AD 2017-07-09

This AD is effective May 12, 2017.

For service information identified in this final rule, contact Sikorsky Aircraft Corporation, Customer Service Engineering, 124 Quarry Road, Trumbull, CT 06611; telephone 1-800-Winged-S or 203-416-4299; email: wcs_cust_service_eng.gr-sik@lmco.com. You may review a copy of the referenced service information at the FAA, Office of the Regional Counsel, Southwest Region, 10101 Hillwood Pkwy., Room 6N-321, Fort Worth, TX 76177.

Kristopher Greer, Aerospace Engineer, Boston Aircraft Certification Office, Engine & Propeller Directorate, FAA, 1200 District Avenue, Burlington, Massachusetts 01803; telephone 781-238-7799; email Kristopher.Greer@faa.gov.

On August 30, 2016, at 81 FR 59526, the Federal Register published our notice of proposed rulemaking (NPRM), which proposed to amend 14 CFR part 39 by adding an AD that would apply to Sikorsky Model S-92A helicopters with a housing part number (P/N) 92358-06107-043 installed. The NPRM proposed to require removing from service any housing with 12,200 or more hours TIS. The NPRM was prompted by fatigue analysis conducted by Sikorsky that determined the housing required a retirement life. The proposed actions were intended to prevent a crack in the housing, which could lead to loss of tail rotor drive and loss of helicopter control.

After our NPRM was published, we received a comment from Sikorsky.

Sikorsky requested a minimum 45-day extension of the comment period. In support of this request, Sikorsky stated it is re-evaluating the housing's 12,200-hour life limit due to an error in the measured flight test loads used in the structural fatigue substantiation. When asked for additional information, Sikorsky advised that it had completed its re-evaluation and determined that the 12,200-hour life limit was, in fact, correct.

We have reviewed the relevant information and determined that an unsafe condition exists and is likely to exist or develop on other products of these same type designs and that air safety and the public interest require adopting the AD requirements as proposed.

We reviewed Sikorsky S-92 Maintenance Manual 4-00-00, Temporary Revision No. 4-49, dated April 10, 2015, which establishes a replacement interval of 12,200 hours for housing, P/N 92358-06107-043.

We estimate that this AD affects 80 helicopters of U.S. Registry and that labor costs average $85 per work hour. Based on these estimates, we expect the following costs.

Replacing the housing requires 24 work-hours, and parts cost $58,000 for a total cost of $60,040 per helicopter.

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701: “General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

This AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that this AD:

(1) Is not a “significant regulatory action” under Executive Order 12866;

(2) Is not a “significant rule” under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979);

(3) Will not affect intrastate aviation in Alaska to the extent that it justifies making a regulatory distinction; and

(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared an economic evaluation of the estimated costs to comply with this AD and placed it in the AD docket.

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

1. The authority citation for part 39 continues to read as follows:

2. The FAA amends § 39.13 by adding the following new airworthiness directive (AD):