AD 2010-25-05

Airworthiness directive · Turbine Discs · Rolls-Royce Deutschland BR700-710A1-10, BR700-710A2-20 and BR700-710C4-11

Effective
January 13, 2011
Published
December 9, 2010 · 75 FR 76624–76626
Issued
November 30, 2010
Models
BR700-710A1-10, BR700-710A2-20, BR700-710C4-11
Data sheet
TCDSE00057EN
Registered aircraft
1,165 matched by model
Product
Engine
Amendment
39-16538
Docket
FAA-2010-0614
Project
2010-NE-24-AD
Issued as
Final rule

Unofficial copy from the Federal Register XML, document 2010-30832. Only the govinfo PDF is the legal edition. DRS record last changed May 30, 2024.

On this page

Summary

We are adopting a new airworthiness directive (AD) for the products listed above. This AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as:

Due to manufacturing problems of BR700-710 HP stage 1 and 2 turbine discs it was necessary to re-calculate the Declared Safe Cyclic Life (DSCL) for all BR700-710 HP turbine discs. The analysis concluded that it is required to reduce the approved life limits for the HP turbine disc part numbers that are listed in Table 1 and Table 2 of this AD (MCAI). Exceeding the revised approved life limits could potentially result in non-contained disc failure.

We are issuing this AD to prevent-failure of the high-pressure turbine (HPT) stage 1 and stage 2 discs, uncontained engine failure, and damage to the airplane.

The airworthiness directive

2010-25-05 Rolls-Royce Deutschland Ltd & Co KG (formerly Rolls-Royce Deutschland GmbH, formerly BMW Rolls-Royce GmbH): Amendment 39-16538. Docket No. FAA-2010-0614; Directorate Identifier 2010-NE-24-AD.

(a) Effective Date

PDF page 2

(a) This airworthiness directive (AD) becomes effective January 13, 2011.

(b) Affected ADs

PDF page 2

(b) None.

(c) Applicability

PDF page 2

(c) This AD applies to Rolls-Royce Deutschland Ltd & Co KG models BR700-710A1-10, BR700-710A2-20, and BR700-710C4-11 turbofan engines with any of the high-pressure turbine (HPT) stage 1 and stage 2 discs installed as listed by part number (P/N) in Table 1 and Table 2 of this AD. These engines are installed on, but not limited to, Gulfstream model G-V and GV-SP airplanes, and Bombardier model BD-700-1A10 and BD-700-1A11 airplanes.

Table 1—Declared Safe Cyclic Life of Affected HPT Stage 1 Discs
HPT stage 1 disc P/NEngine modelDeclared safe cyclic life (flight cycles)
BRR21215BR700-710A1-106,075
BRR21215BR700-710A2-205,950
BRR22005BR700-710A1-106,200
BRR22005BR700-710A2-206,200
BRR22006BR700-710A1-106,200
BRR22006BR700-710A2-206,200
BRR22007BR700-710A1-106,200
BRR22007BR700-710A2-206,200
BRR22358BR700-710A1-106,200
BRR22358BR700-710A2-206,200
BRR23864BR700-710A1-106,200
BRR23864BR700-710A2-206,200
BRR23884BR700-710A1-106,200
BRR23884BR700-710A2-206,200
BRR23885BR700-710A1-106,200
BRR23885BR700-710A2-206,200
BRR23952BR700-710A1-106,200
BRR23952BR700-710A2-206,200
BRR23952BR700-710C4-11 (Service Bulletin (SB) No. SB-BR700-72-101466 not incorporated)6,200
BRR23952BR700-710C4-11 (SB No. SB-BR700-72-101466 incorporated)3,800
BRR23953BR700-710A1-106,200
BRR23953BR700-710A2-206,200
BRR23953BR700-710C4-11 (SB No. SB-BR700-72-101466 not incorporated)6,200
BRR23953BR700-710C4-11 (SB No. SB-BR700-72-101466 incorporated)3,800
BRR23954BR700-710A1-106,200
BRR23954BR700-710A2-206,200
Table 2—Declared Safe Cyclic Life of Affected HPT Stage 2 Discs
HPT stage 2 disc P/NEngine modelDeclared safe cyclic life (flight cycles)
BRR18291BR700-710A1-109,300
BRR21214BR700-710A1-109,600
BRR21214BR700-710A2-209,600
BRR22008BR700-710A1-1010,500
BRR22008BR700-710A2-2010,500
BRR22008BR700-710C4-11 (SB No. SB-BR700-72-101466 not incorporated)10,500
BRR22008BR700-710C4-11 (SB No. SB-BR700-72-101466 incorporated)3,700
BRR22009BR700-710A1-1010,500
BRR22009BR700-710A2-2010,500
BRR22009BR700-710C4-11 (SB No. SB-BR700-72-101466 not incorporated)10,500
BRR22009BR700-710C4-11 (SB No. SB-BR700-72-101466 incorporated)3,700
BRR22010BR700-710A1-1010,500
BRR22010BR700-710A2-2010,500
BRR22359BR700-710A1-1010,500
BRR22359BR700-710A2-2010,500

(d) Reason

PDF page 3

(d) This AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI states:

Due to manufacturing problems of BR700-710 HP stage 1 and 2 turbine discs it was necessary to re-calculate the Declared Safe Cyclic Life (DSCL) for all BR700-710 HP turbine discs. The analysis concluded that it is required to reduce the approved life limits for the HP turbine disc part numbers that are listed in Table 1 and Table 2 of this AD (MCAI). Exceeding the revised approved life limits could potentially result in non-contained disc failure.

