MIA97FA152

While circling flying southbound, the engine was heard to run for about 4-5 seconds then quit for about 2-4 seconds with the cycle repeated. An approximate 600-acre sod farm was located 1.29 nautical miles west of the location of the airplane at that time. The airplane was observed to continue flying southbound while circling then the airplane was observed flying low over trees and circled 2 times over a field sparsely occupied by trees. The airplane then rolled inverted and impacted the ground slightly inverted. Examination of the flight controls revealed no evidence of preimpact failure or malfunction. Examination of the engine revealed that the mixture control cable was separated from the control arm at the servo fuel injector. A non-aviation washer was used in the mixture control cable installation and was found failed. The cable attach hardware was in place. No engine mechanical failure or malfunction was noted. Bench testing of the impact damaged servo fuel injector revealed the fuel flow to momentarily remain high when the throttle was reduced. Disassembly of the servo revealed that the fuel diaphragm stem was bent. The fuel servo was last overhauled in 1991, and the fuel diaphragm was reportedly replaced at that time but the part number of the installed unit at the time of the accident was not the same as the diaphragm after replacement.

History of flight

On May 2, 1997, about 1313 eastern daylight time, a Bellanca 8KCAB, N5057F, registered to a private owner, crashed into an open field near New Smyrna Beach, Florida. Visual meteorological conditions prevailed and no flight plan was filed for the 14 CFR Part 91 personal flight. The airplane was substantially damaged and the airline transport pilot, the sole occupant, was fatally injured. The flight originated about 1238 from Spruce Creek Airport, Daytona Beach, Florida.

A friend of the pilot observed him in the front seat of the airplane and stated that the engine was started after two or three attempts then while the pilot was taxiing to the runway, the pilot waved to him. The weather conditions at the time were reported to be "CAVU", a term used to describe unlimited ceiling and visibility; everything appeared normal.

A pilot-rated witness who was at his residence which was located 1.33 nautical miles due north of the crash site reported first hearing the engine which would run for 4-5 seconds then quit for 2-4 seconds then the cycle started again. The airplane at that time was just south of his house about 400-500 feet above ground level. The engine power interruption continued for about 4 minutes during which time while the engine was operating, the pilot would attempt to climb while circling. The circling continued while flying southbound and he reported occassionally losing sight of the airplane only to observe it climbing above the tree line. He estimated that during the flight the airspeed was 70-90 knots and while circling the bank angle was no more than 20-30 degrees. The last time he observed the airplane he estimated it was at 200 feet above ground level flying westbound. He did not witness the accident and reported a scattered layer of clouds at 3,500 to 4,000 feet. He further stated that there is a sod farm located west of his house. The distance from his house to a point about 300 yards west of the western edge of the approximate 600 acre sod farm was determined to be 1.29 nautical miles.

Several other witnesses closer to the crash site reported seeing the airplane circling two times low over the trees. One of the witnesses observed the airplane attempt to pull up then observed the airplane "...instead went down 'head' propeller forward." The other witnesses reported seeing the airplane go inverted then descend vertically to impact with the ground.

Personnel information

Information pertaining to the pilot is contained on page 3 of the Factual Report-Aviation. Additionally, his pilot logbook was not located therefore his flight time experience could not be exactly determined. According to his last FAA medical application form dated October 19, 1995, he indicated that he had a total civilian pilot time to date of 22,500 hours with 50 hours flown in the previous 6 months. According to his son who is a certified flight instructor, he gave his father a Biennial Flight Review in January 1997, in the accident airplane.

According to personnel who worked with or for the pilot in a cleaning business he owned, on the day of the accident, the pilot did not follow his routine of having a daily cup of coffee with an employee and he also reportedly tore up "IOU" notes from employees who owed him money. Additionally, on the day after the accident, an employee found a birthday card envelope in the freezer which was located in the back of the store that was owned by the pilot. The envelope was inscribed with "Dad" and "Thanks for the wonderful memories God knows I Love you both so much.We had a Hellava' good ride didn't we! Don't take life too seriously, its only a temporary place.I'll wait for you on the other side.Dad.-------. The envelope was reportedly given to the pilot as part of a birthday card a year earlier. The individual who found the note stated that the writing which followed the word "Dad" was written by the pilot to his son and daughter-in-law. The individual who turned the note over to the Sheriff's Department investigator reported that the pilot's son and wife asked him not to talk to anyone. Another employee was also asked by the pilot's son, wife, and daughter-in-law not to talk to any investigator about the crash.

The envelope was analysed by personnel from the Volusia County Sheriff Department personnel and compared to known handwritten documents by the pilot. The handwriting style was similar.

Aircraft information

Information pertaining to the airplane is contained on page 2 of the Factual Report-Aviation. Review of the provided maintenance records (airframe and engine logbook) revealed that they contained information from the first production test flight to an entry dated April 1, 1991, in which the entry indicated that the airplane was inspected in accordance with an annual inspection. Additional Aircraft Logbook information from April 29, 1991, to January 14, 1992, was reviewed which revealed that there was no record of another annual inspection. Additionally, on June 25, 1991, the maintenance records reflects that the servo fuel injector was removed for overhaul. According to paperwork from the facility that overhauled the servo fuel injector, in part, the fuel diaphragm was replaced.

According to the pilot's son, the airplane was last inspected in accordance with an annual inspection in May of 1996, by an unknown person. No determination could be made as to who last inspected the airplane. The pilot's son further stated that the last time he flew the airplane "was approximately 3 weeks maximum prior to the day of 2 May 97" and "I had no problems with the aircraft (airframe or engine) during this flight." That was the last time he had observed the aircraft and engine logs which were located inside the airplane. According to the owner of a fixed base operator at the departure airport, review of their records revealed that no work was done by his facility to the accident airplane between July 1, 1996, and May 4, 1997, when he was asked for maintenance information on that day by the NTSB Investigator-In-Charge.

Meteorological information

Visual meteorological conditions prevailed in the area at the time of the accident. Additional weather information is found on page 4 of the Factual Report-Aviation.

Wreckage and impact information

Examination of the accident site revealed that the airplane crashed into a field which sparsely contained trees and was located 5.85 nautical miles and 200 degrees from the departure airport. The airplane was observed to be nearly inverted with the wings slightly greater than perpendicular to the ground with the empennage inverted and displaced to the left. All components necessary to sustain flight were in the immediate vicinity of the crash site. The airplane was observed on a magnetic heading of about 190 degrees. Chordwise crushing was noted to both wings and ground scars from the wing tips, wing leading edges, and both main landing gears was noted. No fire was noted but browning of grass was noted north of both wings. Examination of the rudder flight controls revealed control cable continuity from the control surface to the rear seat rudder pedals. Continuity to the front seat rudder pedals was also verified. Examination of the aileron and elevator flight control cables revealed continuity at each control surface to the rear seat control but the attach points at the rear control stick were failed. Examination of the fracture surfaces exhibited evidence of overload failure. Examination of the rudder revealed a hole in the fabric on the left lower side of the rudder nearly in-line with the position light. The hole corresponded with the trim tab attach hardware for the left elevator trim tab. The left elevator was observed to be displaced down near the tip and the outboard portion of the left elevator trim tab was observed to be disp