MIA97LA087

The copilot stated the PIC had requested a lower altitude and switched the fuel tanks from the main fuel tank to the auxiliary fuel tank position. The engines sputtered, and they switched back to the main fuel position. The PIC informed ATC, 'sir we are running out of fuel now.' A witness heard the engines sputter and saw the airplane approaching his position at tree top level. The airplane made a left turn followed by a steep bank to the right and disappeared from view below the tree line. Examination of the crash site revealed the left fuel selector was in the main fuel position. The right fuel selector was found loosely in-between the auxiliary and main fuel position. Disassembly of both engines revealed no evidence of a precrash mechanical failure or malfunction. Examination of the left propeller revealed it was operating under low power at impact, and was probably windmilling. The right propeller was operating under conditions of higher power at impact. Neither propeller was in the feather position or were in the vicinity of the low pitch stop at impact.

On February 27, 1997, about 0250 eastern standard time (EST), a Cessna 310R, N72GL, Skibble 840 (SBQ840), registered to SmithKline Beechman Clinical Laboratories, operating as a 14 CFR Part 91 corporate flight, crashed in the vicinity of Calhoun, Georgia, during a forced landing. Instrument meteorological conditions prevailed and an IFR flight plan was filed. The airplane was destroyed by a post crash fire. The airline transport pilot-in-command (PIC), and airline transport copilot (CP) sustained serious injuries. The flight originated from New Orleans, Louisiana (NEW), about 2 hours 49 minutes before the accident.

The PIC stated he was scheduled to depart Lawrenceville, Georgia (LZU), at 1930 EST en route to Jackson, Mississippi (JAN). The flight time was scheduled for 2 hours en route. No fuel was purchased at JAN. He was scheduled to depart JAN at 2115 central standard time (CST) en route to NEW with 50 minutes en route. He was scheduled to take on 70 gallons of fuel, and depart NEW at 2215 CST en route to LZU. The flight time was scheduled for 2 hours 5 minutes. He could not recall who flew the 1st or 2nd leg. The CP stated the PIC flew the 1st and 2nd leg, and he started off flying the 3rd leg. The PIC stated he conducted the preflight inspection before departing LZU, and determined that the auxiliary fuel tanks and main fuel tanks were full of fuel. (See the pilot statement for fuel computations pertaining to the flight).

They departed LZU on the main fuel tanks near their scheduled departure time and climbed to 6, 000 feet. He switched the main fuel tanks to the auxiliary fuel tanks after they had been airborne for 1 hour 30 minutes. Ten minutes before their arrival time at JAN, he switched the auxiliary fuel tanks back to the main fuel tanks. He estimated his average fuel burn rate at 36.8 gallons per hour. They departed JAN at 2100 CST and climbed to 6,000 feet which took 15 minutes. He switched the fuel tanks to the auxiliary tanks for 25 minutes, and switched back to the main fuel tanks 10 minutes before arriving at NEW. Upon landing, he requested that 70 gallons of fuel be added to the airplane. The refueler could only put 33 gallons of fuel in each main fuel tank., and 2 gallons were put in each auxiliary fuel tank. The PIC stated he did not up date his weather before departing NEW, and an alternate airport was required at LZU. He did not know what the alternate airport was because he did not have a copy of the canned company flight plan. In addition, he did not recall any conversations with the CP regarding the weather conditions at LZU. The CP stated he was in the left front seat flying the airplane when they departed NEW at about 2310 CST. Review of recorded transcripts revealed they were airborne at 2226 CST (0426 UTC). The PIC stated they switched to the auxiliary fuel tanks 1 hour 30 minutes after takeoff, remained on the auxiliary fuel tanks for 14 minutes, and switched back to the main fuel tanks 10 minutes before starting the instrument approach at LZU. He called company operations inquiring about the weather conditions at LZU. The chief pilot stated he informed the PIC that other airplanes had been getting in, and he should have no problem. The PIC stated they were cleared for the ILS runway 25 approach at 0110 EST (0610 UTC). Review of transcripts revealed SBQ840 was cleared for the approach at 0619:24. The 0556 UTC Atlanta (ATL) surface weather observation was: 100 broken, 600 overcast, visibility 4 miles, fog, temperature 56 degrees Fahrenheit, dewpoint 56 degrees Fahrenheit, wind from 110 degrees at 4 knots, and altimeter29.98 in Hg. Review of transcripts revealed that SBQ840 made a missed approach at 0625:52 and requested another ILS at LZU. In addition, the PIC informed company operations that he had made a missed approach, and that he would try again. According to the Assistant Manager, Gwinnet County Briscoe Field Tower, there were no NOTAMS in effect at LZU concerning airport lighting. SBQ840 was provided radar vectors to the final approach course, and was cleared for the second ILS approach at 0632:31. SBQ840 stated at 0639:01, "yes sir skibble eight forty back with you and three thousand." SBQ840 stated at 0639:40, "sir eh let's go ahead and eh eh hold over the ndb we're receiving it now if that's okay with you and eh we'll eh wait and see if this other guy gets in and then we'll work it out from there." The controller informed SBQ840 that he would vector him around a little to keep him clear of the area, while they waited for the other airplane to try the approach. The chief pilot stated that SBQ840 called him and stated, "it was too low, he had gone missed again, and was going to ATL." He asked him to hold to see if the weather would improve. About 3 minutes later the chief pilot informed SBQ840 to proceed to ATL and to call him when he arrived. The PIC stated about 3 minutes after the second missed approach that they switched back to the auxiliary fuel tanks. He calculated with a calculator that he had the following fuel on board:

Left Main: 2.8 Right Main: 2.8 Left Aux: 12.42 Right Aux: 12.42

At 0645:22, SBQ840 informed Atlanta approach that they would like to proceed to Atlanta International Airport. SBQ840 was provided radar vectors for the ILS runway 8 left. The PIC stated he switched back to the main fuel tanks before starting the ILS approach. Review of transcripts revealed that SBQ940 was cleared for the approach at 0709:06 (0209:06 EST), and made a missed approach at 0714:23. The 0656 UTC, ATL surface weather observation was: 100 overcast, visibility 4 miles, temperature 56 degrees Fahrenheit, dewpoint 56 degrees Fahrenheit, wind from 110 degrees at 5 knots, and altimeter 29.99 inHg. The PIC requested the Fulton County (FTY) weather, another ILS approach at ATL. The FTY weather at 0646 UTC was: wind calm, visibility 3/4 of a mile, mist, ceiling 300 overcast, temperature and dewpoint missing, and altimeter 30.00 inHg. While they were being vectored for the approach the CP stated he put the airplane on autopilot, and he and the PIC changed seats so the PIC could fly the airplane. When asked how much fuel they had used for third approach, the PIC calculated with a calculator that they had used 5.7 gallons in the left and right main fuel tank. When the PIC started to subtract his calculations from the previous calculated fuel quantities, he realized that he had not been calculating the fuel that was being returned from the auxiliary fuel tanks to the main fuel tanks.

Review of transcripts revealed that SBQ840 was cleared for the approach at 0722:05, made a missed approach at 0727:33, and informed approach at 0727:41, "yes sir er we are running into a situation here we have about ah probably about forty minutes of fuel we need to find another place to go." SBQ840 was asked if he wanted to try FTY or if he had something else in mind. SBQ840 requested the weather at FTY which was provided by ATL approach. SBQ840 informed approach at 0728:58, "okay we'll go ahead and try fulton county." As SBQ840 was being vectored for the ILS approach at FTY, the controller informed him that the glideslope was unusable. SBQ840 requested to divert to Chattanooga, Tennessee (CHA), and to remain at 4,100 feet. A short time later, SBQ840 was instructed to climb to 6,000 feet. The chief pilot stated SBQ840 called on the radio and informed him that they were not able to get in at ATL and that he was going to CHA. He was informed that another company airplane had landed at LZU and asked if he would like to try LZU again. SBQ840 told him no, "he was low on fuel and would prefer CHA where weather conditions were reported as marginal," and indicated his auxiliary fuel tanks were empty. While in cruise flight SBQ840 requested the CHA weather at 0739:42. The controller informed SBQ840 that the CHA weather at 0653 was: winds 200 at nine, visibility 5 miles, mist, ceiling 800 variable to1,300. SBQ840 request