and 4 o'clock positions.

The Altimatic II Operating Instructions state "to disengage the Altimatic, rotate the Pitch and Roll knobs on the Console counterclockwise to the "OFF" position."

SECTION IV - EMERGENCY PROCEDURES of the Pilot Operating Handbook states:

1. In event of a malfunction, turn both pitch and roll servo knobs completely counterclockwise, disengaging both axes of altimatic from the control system.

2. Altimatic may be overpowered by exertion of 16 +/- 3 pounds of force on either control wheel for roll servo, and 14 +/- 3 pounds of force fore or aft on either control wheel for pitch servo.

Meteorological information

Instrument meteorological conditions prevailed at the time of the accident, with the destination airport observation reporting a ceiling of 400 foot obscured with 1/2 mile visibility in blowing snow and fog. Winds were reported from 360 degrees at 20 knots gusting to 30 knots. Within the previous hour, several aircraft had attempted to land at Alliance, were unable, and had executed missed approaches. The Denver ARTCC sector 31 controller who was working the accident airplane stated that at the time he cleared the accident airplane to Scottsbluff (the requested alternate) to hold, there were "8 or 9 holding, with no ice reports." One aircraft was holding at Scottsbluff at that time.

A weather report provided to N5399Y by Huron AFSS while obtaining his IFR clearance included "the Huron radar are indicating a widespread area of a coverage of 1/10 coverage of heavy rain showers 7/10 coverage of light rain with snow increasing in intensity from 95 miles east of Huron to 95 miles west of Huron the area is 85 miles wide from north to south of that line with cell movement from 270 at 20 max tops 22,000 feet 21 miles south of Huron..." (See appended ZDV-ARTCC-128 Formal Accident Package dated April 4, 1994)

A "Weathermation" forecast dated April 04, 1994 at 1251z, which was located in the airplane read as follows: AIA: Unavailable BFF: 13z 25 SCT C60 OVC 3615G25 CHC 3RW- 21z C30 OVC 0120G30 OCNL C15 OVC 3R-S-F 02z IFR CIG S WIND

The AIA recorded observations (SA) were:

1815z SP W5X 1S-F /32/31/3620/977 1850z RS W4X 1/2SF/30/29/3620/979 1915z SP E7OVC 11/2S-F/30/28/3619/982

The time of the accident was 1913z.

The closest precision approach was located at Scottsbluff, Nebraska, 40 nautical miles on a heading of 242 degrees magnetic from Alliance. Weather observations (SA) at Scottsbluff were:

RS 1750z M2OVC 1/4S-F 090/32/32/3512/980/PRFSRR SP 1805z M8OVC 1S-F 3615/982 RS 1850z M13BKN 36BKN 65OVC 1S-F 100/32/30/0116/983 SP 1935z 18SCT M37OVC 15 0220/987

No icing reports were received from aircraft below 10,000 feet msl.

A Center Weather Advisory (CWA01) was in effect from 041745z to 041945z in an area bounded by LAR-PUB-LAA-BFF-LAR for airspeed fluctuation of +/- 10-15 kts due to strong and shifting low level winds with strong winds aloft. (See appended, ZDV-ARTCC-128 Formal Accident Package dated April 4, 1994) AIDS TO NAVIGATION

The flight was conducted on an instrument flight plan. The destination airport, Alliance (AIA), was served by non-precision VOR and NDB approaches, with both straight in and circling Minimum Descent Altitudes of 4420 msl. Required weather minimums for these approaches were 500 foot ceilings and 1 statute mile visibility. There were no reports before or after the accident of discrepancies with these navaids.

The alternate airport, Scottsbluff, Nebraska (BFF),