- Date
- June 30, 2004, 20:00 local (Jul 1, 2004, 00:00 UTC)
- Place
- Childs, FL
- Injuries
- 1 uninjured
- Damage
- Substantial damage
- Phase of flight
- Standing
- Aircraft
- N128FCBell UH-1H
- Weather
- Visual (VMC) · Dusk
- Status
- Completed · report June 8, 2005
- Report
- Approved by Office Director
- Parties
- Orlando FSDO
- FAA report
- 20040630032699A
- Case key
- 59760
From the NTSB’s public API. By law, NTSB reports can’t be used as evidence in lawsuits over the accident.
On this page
Probable cause
The vehicle driver's inadequate visual lookout and his failure to maintain clearance. A factor was the lack of company standards and operation procedures.
Sequence of events
NTSB’s coding before 2008: each occurrence and phase of flight, and the causes and factors under it. The codes are defined in NTSB’s coding manual.
Analysis
According to the pilot after landing, he noticed that one of the skids were off of the pavement and was beginning to settle in the ground. The pilot lifted the helicopter to reposition the skid on the pavement. At the same time, the refuel trailer was being pulled forward towards the helicopter. After the helicopter was positioned on the pavement, the refueling trailer continued towards the helicopter until it struck the right synchronized elevator on the tail boom assembly. Examination of the helicopter revealed the right synchronized elevator was buckled. No flight control or mechanical anomalies were reported by the pilot. Review of the USDA Forest Service operating procedures revealed that there were no operating procedures for "hot" refueling. Subsequent to this accident procedures have been adopted to prevent another reoccurrence of this accident.
Factual narrative
On June 30, 2004, at 2000 eastern daylight time, a Bell UH-1H helicopter, N128FC, registered to and operated by the USDA Forest Service FEPP, was struck by a fuel trailer while the driver of the refueling vehicle positioned to refuel the standing helicopter near Childs, Florida. The public use flight was conducted under the provisions of Title 14 CFR Part 91 with no flight plan filed. Visual meteorological conditions prevailed at the time of the accident. The commercial pilot was uninjured and helicopter sustained substantial damaged. The flight was participating in a wildlife fire operation in the vicinity of Childs, Florida, on June 30, 2004 at 1800.
According to the pilot, while participating in a wildfire operation, he maneuvered the helicopter to land and conduct a "hot" refueling. After landing, the pilot noticed that one of the skids were off of the pavement and was beginning to settle in the ground. The pilot lifted the helicopter to reposition the skid on the pavement. At the same time, the refuel trailer was being pulled forward towards the helicopter. After the helicopter was positioned on the pavement, the refueling trailer continued towards the helicopter until it struck the right synchronized elevator on the tail boom assembly.
Examination of the helicopter revealed the right synchronized elevator was buckled. No flight control or mechanical anomalies were reported by the pilot. Review of the USDA Forest Service operating procedures revealed that there were no operating procedures for "hot" refueling. Subsequent to this accident procedures have been adopted to prevent reoccurrence of this type accident.
Aircraft
- Registration
- N128FC
- Reported as
- Bell UH-1H
- Category
- Helicopter
- Serial number
- 64-13750
- Airframe hours
- 6,607
- Engine
- Lycoming T53-L-703, 1,600 lbs thrust, turbo shaft
- Damage
- Substantial damage
- Flight
- Public aircraft · Public use
- Operator
- USDA Forest Service, doing business as Florida Division of Forestry
- Registered owner
- Florida Depatment of Agr
- Airworthiness certificate
- Special, Special flight (Special)
- Last inspection
- AAIP · April 1, 2004 · 34 hours before
- Departed
- FMY · Fort Myers, FL
- Destination
- Okeechobee, FL
Matched to the registry by N-number and the event date; the registry’s history has gaps, so older matches can be wrong. Compare the reported make and model.
Flight crew
As NTSB recorded them. NTSB leaves out names.
- Role
- Pilot
- Age
- 54
- Injuries
- None
- Certificate
- Commercial
- Airplane ratings
- Multi-engine land, Single-engine land
- Instrument ratings
- Airplane, Helicopter
- Medical
- Class 2, Valid Medical--w/ waivers/lim
- Last flight review
- April 22, 2004
- Seat
- Front
- Flight hours
- 6,000 total
Weather
- Conditions
- Visual (VMC) · Dusk
- Wind
- 110° at 4 knots
- Visibility
- 10 statute miles
- Lowest ceiling
- 7,000 ft broken
- Temperature
- 77 °F, dew point 73 °F
- Altimeter
- 29.87 inHg
- Observed at
- FMY, 25 nm away
FAA reports on this event · 1
The FAA’s own accident and incident reports, matched to the aircraft by N-number and date.