AD 2016-07-19

This AD becomes effective May 9, 2016.

For service information identified in this AD, contact Technify Motors GmbH, Platanenstrasse 14, D-09356 Sankt Egidien, Germany; phone: +49-37204-696-0; fax: +49-37204-696-2912; email: support@continentaldiesel.de. You may view this service information at the FAA, Engine & Propeller Directorate, 1200 District Avenue, Burlington, MA. For information on the availability of this material at the FAA, call 781-238-7125. It is also available on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-5193.

Philip Haberlen, Aerospace Engineer, Engine Certification Office, FAA, Engine & Propeller Directorate, 1200 District Avenue, Burlington, MA 01803; phone: 781-238-7770; fax: 781-238-7199; email: philip.haberlen@faa.gov.

We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 by adding an AD that would apply to the specified products. The NPRM was published in the Federal Register on January 4, 2016 (81 FR 27). The NPRM proposed to correct an unsafe condition for the specified products. The MCAI states:

In-flight shut down occurrences have been reported on aeroplanes equipped with TAE 125-02 engines. The initial results of the investigations showed that a defective fuel feed pump was the probable cause of the engine failure.

You may obtain further information by examining the MCAI in the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2015-5193.

We gave the public the opportunity to participate in developing this AD. We received no comments on the NPRM (81 FR 27, January 4, 2016).

We reviewed the available data and determined that air safety and the public interest require adopting this AD as proposed.

Technify Motors GmbH has issued Operation & Maintenance Manual, CD-135/CD-155, OM-02-02, Issue 4, Revision No. 5, dated September 18, 2015. The service information describes procedures for removing and replacing the fuel feed pump.

We estimate that this AD affects 190 engines installed on airplanes of U.S. registry. We also estimate that it will take about 0.5 hours per engine to comply with this AD. The average labor rate is $85 per hour. Pro-rated cost of the life limit reduction is about $160 per part. Based on these figures, we estimate the cost of this AD on U.S. operators to be $38,475.

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. “Subtitle VII: Aviation Programs,” describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in “Subtitle VII, Part A, Subpart III, Section 44701: General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

We determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify this AD:

(1) Is not a “significant regulatory action” under Executive Order 12866,

(2) Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),

(3) Will not affect intrastate aviation in Alaska to the extent that it justifies making a regulatory distinction, and

(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

1. The authority citation for part 39 continues to read as follows:

2. The FAA amends § 39.13 by adding the following new airworthiness directive (AD):