DCA25LA120

NTSB accident investigation · Bombardier CL-600-2B19 · Chicago, IL · February 2, 2025

Accident · Serious injuriesClass 4 · LimitedFinal report
Date
February 1, 2025, 19:02 local (Feb 2, 2025, 01:02 UTC)
Place
Chicago, IL
Injuries
1 serious, 13 uninjured; on the ground: 1 serious
Damage
Substantial damage
Phase of flight
Taxi
Aircraft
N420AWBombardier CL-600-2B19
Defining event
Taxi-from runway: Ground collision
Weather
Visual (VMC) · Night
Status
Completed
Report
Approved by Office Director
Investigation class
Class 4 - Basic report with no Prelim publish
NTSB office
Major Investigations Division
Parties
FAA
FAA report
20250201000859A
Case key
199663

From the NTSB’s public API. By law, NTSB reports can’t be used as evidence in lawsuits over the accident.

On this page

Probable cause

The tug driver’s failure to ensure the taxiway was clear of aircraft prior to crossing, resulting in a collision with the left wing of the taxiing aircraft. Contributing to the accident was the limited visibility of the aircraft due to ambient lighting conditions and the absence of the aircraft’s nose-gear light, which reduced the tug driver’s ability to detect the aircraft’s presence in time to avoid the collision.

Findings · 2

NTSB’s coded findings. Those marked are part of the probable cause; the rest are factors or other findings. Under each, the cases with the same finding.

Sequence of events

The events NTSB coded, in order, by phase of flight. The defining event is the one that best describes the accident. Under each, the cases with the same event anywhere in their sequence.

Analysis

A serious injury was sustained by a tug driver following a collision with the left wing of Air Wisconsin flight 6181, a CRJ-200, during taxi operations at Chicago O’Hare International Airport (ORD). No injuries were reported among the airplane’s crew or passengers. Night visual meteorological conditions (VMC) prevailed at the time of the accident. Flight 6181 landed at ORD and was initially held at the B Pad for an open gate (see Figure 1). Once cleared, the aircraft proceeded southbound on Taxiway A under a standard clearance. The first officer was actively monitoring both ramp and ground control frequencies during the taxi. The captain reported first observing the tug on Taxiway B as the tug began crossing at the access road. The tug appeared to be slowing down suggesting an intent to stop. The captain could not recall whether the tug’s headlights were illuminated and believed he saw the vehicle using ambient lighting. After briefly diverting attention toward the gate area, the captain looked back and recognized an imminent collision with the tug. Braking was initiated immediately by the captain, but the impact occurred shortly thereafter. The captain described the impact as “not that bad” and believed the tug had struck the wingtip. The flight crew then communicated with the flight attendants, followed by dispatch via the Aircraft Communications Addressing and Reporting System (ACARS). According to the tug driver, while returning from the international terminal, the vehicle approached the service road leading to the L gates. Before entering the road and crossing taxiway B, the tug came to a complete stop at the designated stop sign and the driver observed an airplane taxiing outbound on Taxiway B. The driver checked both directions and waited until the outbound aircraft cleared the taxiway. The driver also verified that no aircraft were approaching from behind or the opposite direction before proceeding to cross the taxiways (A&B). The driver stated that as the tug was crossing the taxiways, the left wing of flight 6181, approaching on taxiway A, was not visible until the last moment, leaving insufficient time to react. He also noted the absence of a nose-gear light on flight 6181, which may have contributed to the tug driver not detecting the presence of flight 6181 before the collision. Figure 1. Ground position tracks for flight 6181 with respect to taxiways A & B. The collision resulted in the tug overturning and trapping the driver, leading to serious injury. Post-flight inspection revealed substantial damage to the leading-edge front spar of the airplane’s left wing. The tug driver emphasized that had he been aware of the airplane’s presence, he would not have entered the intersection. Figure 2. Damage to the aircraft (Source FAA). Figure 3. Damage to the tug (Source FAA). According to the Chicago Department of Aviation (CDA) ground motor vehicle operating regulations manual, dated August 2023, a driver must stop prior to initiating thecrossing of the taxiways A, B, and V to determine if the crossing could be accomplished without stopping in the islands between the taxiways. Vehicles on service roads must yield to vehicles crossing taxiways.

Aircraft

Registration
N420AW
Reported as
Bombardier CL-600-2B19
Category
Airplane
Serial number
7640
Built
2002
Airframe hours
45,460
Engines
GE CF34 SERIES, 9,140 lbs thrust, turbo fanGE CF34 SERIES, 9,140 lbs thrust, turbo fan
Damage
Substantial damage
Flight
Part 121
Operator
Air Wisconsin Airlines LLC, doing business as American Eagle
Registered owner
Air Wisconsin Airlines LLC
Airworthiness certificate
Standard, Transport
Last inspection
Continuous airworthiness · May 5, 2023
Departed
AZO · Kalamozoo, MI
Destination
Same as departure
Flight plan
IFR
Airport
ORD · Chicago O'Hare International Airport
Equipment
Electronic primary flight display, Electronic multifunction display, Data recorder, ADS-B, Stall warning system

Matched to the registry by N-number and the event date; the registry’s history has gaps, so older matches can be wrong. Compare the reported make and model.

Flight crew · 2

As NTSB recorded them. NTSB leaves out names.

Role
Pilot
Age
51
Injuries
None
Certificates
Airline transport, Commercial
Airplane ratings
Single-engine land, Multi-engine land
Instrument ratings
Airplane
Medical
Class 1, Without waivers/limitations
Last flight review
December 15, 2024
Seat
Left
Restraint
5-point
Flight hours
17,000 total · 14,500 in this make and model · 15,000 as pilot in command · 132 in the last 90 days · 37 in the last 30 days · 4 in the last 24 hours
Role
Co-pilot
Age
27
Injuries
None
Certificates
Commercial, Flight instructor, Airline transport
Airplane ratings
Single-engine land, Multi-engine land
Instrument ratings
Airplane
Medical
Class 1, With waivers/limitations
Seat
Right
Restraint
5-point
Flight hours
1,190 total · 259 in this make and model · 745 as pilot in command · 57 in the last 90 days · 25 in the last 30 days · 4 in the last 24 hours

Weather

Conditions
Visual (VMC) · Night
Wind
120° at 11 knots
Visibility
11.5 statute miles

Docket · 3

The files NTSB released with the investigation on September 10, 2025, on NTSB’s docket system: statements, records, photos and specialists’ reports. 5.4 MB in all.

FAA reports on this event · 1

The FAA’s own accident and incident reports, matched to the aircraft by N-number and date.