IAD98FA106

The airplane was on an IFR flight plan, level at 16,000 feet, when radar and radio contact was lost. The tops of the clouds in the area of the accident were reported to be at 18,000 feet. A pilot who was flying in the area of the accident site at the time of the accident stated that the cloud tops of 'the buildups' were from 16,000 to 20,000 feet. The pilot additionally stated that moderate unexpected turbulence was encountered and 'Obviously, the updrafts in the area were very strong.' Satellite imagery data revealed that an east-west cloud band, about 10 miles wide, was located in the area of the accident. The ground track of the airplane was traversing the cloud band during the minutes prior to and around the accident time. The onboard weather radar was found in the off position. According to Advisory Circular -00-6A, 'Do avoid by at least 20 miles any thunderstorm identified as severe or giving an intense radar echo. Do clear the top of a known or suspected severe thunderstorm by at least 1,000 feet altitude for each 10 knots of wind speed at the cloud top.' The airplanes calibrated airspeed (KCAS) was calculated at 141 knots, and the indicated airspeed (KIAS) was 139 knots. According to the POH, the maneuvering speed at gross weight was 135 KCAS and 133 KIAS.

History of flight

On September 7, 1998, about 1945 Eastern Daylight Time, a Piper PA-46-350P, N9150X, was destroyed during an in-flight breakup near Centerville, New York. The certificated private pilot and four passengers were fatally injured. Visual meteorological conditions prevailed and an instrument flight rules flight plan was filed for the flight conducted under 14 CFR Part 91. The flight originated from the Manchester Airport (MHT), Manchester, New Hampshire, at 1720, and was destined for the Griffith-Merrillville Airport (05C), Griffith, Indiana.

The Cleveland Air Route Traffic Control Center (ARTCC) reported that radar and radio contact was lost with the airplane, while it was at 16,000 feet over the COLDE intersection. The ARTCC controller stated that other airplanes in the vicinity of the COLDE intersection did not report any significant weather or turbulence. The tops of the clouds were reported to be at 18,000 feet. Within 30 minutes of losing radar contact, local authorities found debris from the airplane, but due to rain and darkness, the fuselage was not located until 2250.

A pilot who was flying a turbo-prop airplane in the area of the accident site at the time of the accident stated that there were numerous cumulonimbus buildups throughout upstate New York. The pilot estimated the cloud tops of "the buildups" were from 16,000 to 20,000 feet. The "cells" were isolated enough that he could successfully navigate around or above the clouds. As the flight passed just west of Rochester (ROC), New York, the airplane was turned southwesterly. It was in that vicinity that the flight flew over a buildup, with tops estimated at 14,000 feet. Moderate unexpected turbulence was encountered, which lasted for approximately 1 minute. The pilot additionally added, "Obviously, the updrafts in the area were very strong."

The accident occurred during the hours of daylight approximately 42 degrees, 29 minutes north latitude, and 78 degrees, 17 minutes west longitude.

Personnel information

The pilot held a private pilot certificate with ratings for airplane single engine land, and instrument airplane.

The pilot's most recent Federal Aviation Administration (FAA) third class medical certificate was issued on March 26, 1998.

A review of the pilot's logbook revealed the pilot recorded 910 hours of total flight experience. The pilot logged 21 hours in the accident airplane between August 1996, and July 1998.

Aircraft information

The last annual inspection of the airplane was completed on December 10, 1997. The airframe had accumulated 1,773.6 hours of total time at the time of the inspection. The last recorded maintenance was on August 20, 1998, which consisted of an engine oil and filter change. The airframe had accumulated 1,861.4 hours at the time of the maintenance.

Meteorological information

A Safety Board meteorologist completed a weather study and a Meteorological Factual Report. According to the weather briefing section of the report:

A Surface Analysis chart prepared by the National Weather Service (NWS) National Centers for Environmental Prediction (NCEP) for September 7, at 2000 hours, showed an area of low pressure centered over northern Vermont. A cold front extended from the low, south southwestward through eastern New York-Pennsylvania, then west southwestward through central West Virginia, northern Kentucky, and then into the central United States. Also, the chart indicated generally moderate to strong northwesterly surface winds behind the front over most of the northeastern states.