We are issuing this AD to prevent failure of the HPT stage 1 and stage 2 discs, uncontained engine failure, and damage to the airplane.

(e) Actions and Compliance

PDF page 3

(e) Unless already done, do the following actions.

(1) Within 30 days after the effective date of this AD, or upon accumulating the declared safe cyclic life indicated in Table 1 or Table 2 of this AD as applicable, whichever occurs later, initially replace the HPT stage 1 or HPT stage 2 discs with serviceable discs.

(2) Thereafter, upon accumulating the declared safe cyclic life indicated in Table 1 or Table 2 of this AD, as applicable, repetitively replace the HPT stage 1 or HPT stage 2 discs with serviceable discs.

(f) FAA AD Differences

PDF page 3

(f) None.

(g) Alternative Methods of Compliance (AMOCs)

PDF page 3

(g) The Manager, Engine Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19.

(h) Related Information

PDF page 3

(h) Refer to European Aviation Safety Agency AD 2010-0075, dated April 20, 2010, and AD 2010-0076, dated April 20, 2010, for related information.

(i) Refer to Rolls-Royce Deutschland Ltd & Co KG SB No. SB-BR700-72-A900492, dated February 12, 2010, and SB No. SB-BR700-72-A900497, dated February 12, 2010, for related information. Contact Rolls-Royce Deutschland Ltd & Co KG, Eschenweg 11, Dahlewitz, 15827 Blankenfelde-Mahlow, Germany, telephone: +49 (0) 33-7086-1883, fax: +49 (0) 33-7086-3276, for a copy of this service information.

(j) Contact Mark Riley, Aerospace Engineer, Engine Certification Office, FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; e-mail: mark.riley@faa.gov; telephone (781) 238-7758; fax (781) 238-7199, for more information about this AD.

Rule preamble

The FAA’s background, reasoning and cost estimate, published with the AD.

DatesPage 1

This AD becomes effective January 13, 2011.

AddressesPage 1

The Docket Operations office is located at Docket Management Facility, U.S. Department of Transportation, 1200 New Jersey Avenue, SE., West Building Ground Floor, Room W12-140, Washington, DC 20590-0001.

For further information contactPage 1

Mark Riley, Aerospace Engineer, Engine Certification Office, FAA, Engine & Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; e-mail: mark.riley@faa.gov; telephone (781) 238-7758; fax (781) 238-7199.

DiscussionPage 1

We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to the specified products. That NPRM was published in the Federal Register on August 23, 2010 (75 FR 51693). That NPRM proposed to correct an unsafe condition for the specified products. The MCAI states that:

Due to manufacturing problems of BR700-710 HP stage 1 and 2 turbine discs it was necessary to re-calculate the Declared Safe Cyclic Life (DSCL) for all BR700-710 HP turbine discs. The analysis concluded that it is required to reduce the approved life limits for the HP turbine disc part numbers that are listed in Table 1 and Table 2 of this AD (MCAI). Exceeding the revised approved life limits could potentially result in non-contained disc failure.

CommentsPage 1

We gave the public the opportunity to participate in developing this AD. We received no comments on the NPRM or on the determination of the cost to the public.

ConclusionPage 1

We reviewed the available data and determined that air safety and the public interest require adopting the AD as proposed.

Costs of CompliancePage 1

Based on the service information, we estimate that this AD will affect about 1,026 BR700-710 engines of U.S. registry. We also estimate that no additional labor cost will be incurred to replace the discs. The average labor rate is $85 per work-hour. Required parts will cost about $6,000 per disc. Based on these figures, we estimate the cost of the AD on U.S. operators to be $6,156,000. Our cost estimate is exclusive of possible warranty coverage.

Authority for This RulemakingPage 1

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. “Subtitle VII: Aviation Programs,” describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in “Subtitle VII, Part A, Subpart III, Section 44701: General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory findingsPage 2

We determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify this AD:

1. Is not a “significant regulatory action” under Executive Order 12866;

2. Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and

3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket.

Examining the AD DocketPage 2

You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (phone (800) 647-5527) is provided in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

Adoption of the amendmentPage 2

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

1. The authority citation for part 39 continues to read as follows:

2. The FAA amends § 39.13 by adding the following new AD:

Affected TCDS · 1

The type certificate data sheets for the models this AD names, matched by model and maker.

Registered aircraft · 1,165

Registered aircraft whose airframe or engine model this AD names. Matched by model only, so check each against the AD’s applicability.

By aircraft maker
  • Gulfstream Aerospace677 aircraft
  • Bombardier392 aircraft
  • Boeing93 aircraft
  • Bombardier Aerospace1 aircraft
  • Cessna1 aircraft
  • Dassault1 aircraft
By year built
19962025
Registered aircraft by year built: 1,127 aircraft
19963
199723
199825
199949
200066
200167
200238
200330
200443
200534
200643
200752
200855
200943
201037
201145
201263
201365
201468
201570
201656
201751
201848
201917
202019
20218
20223
20231
20242
20253

38 with no year recorded

By model

Aircraft

See all 1,165 aircraft