TCDS A21WE

P a g e N o . 1234 Rev. No. 5 - 4 - DEPARTMENT OF TRANSPORTATION FEDERAL AVIATION ADMINISTRATION A21WE Revision 5 FAIRCHILD C-119C C-119G February 10, 2003 TYPE CERTIFICATE DATA SHEET NO. A21WE This data sheet which is a part of type certificate No. A21WE prescribes conditions and limitations under which the product for which the type certificate was issued meets the airworthiness requirements of the Federal Aviation Regulations. Type Certificate Holder Aero Union Corporation 100 Lockheed Avenue Chico, California 95973 I - MODEL C-119C (RESTRICTED CATEGORY) Approved March 11, 1970 Engine 2 - Pratt & Whitney R4360-20 WD Fuel 115/145 Minimum Grade Aviation Gasoline Engine limits 2700 rpm (3500 hp) Take-off (5 minutes) (Rich Setting) 2550 rpm (2650 hp) Sea Level (Rich Setting) 2550 rpm (2355 hp) 10,000 ft. Alt. (Rich Setting) 2550 rpm (2100 hp) 14,000 ft. Alt. (Rich Setting) 2550 rpm (2145 hp) 20,000 ft. Alt. (Rich Setting) Propeller Hamilton Standard 24260-611 or 619 Blades 2J17Y3-26R or 2J17AE3-26R Airspeed limits Vne - Never exceed 225 mph (195 knots) Vc - Structural Cruising 203 mph (176 knots) Va - Maneuver 187 mph (162 knots) Flaps or gear extended 161 mph (140 knots) Max speed aerial delivery Doors Open 150 mph (130 knots) C.G. range Aft of datum +318.3" to +335.2" at all Wts. Datum Fus. Sta. 0 (103.8" forward of jig point fitting on front jack pad) Max. gross wt. (Aft 71,500 lb. (take-off) and 69,970 lb. (landing) Cargo Doors On) See NOTE 1(a). Max. zero fuel wt. 62,724 lb. (Outer wing tanks to be full before fuel is added to inner wing tanks) Leveling means Eye bolt at cabin ceiling station 310 for plumb bob suspension to crosslined plates under cargo floor between stations 310 and 333. No. seats Limited to the Flight Crew & number of persons essential to perform the intended function of this operation. Cargo Handlers - must wear safety harnesses that are secured to aircraft structure during all drop operations. A21WE Page 2 of 4 I - MODEL C-119C (RESTRICTED CATEGORY) (cont'd) Fuel capacity 3624 Gal. total - 2 outboard fuel tanks 855 Gal. each (+354.5) - 2 inboard fuel tanks 457 Gal. each (+354.5) - 2 auxiliary fuel tanks in fuselage 500 Gal. each (+338.0). Oil capacity 120 gal. total - 2 n acelle A/C Serial No. Applicable tanks 60 gal. each (+461.3) 48-319 thru 51-2584 120 gal. total - 2 nacelle tanks 60 gal. each (+338.4) 51-2587 and subsequent Cargo capacity See T.O. 1C-119B-5 Section III Control surface movements Aileron Up 24° + 1° Down 12° + 1° (See Sec. VIII T.O. Flettner Tab Up 17° + 4° -2° Down 30° + 6° -2° 1C-119C-2-1, Trim Tab Up 15° + 1 1/2° *Down 15° + 1 1/2° Page 8-4) Elevator Up 24 1/2° + 1 1/2° Down 20 1/2° + 1 1/2° Spring Tab Up 17° + 0° -5° Down 24° + 2° -0° Trim Tab Up 12° + 2° Down 22° + 2° Rudder Right 25° + 2° -0° Left 20° + 2° -0° Spring Tab Right 5° + 1° Left 5° + 1° Trim Tab Right 10 1/2° + 1° Left 10 1/2° + 1° Wing Flaps Take-off Down 15° Landing Down 40° *48-319 thru 50-161, Aileron Tab Spec. on 50-162 and subsequent is Down 12° ± 1 1/2°. Serial Nos. eligible 48-319 thru 48-355 49-101 thru 49-199 50-119 thru 50-171 51-2532 thru 51-2584 51-2587 thru 51-2661 51-8233 thru 51-8273 II - MODEL C-119G (RESTRICTED CATEGORY) Approved September 29, 1971 Engine 2 - Wright R-3550-89, -89A Fuel 115/145 Minimum Grade Aviation Gasoline Engine limits 2900 rpm (3500 hp) Take-off (5 minutes) Low Blower 2600 rpm (2600 hp) Sea Level (Low Blower) 2600 rpm (2400 hp) 10,000 ft. Alt. (High Blower) 2600 rpm (2400 hp) 14,000 ft. Alt. (High Blower) 2400 rpm (1780 hp) 20,000 ft. Alt. (High Blower) Propeller Aeroproducts A6441FN-C2 Airspeed limits Vne - Never exceed 225 mph (195 knots) Vc - Structural Cruising 203 mph (176 knots) Va - Maneuver 187 mph (162 knots) Flaps or gear extended 161 mph (140 knots) Max speed aerial delivery Doors Open 150 mph (130 knots) C.G. range Aft of datum +318.3" to +335.2" at all Wts. Datum Fus. Sta. 0 (103.8" forward of jig point fitting on front jack pad) Page 3 of 4 A21WE II - MODEL C-119G (RESTRICTED CATEGORY) (cont'd) Max. gross wt. (Aft 71,500 lb. (take-off) and 69,970 