TCDS A00055SE

Page No. 1 2 3 Rev. No. DEPARTMENT OF TRANSPORTATION FEDERAL AVIATION ADMINISTRATION A00055SE Initial Release CUB CRAFTERS EL-1, Original Issue Date: March 22, 2018 TYPE CERTIFICATE DATA SHEET A00055SE This data sheet, which is part of Type Certificate No. A00055SE, prescribes conditions and limitations under which the product for which the type certificate was issued meets the airworthiness requirements of the Federal Aviation Regulations. Type Certificate Holder: Cub Crafters, Inc. 1918 South 16th Ave. Yakima, WA 98903 I - Model EL-1 (Normal Category), Approved March 22, 2018 Engine: Engine Manufacturer: Lycoming Engines, an Operating Division of AVCO Corporation Number of Engines: One (1) Engine TC Number: E-14EA Engine Model Designation: TIO-540-W2A Fuel: 100 (green) or 100LL (blue) grade aviation fuel. Engine Limits: Maximum takeoff power: 350 horsepower at 2600 RPM Maximum continuous power: 350 horsepower at 2600 RPM See Engine Type Certificate Data Sheet E-14EA for additional limitations. Propeller: Propeller Manufacturer: Hartzell Propeller, Inc. Number of Propellers: One (1) Three (3) blades Propeller TC Number: P-25EA Propeller Model Designation: Hub HC-C3YR-1RF, Blade F8468A-6R
 Diameter Limits: 80 inches. No diameter reduction allowed High Pitch angle: 34.0º ±1º at station 30” Low Pitch Angle: 12.4º±1º at station 30” See Propeller Type Certificate Data Sheet P-25EA for additional limitations. Airspeed Limits VO (4,140 lbs) 123 KCAS VFE (36º) 85 KCAS VNO 123 KCAS VNE 155 KCAS Center of Gravity Normal Category (C.G.) Range Aft Limits: 126” aft of datum (at all weights) Forward Limits: 117.9” aft of datum at 4,140 lbs. 112.0” aft of datum at 3,350 lbs. or less Straight line variation between points. Datum: Datum is 105.8” forward of the wing leading edge. Levelling means: seat tracks in cabin section Maximum Weights: Maximum Ramp: 4,140 lbs. A00055SE Page 2 of 3 Maximum Takeoff: 4,140 lbs. Maximum Landing: 4,140 lbs. Minimum Crew: One (1) Pilot Number of Seats: Two (2) seats total located at station 105.0 Maximum Compartment As defined in the latest approved revision of the EL-1 “Pilot’s Operating Handbook and Weights: FAA Approved Flight Manual”. Fuel Capacity: 105 gallons at station 135.0 (2 wing tanks) Oil Capacity: 12 quart total See Lycoming Service Instruction 1014 for approved oil . Maximum Operating 14,000 feet Altitude Control Surface Wing flaps: 0º, 15º, 30º, 36º ± 1.0º Movements: Ailerons: Up: 20º ± 1.0º Down 18º ± 1.0º Elevator: Up 26º ± 1.0º Down 19º ± 1.0º Elevator Trim: Up 14.0º ± 1.0º Down 29.0º ± 1.0º Rudder Left 26.0º ± 1.0º Right 26º ± 1.0º See the latest FAA approved revision of the EL-1 “Airplane Maintenance Manual, or other FAA approved data, for control system rigging instructions and setting flaps up (0º) configuration. Manufacturer’s The information contained herein is applicable to Serial Number E1. Serial Numbers: Certification Basis: Part 23 of the Federal Aviation Regulations (FAR) effective December 18, 1964, as amended by 23-1 through 23-62. FAR 36 as amended on the date of certification. Equivalent Level of Safety Finding Correction to errors in Amendment 23-62 in accordance with ELOS No TC6535NY-A-PSPM. TC Number: A00055SE TC Issuance Date: March 22, 2018 TC Application Date: August 28, 2017 Operational Limitations: Day Visual Flight Rules (VFR) Airframe Life Limits: 5,000 hours provided there are no changes to engine type or power or increase in gross weight, in which case compliance with 14 CFR§23.2240, amendment 64 or later amendment will be required. Production Basis: None. Equipment: The basic required equipment as prescribed in the applicable airworthiness regulations (see Certification Basis) must be installed in the aircraft for airworthiness certification. Additional Equipment The latest FAA Approved/ Revision of “EL-1 Pilot’s Operating Handbook and FAA Approved Necessary for Type Flight Manual”. Certification: NOTE 1: A current weight and balance report with a list of equipment included in the certificated empty weight must be provided for each aircraft at the time of original airworthiness certification. NOTE 2: The placards specified in the latest FAA Approved/Accepted Revision of “EL-1 Pilot’s Operating Handbook and FAA Approved Flight Manual,” are required. Page 3 of 3 A00055SE NOTE 3 The airplane must be subsequently maintained in accordance with the Instructions for Continued Airworthiness, and Airworthiness Limitations section, as contained in the latest FAA approved data. END