GOES-8 (Geostationary Operational Environmental Satellite-8) data for the accident area during the period from 1845 to 1945 were obtained through Man Computer Interactive Data System and displayed on a Safety Board workstation. "Looping" of the data revealed that an east-west cloud band located from south of Buffalo (BUF), New York, to southeast of ROC, which slowly drifted south during the hour. Also, the information indicated that the cloud band was around 10 nautical miles wide. The ground track of accident airplane was overlaid on the 1945 data and showed that the airplane was traversing the cloud band during the minutes prior to and around the accident time.

The Aviation Area Forecast for western/central New York, on September 7, at 1345, stated scattered clouds at 3,000 feet, broken clouds at 8,000 feet, cloud tops at FL250. Occasional broken clouds at 3,000 feet, in widely scattered moderate rain showers. Isolated thunderstorms with light rain until 2000. Cumulonimbus tops at FL400. The outlook, valid September 8, from 0200-0800, called for marginal visual flight rules ceiling, rain showers, and mist. Occasional overcast clouds at 1,500 feet, in scattered thunderstorms, and moderate rain. Thunderstorms were to be in lines, possibly severe. Cumulonimbus cloud tops above FL450.

In-Flight Advisories (AIRMETs TANGO and ZULU) issued at 1545, did not forecast any turbulence or icing for New York. AIRMET SIERRA, also issued at 1545, forecasted occasional mountain obscuration for portions of the airplane's flight route.

There were no SIGMETs or Convective SIGMETs issued during the period 1400 to 2000 that were valid for the accident area. The Cleveland Center Weather Service Unit (CWSU) issued no Center Weather Advisories (CWAs) for the accident area.

The Winds Aloft Forecasts at 18,000 feet for the BUF area, issued by the NCEP on September 7, at 1240, were from 270 degrees at 62 knots, and a temperature of -10 degrees Celsius.

Wreckage and impact information

The wreckage debris field was oriented from the southeast to the northwest with the furthest pieces about 1.1 miles apart. The vertical stabilizer with the rudder attached, the left elevator, and the right horizontal stabilizer with the elevator attached were found in the southeast area. The left horizontal stabilizer, the outboard portions of both left and right wings were in-between the northwest and southeast parts. The fuselage and the left aileron were in the northwest area.

The fuselage was found in a wooded area, upright and facing about 050 degrees magnetic. The missing tree canopies over the fuselage displayed broken tree limbs, and scratching was observed from the top of a 40-foot tall tree down to ground level on the trunk.

The fuselage was split in two areas, aft of the cockpit, and immediately in front of the aft pressure bulkhead, with the tail cone swung open as if hinged on the left side of the empennage. The engine, which displayed no external signs of malfunction, incurred crushing to its underside. The propeller blades impacted the ground in the horizontal position, with no evidence of cord wise scratching. The left landing gear was found in the down position, and the right landing gear in the up position, underneath the 10-foot stubbed right wing. The left aileron was found in a pasture about 300 feet west-southwest of the fuselage. The right aileron was not found.

Examination of the debris revealed that all the wing attach fittings were accounted for at the accident site. The fracture surfaces of both wings displayed compression on the upper skin surfaces, and tension on the bottom surfaces. The outboard section of the right wing contained a puncture forward of the refueling cap, with blue paint markings found on the inside metal of the hole. The blue vertical stabilizer and rudder displayed an indentation near the top, while the vertical stabilizer cap was not recovered. The aileron cables for both wings displayed damages at the fractured ends consistent with tension overload. Both rudder cables were found attached to the bell crank.

The right horizontal stabilizer, along with the right portion of the elevator still attached, displayed signs of twisting and downward, aft rotation at the attach points. The forward attach bolt, as well as the horizontal rear fusela