lb. (landing) Cargo Doors On) See NOTE 1(b). Max. zero fuel wt. 61,240 lb. (Outer wing tanks to be full before fuel is added to inner wing tanks) Leveling means Eye bolt at cabin ceiling station 310 for plumb bob suspension to crosslined plates under cargo floor between stations 310 and 333. No. seats Limited to the Flight Crew & number of persons essential to perform the intended function of this operation. Cargo Handlers - must wear safety harnesses that are secured to aircraft structure during all drop operations. Fuel capacity 3624 Gal. total - 2 outboard fuel tanks 855 Gal. each (+354.5) - 2 inboard fuel tanks 457 Gal. each (+354.5) - 2 auxiliary fuel tanks in fuselage 500 Gal. each (+338.0). Oil capacity Applicable Serial No. 120 gal. total - 2 nacelle 51-2662 thru 51-8030 tanks 60 gal. each (+338.4) 51-8098 thru 51-6168 51-17365 thru 51-17367 52-6000 thru 52-6003 53-8069 thru 53-8132 109 Gal. total - 2 nacelle 51-8031 thru 51-8097 tanks 54.5 gal. each (+338.4) 52-5840 thru 52-5954 (Applies to aircraft with 52-6004 thru 52-7884 Manufacturer's Serial No's. listed 53-8133 thru 53-8156 below) Cargo capacity See T.O. 1C-119G-1 Section V. Control surface movements Aileron Up 24° + 1° Down 12° + 1° (See Sec. VIII T.O. Flettner Tab Up 17° + 4° -2° Down 30° + 6° -2° 1C-119C-2-1, Trim Tab Up 15° + 1 1/2° Down 12° + 1 1/2° Page 8-4) Elevator Up 24 1/2° + 1 1/2° Down 20 1/2° + 1 1/2° Spring Tab Up 17° + 0° -5° Down 24° + 2° -0° Trim Tab Up 12° + 2° Down 22° + 2° Rudder Right 25° + 2° -0° Left 20° + 2° -0° Spring Tab Right 5° + 1° Left 5° + 1° Trim Tab Right 10 1/2° + 1° Left 10 1/2° + 1° Wing Flaps Take-off Down 15° Landing Down 40° Serial Nos. eligible Air Force Serial No's. Manufacturer's Serial No's. 51-2662 thru 51-8168 For aircraft exported and returned to 51-17365 thru 51-17367 United States: 52-6000 thru 52-7884 10676-10678 52-5840 thru 52-5954 10735-10738 53-8069 thru 53-8156 10773-10776 10823-10825 10859-10861 10870-10872 10905-10908 10942-10945 10954-10957 10992-10994 A21WE Page 4 of 4 SPECIFICATIONS PERTINENT TO ALL MODELS (EXCEPT WHERE NOTED) Certification basis FAR 21.25(a)(2) effective 1 February 1965 Application for Type Certificate dated 21 March 1968. Production basis None. Prior to original certification of each aircraft, an FAA representative must perform an inspection for workmanship, materials, and conformity with the approved technical data. Equipment The basic required equipment as prescribed in the applicable Airworthiness Regulations (see Certification Basis) must be installed in the aircraft for certification. For the C-119C, an FAA Approved Airplane Flight Manual Supplement dated July 19, 1974 is required in addition to the operating limitations specified in Sec. V of T.O. 1C-119C-1. For the C-119G, an FAA Approved Airplane Flight Manual Supplement dated 29 September 1971 is required in addition to the operating limitations specified in Sec. V of T.O. 1C-119G-1. NOTE 1. (a) Current weight and balance report and loading instructions for Model C-119C aircraft must agree with data on pages 16 thru 31 of Sec. III, T.O. 1C-119B-5. (b) Instructions for Model C-119G aircraft must agree with Sec. V of T.O. 1C-119G-1. NOTE 2. (a) This approval applies to: (1) Basic Air Force Airplane with no modification other than the internal floor rollers per Aero Union Corporation Dwg. No's. 7000 & 7001 and (2) Airplane certificated for special purpose of forest and wildlife conservation, with following limitations: a. Aft cargo door must be "ON" aircraft. (b) In addition to the operating limitations in this data sheet, area, economic, passenger and other appropriate operating limitations in accordance with FAR 21.25 shall be shown on placards or listing accessible to the pilot. (c) The following placards must be displayed in front of and in clear view of the pilot: (1) "This airplane must be operated as a restricted category airplane in compliance with the operating limitations stated in the form of placards, markings, and manuals." (d) Red radial line required on airspeed indicator at 195 Kts. (225 mph). .....END.....