CEN11LA005

NTSB accident investigation · Maule MXT-7-180A · Magnolia, AR · October 2, 2010

Accident · No injuriesLimited investigationFinal report
Date
October 1, 2010, 21:00 local (Oct 2, 2010, 02:00 UTC)
Place
Magnolia, AR
Injuries
2 uninjured
Damage
Substantial damage
Phase of flight
Enroute
Aircraft
N152HSMaule MXT-7-180A
Defining event
Enroute-cruise: Loss of engine power (total)
Weather
Visual (VMC) · Night
Status
Completed · report May 16, 2011
Report
Approved by Office Director
NTSB office
Central Region
Parties
FAA/FSDO
FAA report
20101001047779A
Case key
77490

From the NTSB’s public API. By law, NTSB reports can’t be used as evidence in lawsuits over the accident.

On this page

Probable cause

The mechanic's failure to properly install an oil drain line after he replaced a cylinder, which caused the engine to seize in flight due to a lack of lubrication.

Findings · 1

NTSB’s coded findings. Those marked are part of the probable cause; the rest are factors or other findings. Under each, the cases with the same finding.

Eng oil sys (airframe furnish): eng oil dist (airframe furn)Aircraft › Aircraft power plant · Inadequate inspectionMaule MXT-7-180A: 1 caseAll aircraft: 18 casesProbable cause

Sequence of events

The events NTSB coded, in order, by phase of flight. The defining event is the one that best describes the accident. Under each, the cases with the same event anywhere in their sequence.

Analysis

The pilot was on a night cross-country flight when he heard a knocking sound in the engine. He immediately proceeded toward the nearest airport, declared an emergency, and noted that the oil pressure gauge read "0" and the oil temperature gauge read "high." When the airplane was about 5 miles south of the airport, and at an altitude of 1,700 feet, the engine seized. The pilot made a forced landing to a field and subsequently collided with a fence, causing substantial damage to the airplane. Examination of the engine revealed a large hole in the top of the crankcase and that the oil drain line for the No. 4 cylinder was not connected. A review of the engine logbook indicated that the No. 2 cylinder had been removed on the day of the accident, which would have required the No. 4 cylinder oil drain line to be disconnected. When the cylinder was placed back on the engine, the oil drain line was likely not reconnected and properly torqued per the manufacturer's maintenance manual.

Factual narrative

On October 1, 2010, at 2100 central daylight time, a Maule MXT-7-180-A, N152HS, sustained substantial damage during a forced landing after a total loss of engine power near Magnolia, Arkansas. The private pilot and a passenger were not injured. The airplane was registered to and operated by Henderson State University (HSU), Arkadelphia, Arkansas. Night visual meteorological conditions prevailed and no flight plan was filed for the flight that departed Monroe Regional Airport (MLU), Monroe, Louisiana, approximately 2030, and destined for Texarkana Regional Airport (TXK), Texarkana, Arkansas. The cross country flight was conducted under 14 Code of Federal Regulations Part 91 as part of HSU's commercial pilot curriculum. According to the pilot, he was at 2,500 feet about 15 miles south of Magnolia Municipal Airport (AGO), Magnolia, Arkansas, when he heard a knocking sound in the engine. He immediately proceeded toward AGO, declared an emergency, and noted that the oil pressure gage read "0" and the oil temperature gage was "high." When the airplane was about 5 miles south of the airport and at an altitude of 1,700 feet, the engine seized. The pilot noted a small clearing and landed on a private horse farm. He said there was no visible moon and it was very dark outside, which made it difficult to see the terrain and he subsequently collided with corral fencing before coming to a full stop. A Federal Aviation Administration (FAA) inspector performed an on-scene examination of the airplane, which revealed that the nosegear of the airplane collapsed and was pushed aft and the top of the fuselage center section was damaged. The firewall, left horizontal stabilizer and elevator sustained substantial damage. A large amount of oil was noted on the under side of the engine and belly of the airplane. Examination of the engine revealed there was a large hole in the top of the crankcase and the oil drain line for the #4 cylinder was not connected. A review of the engine logbook revealed that the #2 cylinder had been removed on the day of the accident, which would have required the #4 cylinder oil drain line to be disconnected. When the cylinder was placed back on the engine, the oil drain line should have been reconnected and properly torqued per the manufacturer's maintenance manual. In a written statement, the mechanic that replaced the #2 cylinder said that after he replaced the cylinder he performed an engine run and checked for leaks. No leaks were observed. The mechanic placed the cowling back on the engine, completed the 100-hour inspection paperwork and returned the airplane back to service. He stated that all work was performed in accordance with the Maule inspection guide, Lycoming direct drive overhaul manual, and a 4,313-lb torque wrench. The pilot held a private pilot certificate for airplane single-engine land. His last Federal Aviation Administration (FAA) first class medical was issued on August 20, 2007. The pilot reported a total of 128hours, of which, 34 hours were in the Maule.

Aircraft

Registration
N152HS
Reported as
Maule MXT-7-180A
Category
Airplane
Serial number
21095C
Engine
Lycoming O-360-C4F, 180 horsepower, reciprocating
Damage
Substantial damage
Flight
Personal · Part 91
Operator
Henderson State University
Registered owner
Henderson State University
Airworthiness certificate
Standard, Normal
Departed
SHV · Shreveport, LA
Destination
M89 · Arkadelphia, AR
Flight plan
VFR
Airport
AGO · Magnolia Municipal

Matched to the registry by N-number and the event date; the registry’s history has gaps, so older matches can be wrong. Compare the reported make and model.

Flight crew

As NTSB recorded them. NTSB leaves out names.

Role
Pilot
Age
21
Injuries
None
Certificate
Private
Airplane ratings
Single-engine land
Medical
Class 1, Without waivers/limitations
Seat
Left
Flight hours
150 total · 150 in this make and model

Weather

Conditions
Visual (VMC) · Night
Visibility
10 statute miles
Lowest ceiling
None
Temperature
61 °F, dew point 41 °F
Altimeter
30.01 inHg
Observed at
ELD, 20 nm away

Docket · 5

The files NTSB released with the investigation on February 4, 2011, on NTSB’s docket system: statements, records, photos and specialists’ reports. 1.9 MB in all.

FAA reports on this event · 1

The FAA’s own accident and incident reports, matched to the aircraft by N-number and date.